Technologies developed in the last decade have made viable the use of lignocellulosic materials for the production of ethanol. However, to improve the fermentative yield some improvements are necessary, among them the search for new microorganisms capable of fermenting sugars with five carbons. Thus, the present research aimed to determine the best pH and temperature for Pichia membranifaciens LJ04 in synthetic medium containing pentose, aiming at the biotechnological production of ethanol from hemicellulosic hydrolysate. The experimental design was completely randomized in Split-Split-Plot, with 3 replicates. The main treatments were pHs (3.5, 4.0 and 4.5), the secondary were temperatures (32 ºC, 37 ºC and 40 ºC) and the tertiary were fermentation periods (0, 6, 12 and 24 hours). It was determined in this study that the ideal conditions were temperature of 32 ºC and pH 4.0-4.5. With these conditions there was higher xylose consumption, high ethanol production, low production of secondary compounds and high rates of cell viability during fermentation.

ABSTRACT In order for the use of biological carotenoids to become feasible, it is necessary to have adequate low cost sources and improved methods of cultivation. The aim of this study was to evaluate the effect of supplementation with nitrogen, phosphorus, zinc, and magnesium, on the biomass and carotenoid volumetric production by yeast Rhodotorula rubra L02 using a complex medium (sugarcane juice) and synthetic media (sucrose and maltose) as substrates. The experimental design used for each substrate was randomized in blocks with 16 treatments and 3 repetitions. The treatments were compound for 15 different combinations of nutrients (N; Mg; Zn; P, N + Mg; N + Zn; N + P; Mg + Zn; Mg + P; Zn + P; N + P + Zn; N + P + Mg; N + Zn + Mg; P + Zn + Mg; N + Zn + Mg + P) alone and combined, and a control. The results were submitted to analysis of variance and Tukey test at 5% significance level. Among the treatments evaluated, the highest production of dry biomass, with both maltose and sucrose, was observed for Mg (1.60 g/L and 1.94 g/L, respectively). Additionally, another treatment that stood out in terms of biomass production was the control treatment with maltose (1.54 g/L). After the incubation time, killer activity was not observed since there was no formation of inhibition halo around the L02 yeast.

ABSTRACT One of the most important steps is to clarify the juice, which are added synthetic polymer acrylamide base, aiming the fast settling of impurities present in the juice. However, this input is expensive and may have carcinogenic and neurotoxic actions to humans. The search for new natural flocculants that have similarity with the commercial product is of great value. A bioextract that may be promising and has coagulant action is the Moringa oleifera Lam. In this context, the objective of the research was to evaluate the consequences of the use of moringa seed extracts and various concentrations of commercial polymer, such as sedimentation aids in clarifying sugarcane juice in the ethanol production, comparing the efficiency of the bioextract moringa. In the treatment of the juice, excessive addition of flocculants can result in reduction of sugars. The bioflocculant moringa was similar in technological features and the fermentative viability compared to usual dose of commercial polymer in Brazil. The fermentation efficiency was also higher for this flocculant, followed by moringa extract. The results obtained in this research indicate potential to the moringa bioextract, particularly in countries where the doses of flocculants are higher than 5 mg.L-1.

Os biocombustíveis apresentam-se com grande importância para suprir a demanda global de energia. São produzidos a partir de biomassa vegetal, emitem menor quantidade de dióxido de carbono e de partículas poluentes ao ambiente quando utilizados e possuem grande vantagem por serem combustíveis renováveis. Entre as matérias-primas com potencial para produção de etanol, cita-se o sorgo sacarino. Objetivou-se comparar o processamento industrial do genótipo de sorgo sacarino CVSW80007 e da cultivar de cana-de-açúcar 'RB966928' para produção de bioetanol em início de safra. As análises realizadas foram: brix; pH, ART, AR, acidez total, ARRT, glicerol, teor alcoolico, viabilidade celular, viabilidade de brotos e brotamentos. Quanto às características químico-tecnológicas, as matérias-primas apresentaram-se aptas ao processamento industrial, com índices superiores para a cana-de-açúcar. O desenvolvimento das fermentações ocorreu de forma adequada para ambas, sendo que o mosto fermentado (vinho), produzido a partir do mosto de cana-de-açúcar, apresentou maior teor alcoolico e rendimento fermentativo.

Biofuels have great importance to supply the global energy demand. These fuels are produced from plant biomass, emit less carbon dioxide and particulate pollutants to the environment when used and have great advantage of being renewable fuels. Among the raw materials with potential for ethanol production, is cited sweet sorghum. This study aimed to compare industrial processing of genotype sorghum CVSW80007 and the cultivar sugar cane 'RB966928' for bioethanol production in early season. The analyzes performed were: brix, pH, ART, AR, total acidity, ARRT, glycerol, alcohol content, cell viability, shoots viability and buds. Regarding the chemical-technological characteristics, raw materials were suitable for industrial processing, with higher rates for sugar cane. The development of fermentations occurred appropriately for both, and the fermented must (wine) produced from the must of sugar cane had higher alcohol content and fermentation yield.

This study aimed to evaluate the efficiency of natural biocides, brown and green propolis, for the control of bacterial contamination in the production of sugarcane spirit. The treatments consisted of brown and green propolis extracts, ampicillin, and a control and were assessed at the beginning and end of harvest season in ten fermentation cycles. In the microbiological analyses, the lactic acid bacteria were quantified in the inoculum before and after the treatment with biocides, and the viability of yeast cells during fermentation was evaluated. The levels of acids, glycerol, total residual reducing sugars, and ethanol were analyzed for the wine resulting from each fermentation cycle. A reduction in the number of bacterial contaminants in the inoculum in the treatments with the natural biocides was observed, but it did not affect the viability of yeast cells. The control of the contaminants led to the production of higher levels of ethanol and reduced acidity in the wine produced. The results of the use of brown and green propolis to control the growth microorganisms in the fermentation of sugarcane spirit can be of great importance for using alternative strategies to synthetic antibacterials in fermentation processes including other distilled beverage or spirits.

The objective of this study was to evaluate the effect of Moringa oleifera Lam. leaf extract on the sedimentation of impurities in the treatment of sugarcane juice and the effects on sugar quality and on the clarified juice. The experimental design used was a 4x2 factorial arrangement with four replications. The main treatments performed included the extracted original sugarcane juice, the synthetic polyelectrolyte (Flomex 9076), the leaf extract, and a control. The secondary treatments consisted of the sugarcane varieties RB92579 and RB867515. The clarification process used was simple defecation, in which the flocculating agents and the juice, limed and heated, were poured simultaneously into a decanter. The microbiological and chemico-technological characteristics of the extracted and clarified juices were evaluated. The clarified juice was concentrated up to 60° Brix (syrup) and subjected to boiling in a pilot pan using seeds to perform the graining: The sugar was recovered by centrifugation and analyzed for microbiological and chemico-technological characteristics. It was concluded that the use of the Moringa oleifera Lam. leaves extract resulted in a better quality of clarified juice and sugar.

A produção de biomassa e de carotenoides por Rhodotorula rubra foi estudada em meios à base de caldo, melaço e xarope de cana. Avaliou-se o efeito da suplementação dos meios com nitrogênio na forma de ureia ou do nutriente comercial Nitrofos KL. O delineamento experimental utilizado foi o inteiramente casualizado, no esquema fatorial 3 × 3, sendo um dos fatores o substrato (caldo, melaço e xarope) e o outro a suplementação (controle, ureia e Nitrofos KL). Os resultados foram submetidos à análise de variância e teste de Tukey a 5% de probabilidade. As maiores produções de massa seca de levedura foram obtidas no meio à base de melaço suplementado com ureia ou Nitrofos KL (15,09 e 14,87 g/L, respectivamente). A produção de carotenoides intracelular foi elevada em todos os meios estudados sem suplementação (0,329 mg/g). Para a produção volumétrica, o melhor meio foi o melaço (2,74 mg/L), enquanto a suplementação com ureia e com Nitrofos KL produziu 2,55 e 2,32 mg/L, respectivamente. Os principais carotenoides produzidos foram toruleno, torularrodina e β-caroteno. No meio à base de caldo de cana sem suplementação, houve o menor consumo de carboidratos, enquanto que o meio com suplementação à base de ureia obteve o maior consumo.

The Rhodotorularubra biomass and carotenoids production was evaluated in sugarcane juice, molasses, and syrup based media. The effects of media supplementation with urea- nitrogen or the commercial nutrient called Nitrofos KL was also verified. The experimental design used was a completely randomized factorial with 3 substrates (juice, molasses, and syrup) and three supplementations (control, urea, and Nitrofos KL). The results were submitted to variance analysis and Tukey test at 5% probability. The highest production of yeast dry mass was obtained with molasses media supplemented with urea or Nitrofos KL (15.09 and 14.87 g/L respectively). The intracellular carotenoid production was high in the media without supplementation (0.329 mg/g). The best growth medium for the volumetric production was molasses (2.74 mg/L), while those supplemented with urea and Nitrofos KL produced 2.55 and 2.32 mg/L, respectively. The major carotenoids produced were torulene, torularhodin, and β-carotene. The lowest carbohydrate consumption was observed in the sugarcane juice medium without supplementation, while the highest consumption was observed in the urea based supplementation medium.