ABSTRACT This study aimed at evaluating beak-trimming methods and intensities on the performance, beak length and uniformity, and egg parameters of commercial layers. During the rearing period, birds were distributed in randomized blocks, with a 2x3 factorial design + two treatments, consisting of beak trimming with infrared (IR) radiation (moderate or severe); three IR intensities (low: 42 nm, intermediate: 46 nm, or high: 52 nm); and two control hot blade (HB) beak trimming treatments (moderate or severe) with eight treatments and five replicates of 21 chicks each, totaling 840 birds. During the growing phase (second experiment) the factorial design was modified to 2 x 3 x 2 + 4, comprising two IR beak-trimming intensities (moderate or severe); three IR radiation intensities (low, moderate and high), second beak trimming at 11 weeks of age or not, and four additional HB beak-trimming treatments (moderate or severe) beak-trimming intensities, and second beak trimming at 11 weeks of age or not. There were 16 treatments with six replicates of seven birds each, totaling 672 laying hens, out of which 576 were selected for evaluation during the production period, with the same number of treatments and replicates of the previous phase. Weight gain (g), body weight (g), body weight uniformity (%), beak length (mm) and uniformity (%), absence of cannibalism (%), livability (%), egg production (%), feed intake (g), feed conversion per eggmass, eggmass, specific gravity, eggshell strength, Haugh unit, % yolk were evaluated. Beak trimming by infra-red radiation may be employed in commercial laying hens.

The objective of this study was to evaluate the effects on gamma radiation levels on the physical and microbiological characteristics of chicken breast meat. A completely randomized experimental design in a 4x2x3 factorial arrangement was adopted. Treatments consisted of four radiation concentrations (0, 2, 4, or 8kGy), two package sealing methods (with or without vacuum), and three storage times (01, 07, or 14 days), with ten replicates each, totaling 240 chicken breast fillets. Packaging and radiation had no influence (p>0.05) on chicken breast meat pH, water retention capacity, or presence of Salmonella spp. Breast fillets not submitted to radiation and vacuum packed presented higher water retention capacity (p<0.05) than those radiated at 4kGy and vacuum packed. Drip loss in fillets radiated at 8kGy and not vacuum packed was higher (p<0.05) than in non-radiated and non-vacuum packed fillets; however, both were not different from the other treatments. Coliform presence increased with storage time in non-radiated samples; however, when these were vacuum-packed, their development was slower. The results of the present experiment suggest that the use of a low radiation dose (2kGy), combined with vacuum packing, may minimize the harmful effects of storage on chicken breast fillets.

This study aimed at developing radiographic techniques for the early detection of dyschondroplastic lesions in the tibia of broilers. The experiment was carried out at the facilities of UNIFOR/MG and Formiga and UNIFENAS/ Alfenas with 420 one-day-old male Cobb broilers. At 20 days of age, all birds were radiographed and identified with an alpha-numeric metal ring in the right leg. At 40 days of age, 42 broilers previously selected as a function of bone mineral density and lesion thickness scores were again radiographed and scored, and then sacrificed. Their right tibia was removed for gross and histological examination of the growth plate. The results showed that radiographic techniques are correlated with gross and histological examination and that there was no significant differences among techniques (P>0.05). it was concluded that the use of radiographic examination to identify tibial dyschondroplasia in broilers precludes the use of bone mineral density to diagnose this condition. The non-parametric statistical Chi-square test at 5% significance level was used to analyze the results.

A total of 405 23-week-old ISA® Brown layers were distributed in a completely randomized experimental design in a factorial arrangement with nine treatments consisting of three dietary calcium levels (3.5, 3.75, and 4.5%) and three limestone particle sizes (100% fine limestone (FL), 70% FL + 30% coarse limestone (CL) and 50% (FL) + 50% (CL)), with nine replicates of five birds per cage. The following parameters were evaluated: percentage of lay, defective eggs, egg weight, egg mass, feed intake, feed conversion ratio (per kg eggs and per dozen eggs), and mortality. Dietary Ca levels significantly affected lay, with birds fed diets containing 4.5% calcium producing less eggs as compared to those fed 3.0 and 3.75% Ca. Egg production linearly decreased as dietary Ca levels increased, but blood Ca levels (mg/L) increased in 28-week-old birds. The interaction of dietary Ca levels and limestone particle sizes resulted in a reduction in tibial ash Ca content as dietary Ca levels increased and as fine limestone was replaced by coarse limestone. It is concluded that a dietary Ca level of 3.75% and 100% fine particle limestone are required to maintain adequate egg production and available Ca blood level.

This study evaluated the effect of dietary calcium levels and limestone particle size distribution on first-cycle layer performance and egg quality. A completely randomized experimental design in 4x3 factorial arrangement (four Ca levels - 3.0, 3.5, 4.0, 4.5%; and three limestone particle size distributions - 100% fine, 50% fine and 50% coarse, 30% fine and 70% coarse) was applied, totaling 12 treatments with six replicates of eight birds each. The treatments did not influence the most of evaluated performance and internal and external egg quality parameters. However, limestone particle size distribution quadratically affected with percentage of defective eggs, with the lowest percentage obtained with the distribution 61.75% fine limestone and 38.25% coarse limestone. Increasing dietary Ca levels significantly increased eggshell weight per surface area and the percentage of Ca excreted in the feces. It was concluded that the combination of the highest dietary Ca level (4.5%) with 50% replacement of fine-particle limestone by coarse limestone results in better eggshell and increases the number of marketable eggs.

This experiment studied the effect of four calcium (3.0, 3.5, 4.0, and 4.5%) and four available phosphorus levels (0.25, 0.30, 0.35, and 0.40%) in the diet of semi-heavy commercial layers after molting. Hisex Brown® layers between 90 and 108 weeks of age were distributed in a completely randomized experimental design with a 4x4 factorial arrangement with 16 treatments of five replicates of eight birds each. mortality, egg production, feed intake, egg mass, average egg weight, calcium and phosphorus intake, feed conversion ratio (per dozen eggs and per kg eggs), eggshell percentage and thickness, eggshell strength, eggshell weight per surface area (ESWSA), yolk percentage and color, albumen percentage, albumen and yolk heights, and blood and excreta calcium and phosphorus concentrations. There was no interaction (P>0.05) between dietary Ca and avP for any of the studied parameters. There were linear increases in Ca intake (P<0.01), eggshell percentage (P<0.05); ESWSA (P<0.05); yolk color (P<0.05); Ca concentration in the blood (P<0.05) and excreta (P<0.01) as dietary Ca level increased. The intake of avP linearly increased (P<0.01) with dietary avP levels. The remaining parameters were not influenced (P>0.05) by dietary Ca and avP levels. The diet containing 4.5% calcium improved feed conversion ratio per dozen eggs and eggshell quality. The lowest avP level fed (0.25%) is sufficient to maintain the performance and the egg quality of semi-heavy commercial layers after molting.

Three experiments were carried out to analyze the performance and egg quality of Japanese quails throughout the day when submitted to different lighting programs. In each experiment, birds were submitted to a period of 28 days for adaptation to the lighting program. During the following three days, each day - from 7 am to 7 pm or 9 pm - was divided into six or seven periods of two hours each, and the remaining hours corresponded to another single period. All birds were submitted to the same management practices, and received water and feed ad libitum. The experimental diet was formulated according to NRC (1994) standards. It was observed lower feed intake in the period of 9 pm to 7 am, and a higher incidence of lay from 3 pm to 7 pm, as opposite to hens, which peak of egg laying occurs during the morning. Some controversial results were found among experiments as to eggshell quality during the different periods of the day. Variation on the lighting program had little influence on the other performance and egg quality parameters.