Abstract Industrial egg residue (IER) possesses substantial concentrations of calcium and crude protein. The objective of this study was to measure the digestibility and performance of broilers when IER was added to the feed. Four treatments were tested, which caused increasing replacement of calcitic limestone by IER (0, 35, 70 and 100%) during a 42-day production cycle. First, total bird excreta were collected from broilers with and without IER, and we determined dry matter digestibility, apparent metabolizable energy (AME), calcium, and nitrogen retention. The IER presented 7.5% of crude protein, 31% of calcium, 209 kcal/kg of AME and the digestibility coefficients for dry matter, crude protein, and calcium were calculated at 83.95%, 86.20%, and 67%, respectively. After the digestibility test, the effects of IER on performance, carcass and meat yield were evaluated. No significant differences between the treatments were found in terms of performance (weight gain, feed conversion, consumption, and mortality), and no differences were found in terms of carcass or meat yield. A linear decrease in the percentage of abdominal fat was observed with increasing inclusion of IER in feed. These findings suggest that IER can totally replace limestone (calcium carbonate) in broiler diets.

Abstract The objective of this study was to evaluate whether the addition of a blend based on α-monolaurin mono-, di- and triglycerides of butyric acid, and lysolecithin on the performance even on diets containing reduced inclusion of oil in the diet and without the use of growth-promoting antibiotics of broilers considering the effect on health, performance, and meat. Three treatments were defined: positive control (TP: with enramycin), negative control (TN: no enramycin), and blend (T-FRA: with monolaurin and glycerides of acid butyric minus 0.8% soybean oil). At 21 days, broilers treated with TP and T-FRA obtained the lower feed conversion ratio (FC); at 35 days, T-FRA broilers obtained lower FC than TN broilers. Cholesterol levels were higher in the blood of T-FRA broilers. On day 42, levels of ROS and TBARS were lower in the intestine, muscles, and liver of T-FRA broilers. Moreover, glutathione S-transferase and total non-enzymatic antioxidants were greater at the intestinal and muscular levels. The T-FRA broilers had a lower percentage of lipids in the meat. The MIC indicated that 111mg of the blend/mL inhibited the growth of E. coli; however, the counts of total coliforms and E. coli in the feces and the broilers’ litter did not differ between treatments. In conclusion, the addition of the blend T-FRA in broiler diets was able to improve the feed conversion and maintain the other performance parameters even considering a reduction of 0.8% in the inclusion of oil.

Abstract Our objective was to determine whether inclusion of industrial egg residue (IER) in the diets of laying hens would replace calcitic limestone without interfering with productive efficiency, egg quality or digestibility. In a first study (Experiment I), we used 30% IER in the diets of laying hens and found that the apparent digestibility coefficients were 51.6%, 42.8%, 51.6% and 17.8% for dry matter, crude protein, calcium and phosphorus, respectively. In the second study (Experiment II), we compared a control diet containing calcitic limestone with four diets containing increasing levels of IER, in proportions of 25%, 50%, 75% and 100%. During the first cycle (day 1–28), there was no difference between treatments in terms of productive performance or egg quality. During the second production cycle (day 29–56), we observed less food consumption by birds that ingested the highest levels of IER (100% substitution) than in controls. During the third cycle (day 57–84), we found that the inclusion of IER negatively affected performance, particularly lower production numbers, lower egg mass and higher feed conversion. Finally, during the third cycle, chickens broke and ingested their eggs shortly after laying. We conclude that the use of industrial egg residue cannot replace limestone in the feed of commercial laying hens, because it reduces performance and affects egg quality.

Abstract This study aimed to determine whether the addition of green propolis extract to the diet of laying hens would improve egg quality and bird performance and decrease bacterial contamination of eggs. Forty-five brown Hy-line laying hens were used, divided into five groups with three replicates each and three animals per cage: T0 - diet without propolis; T5 - 5 grams of propolis per kg of feed; T10 - 10 grams of propolis per kg of feed; T20 - 20 grams of propolis per kg of feed and T30 - 30 grams of propolis per kg of feed. The quality of fresh eggs was made on day 21 of the experiment, and eggs were stored for 21 days. Greater specific gravity was observed in fresh eggs in T5 birds and stored eggs for T10. TBARS in fresh eggs, we found that T30 eggs had lower levels compared to other treatments. T20 eggs had the lowest total bacterial count and the lowest total coliform count in the eggshells of T10 and T20 chickens. The count of E. coli in the peel was lower for T20 and T30 than T0 and T5. The consumption of propolis did not interfere with the hens’ egg production rate but reduced food intake and consequently reduced feed conversion. We concluded that the addition of green propolis in the diet of laying birds proved efficient in reducing bacterial contamination in the eggshells and reducing the lipid peroxidation of fresh and stored eggs.

Abstract The aim was to evaluate the use of mixture of microencapsulated carvacrol and cinnamaldehyde as a replacement for growth-promoting antibiotics in broiler diets on performance, intestinal quality, organ development, carcass yields and cuts, and meat quality. In the trial were used 600 male chicks, allocated in a completely randomized design, with five treatments and eight replicates of 15 birds, reared up to 41 days of age. The treatments were: Negative Control (NC), Positive Control (PC) 30 mg/kg of virginiamycin, NC+100 mg/kg of essential oils, NC+200 mg/kg of essential oils and NC+400 mg/kg of essential oils. Essential oils were composed by a micro-encapsulated blend, with of 60% cinnamaldehyde, 30% carvacrol and 10% carrier. Birds received essential oils achieved performance equivalent to those birds received PC diets, having better development than NC broilers. No differences were found on relative organ weight, intestinal mucosa and meat quality parameters, however, higher villus:cript ratio was found in PC, NC+200 and NC+400 groups. Meat crude protein and yellowness were influenced by inclusion of carvacrol and cinnamaldehyde. It was concluded microencapsulated carvacrol and cinnamaldehyde can replace growth-promoting antibiotic in broiler diets, ensuring performance, intestinal integrity and broiler meat quality.

Abstract Evaluated lipid and cholesterol concentration and fatty acid profile of raw breast, thigh and drumstick meat from broilers raised in different rearing systems. Were used 200 male broiler carcasses from four different rearing systems (n=50 from conventional intensive; n=50 from organic; n=50 from free-range; and n=50 from antibiotic-free) distributed in a completely randomized design with four rearing systems and 50 replications (carcasses). Breast meat from conventional broilers showed higher lipid (1.47) and cholesterol (34.13) concentration. Thigh and drumstick meat from free-range broilers had higher lipid (7.53/4.73) and cholesterol (45.55/53.65) concentration. Fat contained in breast, thigh and drumstick meat from free-range broilers showed higher levels of polyunsaturated fatty acids. Fat from breast and thigh meat from free-range broilers showed higher total concentration of ω3 and ω6 fatty acids. Fat from thigh meat from organic broilers showed higher levels of EPA (C20:5n3) and DHA (C22:6n3). Fat from drumstick meat from free-range broilers showed higher total concentration of ω3 and ω6 fatty acids. Meat from chickens raised in alternative rearing systems offers less risk to cardiovascular health because it presents lower concentrations of lipids and cholesterol, greater amounts of polyunsaturated fatty acids, which are beneficial for human health.

Abstract Abstract: This study evaluated the effect of oregano essential oil added to the feed of commercial laying hens. This research was focused on the analysis of biochemical changes linked to hepatic function, and protein and lipid metabolism. It was used 240 laying hens (59 weeks-old) distributed in a completely randomized design of six treatments (five repetitions with eight birds each). The experiments were constituted by a control treatment (CT) with the inclusion of zinc bacitracin and five treatments of oregano essential oil (OEO: 0, 50, 100, 150, and 200 mg.kg-1), respectively. After 28 days of feeding, an increase on serum levels of total proteins and globulins was observed on groups T150 and T200, as well as an increase on albumin levels on group CT. After 84 days of feeding, a significant reduction on total proteins and albumin was observed on group T200, as well as an increase in serum triglycerides. OEO at 200 mg.kg-1 increased globulin levels on day 28, which may be considered an effect in the inflammatory response, which increases serum immunoglobulins and proteins.