ABSTRACT The experiment aimed to analyze the economic viability of using high-energy diets and the supplementation of chromium propionate or calcium salts of palm oil in the diet of ewes from the late gestation until the end of lactation. Seventy-two ewes of Santa Ines × Dorper crossbreeds were allocated to five treatments: CTL (n = 14) with 100% of NRC recommendation for metabolizable energy per kg dry matter intake (ME/kg DMI), LOW (n = 14) with 90% ME/kg DMI, HIGH (n = 15) with 110% ME/kg DMI, Cr (n = 15) HIGH diet plus chromium propionate, and FAT (n = 14) HIGH diet plus calcium salts of palm oil. Based on the performance data, a short-term analysis was performed for a module of 1000 ewes, evaluating costs, revenues, and profitability, and long-term analysis was performed by an additional cash flow of 120 months. The CTL and FAT treatments were not viable due to higher costs and lower revenues, and they also had a negative net present value (NPV) and internal rate of return (IRR). The LOW treatment, despite lower costs and positive profitability, had a negative NPV (-$872.90) and IRR (1.85%) that was below the discount rate, making it unprofitable in the long run. The HIGH and Cr treatments were considered feasible because they had lower unit costs and higher profitability, in addition to a high NPV ($64,894.11 and 104,902.05, respectively) and a higher IRR (9.03% and 13.65%, respectively) than the discount rate. The use of high-energy diets, with added chromium propionate, promoted better performance and, consequently, better economic return.

ABSTRACT The objective of the present study was to evaluate the reduction of calcium (Ca), crude protein (CP), metabolizable energy (ME), and available phosphorus (aP) in the nutritional matrix of Brazilian commercial broiler diets supplemented with both phytase superdosing (1500 FTU/kg) or conventional doses (500 FTU/kg) on the feed cost and profitability, performance, bone mineralization, and carcass yield of broiler from 1 to 42 d. A total 1200 one-day-old chicks (Cobb 500) were randomly distributed in a commercial feeding program composed of a positive control diet and three diets with reduction of Ca, aP, CP, and ME in the nutritional matrix supplemented with 500, 1000, and 1500 FTU/kg of phytase. The broilers subjected to diets with phytase superdosing presented similar performance, bone ash, and carcass yield, among the treatments. There was a linear effect in the total nutrition cost, gross margin, and estimated net margin per bird with the increase of dietary inclusion of phytase in all purposed scenarios. Thus, for each 500 FTU/kg of dietary phytase included in the diet with reduction of Ca, P, ME, and CP in the nutritional matrix, the total nutrition cost decreased R$ 0.072/bird, R$ 0.079/bird, and R$ 0.081/bird in scenarios of high, medium, and low prices of corn and soybean meal, respectively, that allowed an increase in the estimated net margin of R$ 0.20/bird, R$ 0.22/bird, and R$ 0.22/bird in the same scenarios.

ABSTRACT The objective with this study was to evaluate the impact of different swine nutritional strategies and technologies, as well as the land spread system, on logistical costs of pig manure distribution. For this, pigs were fed a conventional diet (C0) or a diet supplemented with 0.01% phytase (C1); organic minerals (40% substitution; C2); synthetic amino acids at reduced dietary crude protein levels (C3); or a combination of the three strategies (C4). All pig manure was weighed, then its chemical composition was determined. The mineral values and volume of manure produced were extrapolated to corresponding pig farm sizes in Sao Paulo state (300, 650, and 1000 sows) from real pig manure levels to produce simulations. To determine the logistical cost of manure distribution, two distribution systems were considered: vacuum tank tractor and vacuum tank truck (4.30 and 15 m3, respectively). The land spread truck system had the highest cost/hour worked due to the higher fuel consumption. However, this cost might be different over greater distances. Manure production, as well as the nutrient levels of N, P, and K, were lower for swine fed diets supplemented with nutritional technologies. Therefore, the different nutritional technologies reduced the transportation and distribution cost of pig manure by reducing the area and, consequently, the distances that need to be traveled for distribution. However, from an agronomic point of view (i.e., to meet a crop fertilization demand per hectare), manure from pigs fed diets supplemented with nutritional technologies had a higher application rate on land.