Natural colorants improved the physicochemical and sensorial properties of frozen Brazilian sausage (linguiça) with reduced nitrite

ABSTRACT:

The use of natural colorants in meat products can keep its coloring attractive as well as meet the demand from consumers interested in products that are healthier. Nitrite is added as a preservative to these products and it is also a precursor of the generation of a specifically desired color in meat products. However, its use has been associated with the development of certain kinds of cancer. The objective of this study was to evaluate the effect of reduced levels of nitrite in Brazilian sausage (linguiça) with natural colorants on the physicochemical and sensorial properties following frozen storage. Nine treatments were tested: 0.015 % nitrite (C150), 0.0075 % nitrite (C75) and 0 % nitrite (C0), 0.0075 % nitrite and 1.5 % microencapsulated betalain (BME75), 0 % nitrite and 1.5 % microencapsulated betalain (BME0), 0.0075 % nitrite and 0.19 % commercial betalain (BCP75), 0 % nitrite and 0.19 % commercial betalain (BCP0), 0.0075 % nitrite and 0.02 % of cochineal carmine (CC75) and 0 % nitrite and 0.02 % of cochineal carmine (CC0). Oxidative stability, residual nitrite and instrumental color were the determinant factors. Sensory analysis was directed at color, texture, taste and global acceptance. Natural colorants did not have any antioxidant effect. Sausages prepared with betalain and 0.0075 % nitrite showed the highest a* values. The addition of colorants improved both color and overall acceptance. The addition of betalain and cochineal carmine with 0.0075 % nitrite proved to be effective in achieving high acceptability in Brazilian sausage (linguiça).

Keywords:
betalain; sensory evaluation; cochineal carmine; lipid oxidation

Introduction

Sodium nitrite is a salt commonly used to cure meats in the production of ham, bacon and sausages. It acts by preserving meat products, inhibiting the germination of spores of Clostridium botulinum and resisting the growth of Listeria monocytogenes, among others (Feng et al., 2016). Nitrite also has antioxidant properties which influence the reduction in rancidity of the product (Sucu and Turp, 2018). Nitrite is known for its contribution to the development of the reddish-pink color and the flavor characteristics of cured meat products (Alahakoon et al., 2015; Bedale et al., 2016; Feng et al., 2016). However, nitrite is also connected to increased risk in certain types of cancer (Jin et al., 2012; Zhang et al., 2018). It is considered the most feared food additive and, is thus, avoided by consumers (Bedale et al., 2016). Research has been carried out in recent years to reduce nitrite in these products, and thereby decrease the potential risks to humans (Alahakoon et al., 2015; Alirezalu et al., 2018; Feng et al., 2016; Jin et al., 2012; Ruiz-Capillas et al., 2014).

On the other hand, meat color is the main factor in consumer's purchasing decisions because it is considered to be a good indicator of meat freshness and quality (Domingo et al., 2015). In this regard, food coloring is used to maintain an attractive red color in meat products; however, only natural colorants should be considered for such application, since ‘natural’ is associated with an image of good health and quality (Martínez et al., 2006). The most commonly used natural colorant in meat products is cochineal carmine. It is soluble in water and its color depends on the pH. Moreover, it is stable when confronted by changes in temperature and light and is resistant to oxidation (Borges et al., 2012).

Betalains are plant pigments that belong to the Caryophyllales order (Strack et al., 2003). According to their chemical structure, betalains are divided into two groups: the red-violet betacyanins and the yellow betaxanthins. The root of red beets (Beta vulgaris L. ssp. vulgaris) is the main source of betanin (Nemzer et al., 2011), which contains about 300-600 mg betanin kg⁻¹ (Kanner et al., 2001) and high amounts of nitrate, containing more than 2,500 mg nitrate kg⁻¹ (Sucu and Turp, 2018).

The meat processing industry is searching for alternative technologies to increase the shelf-life of meat products by utilizing additives from natural sources (Lorenzo et al., 2018a, b, c). In view of this, the replacement of nitrite from artificial origin with natural compounds in meat products is a trend that has been on the increase over the last few years (Hwang et al., 2017; Jin et al., 2014; Sucu and Turp, 2018). The reduction in temperature of storage (frozen) or vacuum packaging are procedures that have been adopted to ensure microbiological safety and prolong the commercial life of low-nitrite content meat products (Lago et al., 2019).

The objective of this work was to assess the effect of the betalain and cochineal carmine, as natural colorants, on the physicochemical properties, lipid oxidation and sensorial acceptance of frozen Brazilian sausage (linguiça) with reduced nitrite.

Materials and Methods

Brazilian sausage (linguiça) production

Brazilian sausage (linguiça) is a raw meat product widely consumed in Brazil, usually sold to the consumer under frozen or fresh conditions; this product needs to be cooked before consumption. It is not an emulsified product such as frankfurter sausage or mortadella sausage. The raw materials, pork ham (19.13 % of protein and 5.33 % of fat) and pork fat trimmings (15.49 % of protein and 22.68 % of fat) were obtained from the slaughterhouse (Ipoã, São Paulo, Brazil – latitude 23°31’34” S; longitude 46°20’38” W; altitude 745 m) 48 h after slaughter, and are ground using a 10 mm diameter disc. All formulations had the following ingredients: pork ham (68 %), pig fat trimmings (15 %), sodium lactate (2.0 %), condiment for Brazilian sausage (0.5 %), sodium chloride (0.8 %), sodium hexametaphosphate (0.2 %), natural garlic (0.4 %), sodium erythorbate (0.4 %), white pepper (0.195 %) and ascorbic acid (0.02 %).

Microencapsulated betalain (BME) was produced by the Laboratory for Physical Measurement at IBILCE (Institute of Biosciences, Humanities and Exact Sciences) through the homogenization of beetroot with 70 % ethanol, which was then filtered and evaporated under vacuum to constant volume (15° Brix). This extract was homogenized in a solution of 35 % of total solids with enzymatically modified starch and maltodextrin DE 10 at a ratio of 80:20, respectively. Next, the finalized solution was atomized in a spray drier to obtain microcapsules in the final concentration of betalain (0.034 % w w⁻¹). The commercial betalain (BCP) used was B-35-WSP (Chr. Hansen's Laboratorium Denmark A/S., Horsholm, Denmark), where the concentration of betalain was 0.25 to 0.28 % (w w⁻¹). Another colorant used was cochineal carmine (CC), namely, CC-3000WS (Chr. Hansen's Laboratorium Denmark A/S., Horsholm, Denmark), in which the concentration of caminic acid was 2.8 to 3.2 % (w w⁻¹).

Nine treatments were processed and the difference between treatments was the amount of sodium nitrite, colorant and water added (Table 1). The ground meat and other ingredients were blended for 10 min and this meat mixture was stuffed into natural pork casings 34 mm in diameter and tied into approximately 12 cm skins. The Brazilian sausages (linguiça) were individually vacuum packed in nylon-polyethylene bags and were frozen and stored at −18 ± 2 °C for up to 90 days for evaluation. For the analysis, the Brazilian sausages (linguiça) were thawed for 24 h at 4 ± 2 °C. All treatments were replicated independently three times. For each replicate, 30 sausages were produced per treatment. Samples at day 0 were taken for pH, chemical composition and sensorial analysis; whereas samples at 0, 30, 60 and 90 days of storage for TBARS, residual nitrite and color parameters.

Table 1
Difference between treatments of frozen Brazilian sausages (linguiça) (%).

Treatment	C150	C75	C0	BME75	BME0	BCP75	BCP0	CC75	CC0
Water	12.47	12.4775	12.485	10.9775	10.985	12.2875	12.295	12.4575	12.465
NaNO21	0.015	0.0075	–	0.0075	–	0.0075	–	0.0075	–
CBM2	–	–	–	1.5	1.5	–	–	–	–
CCB3	–	–	–	–	–	0.19	0.19	–	–
CCL4	–	–	–	–	–	–	–	0.02	0.02

• ¹
  Sodium nitrite;
• ²
  Microencapsulated betalain;
• ³
  Commercial betalain;
• ⁴
  Cochineal carmine.

Proximate composition

Moisture, ash and protein contents were determined following the official method of the Association of Official Analytical Chemistry (AOAC, 2007). Fat content was assessed using the method described by Bligh and Dyer (1959). The analyses were performed in triplicate for each treatment and results were expressed in percentages.

Oxidative stability (TBARS), residual nitrite and pH values

Lipid oxidation was determined according to the method previously described by Vyncke (1970) with modifications proposed by Zipser and Watts (1962). The betalain is a colorant soluble in water, so it can be present in filtered extracts before the addition of a thiobarbituric acid solution. Therefore, the filtrate obtained in the determination of oxidative stability was subject to two different conditions: 1) following the methodology mentioned, adding thiobarbituric acid solution in acetic acid (90 % v v⁻¹), and 2) with the addition of acetic acid only (90 % v v⁻¹) without the presence of thiobarbituric acid. Both were read at 532 nm, and the values of condition 2 were deducted from condition 1, in order to isolate the interference of betalain in the results. Residual nitrite analysis was performed using the diazotization reaction of nitrites with sulfanilic acid and coupling with alpha-naphthylamine hydrochloride in an acidic medium, forming alpha-naphthylamino-pazobenzene-β-sulfonic acid, which shows a pink coloration as described by the Association of Official Analytical Chemists (AOAC, 2000). The results were determined spectrophotometrically at 540 nm and by a standard curve at different concentrations of sodium nitrite. The assays were performed in C150, C75, BME75, BCP75 and CC75 treatments and the pH was determined using a PG 1800 pH meter with a penetration probe and four readings were taken for each treatment. All the determinations were made in triplicate.

Color measurement

Color measurements were determined on the outer surface of the uncooked sausage (linguiça) using a ColorFlex45/0 colorimeter (Hunterlab, Reston, United States) and calibrated using the black glasses and white tiles provided. Samples were analyzed directly over the 0.75-inch aperture, with D65 illumination configurations, and a 10° viewing angle, using the Universal Software program version 4.10. The CIELab system of color specification was used and the parameters obtained were L* (lightness), a* (redness) and b* (yellowness). Ten determinations were made for each treatment, avoiding areas that had an excess of fat.

Sensory analysis

The effective acceptance test was carried out on a group of eighty consumers, who answered a questionnaire on characterisation of the sensory panel – 71.25 % said they liked Brazilian sausage (linguiça) a lot, even though 70.89 % consume it only once a week. A hedonic scale of nine points ranging from 1 – “disliked extremely” to 9 – “liked extremely” was used to evaluate the color, texture and flavor attributes as well as overall acceptance. The samples were cooked in an FELS3 electric oven until the geometric centre of the sausage reached 72 ± 2 °C, controlled by a digital thermocouple. After cooking, the samples were cut into 2 cm (height) cylinders and kept at 60 °C in a water bath at 90 °C until the analysis. They were delivered in a monadic manner (Meilgaard et al., 1999) and followed a complete block design. This study was approved by the Ethics Committee of the Institute of Biosciences and Exact Sciences, UNESP (n° 58983516.2.0000.5466).

Statistical analyses

Nine treatments (C150, C75, C0, BME75, BME0, BCP75, BCP0, CC75 and CC0) of Brazilian sausage (linguiça) were manufactured in triplicate (n = 3), and analyzed during the frozen storage period (at 0, 30, 60 and 90 days). For the statistical analysis of the results, analysis of variance (ANOVA) was carried out using the General Linear Model (GLM). The time of storage and the treatment were considered to be constant effects while manufacture repetition was a random effect. For the sensory analysis, the treatment was considered to be the constant effect and consumers as the random effect. Statistical analyses were carried out using the statistical SPSS software package (IBM SPSS Statistics, version 23).

Results and Discussion

Proximate composition and pH

Nitrite significantly affected (p < 0.05) the moisture content of the Brazilian sausage (linguiça) from control samples and those manufactured with microencapsulated betalain (Table 2), whereas samples prepared with commercial betalain and cochineal carmine were not affected. Our findings are in agreement with those observed by Alahakoon et al. (2015) who found that the use of nitrite salts in meat reduces its moisture content and water activity. The amount of protein varied from 15.31 to 18.36 %, fat content between 5.35 and 8.97 % and the amount of ash ranged from 2.40 to 2.83 %. These variations are inherent in the raw meat used.

Table 2
Proximate analysis and pH of frozen Brazilian sausages (linguiça).

	Treatments
	C150	C75	C0	BME75	BME0	BCP75	BCP0	CC75	CC0	SEM	p-value
Proximate analysis (%)
Moisture	70.30bc	70.38bc	73.04a	69.18d	70.38bc	69.61cd	70.28bc	71.17b	71.14b	0.237	0.000
Protein	16.23bcd	16.76bc	18.36a	15.31d	15.32d	16.29bc	16.89b	15.82cd	16.31bc	0.217	0.000
Fat	8.97a	7.16b	5.35c	7.31ab	6.11bc	7.37ab	6.68bc	6.91bc	7.73ab	0.245	0.001
Ash	2.40b	2.69ab	2.78a	2.69ab	2.69ab	2.77a	2.83a	2.75a	2.45b	0.036	0.003
pH	5.89	5.93	5.71	5.91	5.85	5.82	5.77	5.87	5.78	0.018	0.067

• C150 = 0.015 % nitrite, C75 = 0.0075 % nitrite, C0 = 0 % nitrite. BME75 = 1.5 % microencapsulated betalain and 0.0075 % nitrite, BME0 = 1.5 % microencapsulated betalain and 0 % nitrite, BCP75 = 0.19 % commercial betalain and 0.0075% nitrite, BCP0 = 0.19 % commercial betalain and 0 % nitrite, CC75 = 0.02 % cochineal carmine and 0.0075 % nitrite, CC0 = 0.02 % cochineal carmine and 0 % nitrite.
• ^a-d
  Mean values in the same line not followed by a common letter differ significantly (p < 0.05). SEM = standard error of the mean.

On the other hand, it was also found that the addition of natural colorants (betalains and cochineal carmine) and the use of nitrite (0 to 0.015 %) did not affect (p > 0.05) the pH values of Brazilian sausages (Table 2). Similar results were found by Sucu and Turp (2018) who found that the addition of beetroot powder as a nitrite alternative did not affect the pH values of Turkish fermented beef sausage. However, Choi et al. (2017) and Hwang et al. (2017) noticed that the inclusion of red beet showed a decrease in pH values of emulsion type sausages.

Oxidative stability

Nitrite shows antioxidant effects on frozen Brazilian sausages (linguiça) at 60 days, where C150 presents TBARS values lower than C0 and BCP75, and BME75 were lower than BME0 (Figure 1). At day zero, the results found for controls with nitrite (C150 and C75) were similar (p < 0.05) to the control which had no added nitrite (C0). At 30 and 90 days, no differences to TBARS values among treatments were found (p > 0.05) (Figure 1). The inclusion of beetroot powder could show an antioxidant activity due to betalain content, which presents antioxidant and radical-scavenging activities (Georgiev et al., 2010). The use of betalain and cochineal carmine did not have any antioxidant effect on Brazilian sausage (linguiça). According to Stagnari et al. (2014), 100 g of red beet contain between 62.04 and 118.92 mg of betalains.

Figure 1
TBARS values of Brazilian sausage (linguiça) during frozen storage. C150 = 0.015 % nitrite, C75 = 0.0075 % nitrite, C0 = 0 % nitrite, BME75 = 1.5 % microencapsulated betalain and 0.0075 % nitrite, BME0 = 1.5 % microencapsulated betalain and 0 % nitrite, BCP75 = 0.19 % commercial betalain and 0.0075 % nitrite, BCP0 = 0.19 % commercial betalain and 0 % nitrite, CC75 = 0.02 % cochineal carmine and 0.0075 % nitrite, CC0 = 0.02 % cochineal carmine and 0 % nitrite. ^a-cMean values on the same day not followed by a common letter differ significantly (p < 0.05) Errors bars show the standard error. ¹TBARS = Thiobarbituric acid reactive substances. ²MDA = Malondialdehyde.

Our results are in agreement with the data found by Sucu and Turp (2018) who did not observe any significant differences in TBARS values at the end of storage time in Turkish fermented beef sausage manufactured with sodium nitrite and three levels of beetroot powder. Moreover, according to O’Neill et al. (1998), the threshold for detecting rancid odor in pork is between 0.5 and 2.0 mg TBARS kg⁻¹ of the sample. The TBARS results obtained in the present study did not exceed the limit compromising the sensory quality of the product in all the periods analysed.

Residual nitrite content

The residual nitrite values (Figure 2) after 0 and 30 days of storage were the highest in C150. A similar result was found by Jin et al. (2012) who used different concentrations of nitrite (100 and 150 mg kg⁻¹) and purple-fleshed sweet potato powder in cooked pork sausage. A drop in residual nitrite amount was found in all treatments during the storage time (p < 0.05).

Figure 2
Residual nitrite content of Brazilian sausages (linguiça) during frozen storage. C150 = 0.015 % nitrite, C75 = 0.0075 % nitrite, BME75 = 1.5 % microencapsulated betalain and 0.0075 % nitrite, BCP75 = 0.19 % commercial betalain and 0.0075 % nitrite, CC75 = 0.02 % cochineal carmine and 0.0075 % nitrite. ^a-cMean values in the same day not followed by a common letter differ significantly (p < 0.05). Error bars show the standard error.

The results of the present study showed that, on day 0, the samples presented a mean reduction of 68 % of the initial concentrations after production, ranging from 24.10 and 77.69 mg kg⁻¹ nitrite (Figure 2). BME75 and the control (C150 and C75) had a reduction of approximately 50 % of the nitrite content compared to the initial amount added. The reduction of nitrite values was lower than those reported by Xi et al. (2012) who observed that residual nitrite content was around 75 % of the initial levels after the production process.

After 30 days of storage, the amount of nitrite presented in the C150 had a reduction of 90 % of the initial concentration added at the formulation stage in the C75 and BME75 the reduction of nitrite was approximately 86 %, whereas in the BCP75 and CC75 the reduction was 91 and 87 %, respectively. After 60 days of storage, all treatments had values ≤ 5 % of the amount of nitrite added, ranging from 2.60 to 4.74 mg kg⁻¹ nitrite for BCP75 and CC75, respectively. At the end of storage time, it was not possible to quantify the nitrite in the samples (bellow limit of detection). According to Sucu and Turp (2018), the residual nitrite amount differed according to the processing conditions, type of product, the presence of sodium ascorbate, and other factors (non-heme proteins, myoglobin and lipids).

Color measurement

The inclusion of betalain and cochineal carmine decreased lightness and yellowness and increased redness values (Table 3). There were no significant differences in luminosity (p < 0.05) compared to the control. Thus, the reduction of nitrite had no effect on this parameter. The control with nitrite at 0.0075 % (C75) and the control with no added nitrite (C0) presented the highest luminosity values during the storage time. This outcome agrees with the data found by Ruiz-Capillas et al. (2014) who noticed that the addition of nitrite showed a higher luminosity than the treatments with added celery as a natural source of nitrite and urucum and cochineal carmine as colorants in hot dog sausages. Moreover, Bloukas et al. (1999) when studying the effect of adding natural colorants and nitrite to the color of frankfurter sausage, it was observed that the highest L* values were found in the control treatment, with the addition of nitrite only, whereas the samples with added carmine or betalain showed the lowest luminosity. The values of L * increased over time for all the treatments analyzed and the same trend was observed by Sucu and Turp (2018) in fermented sausages manufactured with the addition of beetroot powder in different concentrations (as a source of nitrate) and reduction of nitrite. Jin et al. (2014) also observed that L* values for the red beet-added group increased during storage time (p < 0.05); control treatments did not present any effect of storage on lightness (p > 0.05). On the contrary, Hwang et al. (2017) observed a decrease in L* of low-fat frankfurter sausages by the addition of red beet extract. In Brazilian sausages (linguiça) (at day 0), the control samples without the addition of colorants (C150, C75 and C0) presented similar redness values, possibly due to an incomplete curing reaction, with a* values ranging from 9.28 to 10.11. In this regard, Bloukas et al. (1999) noticed that, initially, nitrite is reduced to nitric oxide, and this process involves the oxidation of myoglobin to metmyoglobin, producing a brown color. Subsequently, the nitric oxide reacted with the myoglobin of the meat, forming nitric oxide myoglobin, a bright red compound which remains stable when exposed to heat.

Table 3
Color parameters (L*, a*and b*) of frozen Brazilian sausages (linguiça).

	C150	C75	C0	BME75	BME0	BCP75	BCP0	CC75	CC0	SEM	p-value
L*
0	53.58b AB	54.41b A	54.22b A	50.39b AB	50.81b AB	51.94b AB	51.72b AB	53.19b AB	54.04b A	0.289	0.001
30	58.20a AB	58.60a A	58.72a A	54.53a CD	55.55a BCD	54.12ab D	53.14ab D	54.49ab CD	57.13a ABC	0.258	0.000
60	57.55a AB	58.69a A	57.52a AB	54.54a CD	55.21a BCD	54.34ab CD	53.82ab D	56.76a ABC	58.10a A	0.234	0.000
90	57.26a AB	57.39a AB	58.86a A	54.44a B	54.81a B	55.32a B	55.52a B	56.86a AB	56.48a AB	0.263	0.000
SEM	0.372	0.372	0.360	0.461	0.466	0.352	0.429	0.401	0.346
p-value	0.000	0.000	0.000	0.000	0.000	0.005	0.019	0.001	0.000
a*
0	10.11b EF	10.07c EF	9.28a F	13.93AB	12.79a BC	14.80ab A	13.67a AB	11.73b CD	11.01a DE	0.168	0.000
30	11.43a C	11.27ab C	8.31ab D	14.60AB	11.90ab C	15.61a A	13.35a B	13.99a B	11.07a C	0.168	0.000
60	10.64ab E	10.39bc E	8.40ab F	14.02AB	11.80b D	15.05ab A	12.88ab CD	12.98a BC	10.01b E	0.160	0.000
90	11.57a BC	11.46a BC	7.71b D	13.89A	11.38b BC	14.33b A	12.31b B	13.73a A	10.79ab C	0.166	0.000
SEM	0.172	0.141	0.161	0.148	0.138	0.131	0.144	0.168	0.132
p-value	0.005	0.001	0.010	0.437	0.004	0.004	0.007	0.000	0.019
b*
0	12.97a A	12.88A	12.83AB	11.37C	11.87a C	10.17a D	9.59ab D	11.96BC	11.79C	0.101	0.000
30	11.76b ABC	12.10AB	12.19A	10.76CD	10.59b D	9.09b E	9.43ab E	11.08BCD	11.67ABC	0.106	0.000
60	11.65b ABC	11.99AB	12.22A	11.05BC	10.75b C	9.60ab D	8.67b D	11.60ABC	11.68ABC	0.111	0.000
90	11.83b AB	12.41A	12.38A	10.65CD	10.12b D	9.08b E	9.74a DE	11.21BC	11.83AB	0.113	0.000
SEM	0.122	0.127	0.119	0.132	0.124	0.112	0.120	0.132	0.101
p-value	0.000	0.053	0.199	0.216	0.000	0.001	0.016	0.070	0.934

• C150 = 0.015 % nitrite, C75 = 0.0075 % nitrite, C0 = 0 % nitrite. BME75 = 1.5 % microencapsulated betalain and 0.0075 % nitrite, BME0 = 1.5 % microencapsulated betalain and 0 % nitrite, BCP75 = 0.19 % commercial betalain and 0.0075 % nitrite, BCP0 = 0.19 % commercial betalain and 0 % nitrite, CC75 = 0.02 % cochineal carmine and 0.0075 % nitrite, CC0 = 0.02 % cochineal carmine and 0 % nitrite.
• ^A-F
  Mean values in the same line not followed by a common letter differ significantly (p < 0.05). SEM = standard error of the mean.
• ^a-c
  Mean values in the same column not followed by a common letter differ significantly (p < 0.05).

After 30, 60 and 90 days of storage, C0 presented the lowest a* values (p < 0.05), corroborating the role of the nitrite in the final coloring of Brazilian sausage (linguiça) (Table 3). On the other hand, C150 and C75 were similar (p > 0.05), reporting that amounts below 0.015 % nitrite are sufficient to generate the desired color of cured products. The addition of the betalain colorant increased the redness (p > 0.05) in Brazilian sausage (linguiça) with nitrite at 0.0075 % producing the highest a* values in all periods analysed (BCP75). These results show that the addition of betalain colorant is effective in improving the color of Brazilian sausage and keeping it attractive for up to 90 days of frozen storage. Moreover, BME0, BCP0 and CC0 had higher or similar values than the C150 and C75 controls and higher than the C0 treatment (Table 3), showing that the use of the colorants assisted in the final color of the meat product, even with no added nitrite. Bloukas et al. (1999) found that carminic acid, betanin and paprika extract significantly increased the redness in Frankfurter sausage and their interaction with nitrite resulted in an increase in a* values. The authors also claimed that the interaction of nitrite with natural colorants positively affected the intensity of the red color of the sausage, resulting in a more acceptable product for consumers. Other authors (Jin et al., 2014; Sucu and Turp, 2018) have also noticed that a* values increased with an increased level of red beetroot added. There was a reduction in a* values over time in the C0, BME0, BCP75, BCP0 and CC0 treatments. The reduction found in the treatments after the addition of betalain may be due to the degradation of this pigment by light, oxygen, pH and temperature (Martínez et al., 2006). In addition, the encapsulation process of betalain did not help to improve its stability in Brazilian sausage (linguiça) due to the carriers’ material used being soluble in water. Thus, the microencapsulated betalain showed behavior similar to commercial betalain.

C0, C75 and C150 did not show any differences (p > 0.05) for b* values during the storage time (Table 3). The lower b* values (p < 0.05) for Brazilian sausages (linguiça) were found in BCP75 and BC0. This finding agrees with that noticed by Sucu and Turp (2018) who found that the inclusion of beetroot powder significantly decreased b* values on day 0.

Sensory analysis

As regards color attributes (Table 4), Brazilian sausage (linguiça) manufactured with natural colorants and nitrite presented the highest scores (7.57, 7.26, 7.22 and 7.07 for BCP75, CC75, C150 and BME75, respectively). In contrast, the C0 control had the lowest score for color, with a mean between the terms “slightly dislike” and “moderately dislike” and was no different from the BME0, which had no addition of nitrite. This outcome is in agreement with the data noticed by Jin et al. (2014), who found higher color scores in emulsified sausages prepared with red beet addition and nitrite compared to control, whereas no significant differences were observed in the other treatments in terms of flavor, tenderness and juiciness. In addition, Sucu and Turp (2018) reported that the inclusion of beetroot powder significantly (p < 0.05) increased the color scores of the Turkish fermented beef sausages.

Table 4
Sensory acceptance of frozen Brazilian sausages (linguiça).

Treatments	Sensory atributes
	Color	Texture	Flavor	Overall acceptance
C150	7.22ab	7.61a	7.60ab	7.57a
C75	6.80b	7.06bcd	7.24bc	7.10b
C0	3.96d	6.56d	6.85c	6.04d
BME75	7.07ab	7.46ab	7.64ab	7.41ab
BME0	4.61cd	7.01bcd	7.20bc	6.54c
BCP75	7.57a	7.49ab	7.74a	7.65a
BCP0	4.76c	7.11abc	7.25bc	6.57c
CC75	7.26ab	7.57a	7.74a	7.55a
CC0	5.05c	6.91cd	7.24bc	6.49c
SEM	0.077	0.048	0.045	0.046
p-value	0.000	0.000	0.000	0.000

• C150 = 0.015 % nitrite, C75 = 0.0075 % nitrite, C0 = 0 % nitrite. BME75 = 1.5 % microencapsulated betalain and 0.0075 % nitrite, BME0 = 1.5 % microencapsulated betalain and 0 % nitrite, BCP75 = 0.19 % commercial betalain and 0.0075 % nitrite, BCP0 = 0.19 % commercial betalain and 0 % nitrite, CC75 = 0.02 % cochineal carmine and 0.0075 % nitrite, CC0 = 0.02 % cochineal carmine and 0 % nitrite.
• ^a-d
  Mean values in the same column not followed by a common letter differ significantly (p < 0.05). SEM = standard error of the mean.

Texture attribute presented significant differences between treatments, presenting the lowest scores in Brazilian sausages (linguiça) prepared without sodium nitrite and natural colorants. The addition of natural colorants significantly increased (p < 0.05) the overall acceptance of the Brazilian sausage (linguiça) even with a 50 % reduction in nitrite, since the best scores were obtained for BCP75, CC75 and C150 treatments. However, the treatments that had no added nitrite presented the lowest scores for the overall acceptance, even with the addition of betalain and cochineal carmine. This finding agrees with that found by Sucu and Turp (2018) who observed that the overall acceptance scores of sausages prepared with 0.24 % and 0.35 % of beetroot powder were higher than those of the control treatment. In addition, Choi et al. (2017) also found significant differences in the overall acceptability of meat emulsions prepared with 10 % fermented red beet compared to those of the control treatment containing nitrite.

The C0, without addition of colorant and nitrite, presented the lowest scores for all the attributes examined (Table 4) and was, therefore, less acceptable compared to the others. Ruiz-Capillas et al. (2014) reported a sensory evaluation of three treatments for hot-dog type sausages - with nitrite, with no added nitrite but with cochineal carmine and no added nitrite with annatto, and their results showed that the treatment with annatto was less acceptable than the other treatments since the color is the attribute that mostly contributed to overall acceptability.

Conclusion

The addition of betalain and cochineal carmine in frozen Brazilian sausage (linguiça) improved the color when the nitrite was reduced or not added. The physicochemical and sensorial properties (color, flavor and overall acceptance) of Brazilian sausage (linguiça) were compromised in the cases of no added nitrite and natural colorants. No decrease in the oxidative stability of frozen Brazilian sausage (linguiça) manufactured with reduced nitrite was observed. The betalain proved to be a natural alternative for reducing nitrite levels without compromising the acceptability of frozen Brazilian sausages (linguiça).

Acknowledgments

The authors would like to acknowledge the financial support from Coordination for the Improvement of Higher Level Personnel (CAPES). José M. Lorenzo is a member of the MARCARNE network, funded by CYTED (ref.116RT0503).

References

• Alahakoon, A.U.; Jayasena, D.D.; Ramachandra, S.; Jo, C. 2015. Alternatives to nitrite in processed meat: up to date. Trends in Food Science and Technology 45: 37-49.
• Alirezalu, K.; Hesari, J.; Nemati, Z.; Munekata, P.E.; Barba, F.J.; Lorenzo, J.M. 2018. Combined effect of natural antioxidants and antimicrobial compounds during refrigerated storage of nitrite-free frankfurter-type sausage. Food Research International 120: 839-850.
• Association of Official Analytical Chemists-International [AOAC]. 2000. Official Methods of Analysis: Nitrites in Cured Meat. 15ed. AOAC, Arlington, VA, USA.
• Association of Official Analytical Chemists-International [AOAC]. 2007. Official Methods of Analysis. 18ed. AOAC, Gaithersburg, MD, USA.
• Bedale, W.; Sindelar, J.J.; Milkowski, A.L. 2016. Dietary nitrate and nitrite: benefits, risks, and evolving perceptions. Meat Science 120: 85-92.
• Bligh, E.G.; Dyer, W.J. 1959. A rapid method of total lipid extraction and purification. Canadian Journal of Biochemistry and Physiology 37: 911-917.
• Bloukas, J.; Arvanitoyannis, I.; Siopi, A. 1999. Effect of natural colourants and nitrites on colour attributes of frankfurters. Meat Science 52: 257-265.
• Borges, M.E.; Tejera, R.L.; Díaz, L.; Esparza, P.; Ibáñez, E. 2012. Natural dyes extraction from cochineal (Dactylopius coccus): new extraction methods. Food Chemistry 132: 1855-1860.
• Choi, Y.S.; Kim, T.K.; Jeon, K.H.; Park, J.D.; Kim, H.W.; Hwang, K.E.; Kim, Y.B. 2017. Effects of pre-converted nitrite from red beet and ascorbic acid on quality characteristics in meat emulsions. Korean Journal for Food Science of Animal Resources 37: 288-296.
• Domingo, G.; Iglesias, A.; Monserrat, L.; Sánchez, L.; Cantalapiedra, J.; Lorenzo, J.M. 2015. Effect of crossbreeding with Limousine, Rubia Gallega and Belgium Blue on meat quality and fatty acid profile of Holstein calves. Animal Science Journal 86: 913-921.
• Feng, X.; Li, C.; Jia, X.; Guo, Y.; Lei, N.; Hackman, R.M.; Chen, L.; Zhou, G. 2016. Influence of sodium nitrite on protein oxidation and nitrosation of sausages subjected to processing and storage. Meat Science 116: 260-267.
• Georgiev, V.G.; Weber, J.; Kneschke, E.M.; Denev, P.N.; Bley, T.; Pavlov, A.I. 2010. Antioxidant activity and phenolic content of betalain extracts from intact plants and hairy root cultures of the red beetroot Beta vulgaris cv. Detroit dark red. Plant Foods for Human Nutrition 65: 105-111.
• Hwang, K.E.; Kim, T.K.; Kim, H.W.; Oh, N.S.; Kim, Y.B.; Jeon, K.H.; Choi, Y.S. 2017. Effect of fermented red beet extracts on the shelf stability of low-salt frankfurters. Food Science and Biotechnology 26: 929-936.
• Jin, S.K.; Choi, J.S.; Moon, S.S.; Jeong, J.Y.; Kim, G.D. 2014. The assessment of red beet as a natural colorant, and evaluation of quality properties of emulsified pork sausage containing red beet powder during cold storage. Korean Journal for Food Science of Animal Resources 34: 472-481.
• Jin, S.K.; Kim, Y.J.; Park, J.H.; Hur, I.C.; Nam, S.H.; Shin, D. 2012. Effects of purple-fleshed sweet potato (Ipomoera batatas Cultivar Ayamurasaki) powder addition on color and texture properties and sensory characteristics of cooked pork sausages during storage. Asian-Australasian Journal of Animal Sciences 25: 1329-1337.
• Kanner, J.; Harel, S.; Granit, R. 2001. Betalains: a new class of dietary cationized antioxidants. Journal of Agricultural and Food Chemistry 49: 5178-5185.
• Lago, A.M.T.; Teixeira, J.T.; Olímpio, B.J.G.; Schiassi, M.C.E.V.; Pimenta, C.J.; Gomes, M.E.S. 2019. Shelf life determination of frozen fish sausage produced with fillet and minced fish derived from the Nile tilapia processing. Journal of Food Process and Preservation 43: e13984.
• Lorenzo, J.M.; Pateiro, M.; Domínguez, R.; Barba, F.J.; Putnik, P.; Kovačević, D.B.; Shpigelman, A.; Granato, D.; Franco, D. 2018a. Berries extracts as natural antioxidants in meat products: a review. Food Research International 106: 1095-1104.
• Lorenzo, J.M.; Munekata, P.E.S.; Sant’Ana, A.S.; Carvalho, R.B.; Barba, F.J.; Toldrá, F.; Mora, L.; Trindade, M.A. 2018b. Main characteristics of peanut skin and its role for the preservation of meat products. Trends in Food Science & Technology 77: 1-10.
• Lorenzo, J.M.; Munekata, P.E.S.; Gómez, B.; Barba, F.J.; Mora, L.; Pérez-Santaescolastica, C.; Toldrá, F. 2018c. Bioactive peptides as natural antioxidant in food products: a review. Trends in Food Science and Technology 79: 136-147.
• Martínez, L.; Cilla, I.; Beltrán, J.A.; Roncalés, P. 2006. Comparative effect of red yeast rice (Monascus purpureus), red beet root (Beta vulgaris) and betanin (E-162) on colour and consumer acceptability of fresh pork sausages packaged in a modified atmosphere. Journal of the Science of Food and Agriculture 86: 500-508.
• Meilgaard, M.; Civille, G.V.; Carr, B.T. 1999. Sensory Evaluation Techniques. 3ed. CRC Press, New York, NY, USA.
• Nemzer, B.; Pietrzkowski, Z.; Spórna, A.; Stalica, P.; Thresher, W.; Michałowski, T.; Wybraniec, S. 2011. Betalainic and nutritional profiles of pigment-enriched red beet root (Beta vulgaris L.) dried extracts. Food Chemistry 127: 42-53.
• O’Neill, L.M.; Galvin, K.; Morrissey, P.A.; Buckley, D.J. 1998. Comparison of effects of dietary olive oil, tallow and vitamin E on the quality of broiler meat and meat products. British Poultry Science 39: 365-371.
• Ruiz-Capillas, C.; Tahmouzi, S.; Triki, M.; Rodríguez-Salas, L.; Jiménez-Colmenero, F.; Herrero, A.M. 2014. Nitrite-free Asian hot dog sausages reformulated with nitrite replacers. Journal of Food Science and Technology 52: 4333-4341.
• Stagnari, F.; Galieni, A.; Speca, S.; Pisante, M. 2014. Water stress effects on growth, yield and quality traits of red beet. Scientia Horticulturae 165: 13-22.
• Strack, D.; Vogt, T.; Schliemann, W. 2003. Recent advances in betalain research. Phytochemistry 62: 247-269.
• Sucu, C.; Turp, G.Y. 2018. The investigation of the use of beetroot powder in Turkish fermented beef sausage (sucuk) as nitrite alternative. Meat Science 140: 158-166.
• Vyncke, W. 1970. Direct determination of the thiobarbituric acid value in thricloracetic acid extracts of fish as a measure of oxidative rancidity. Fette Sefein Anstrichmittel 72: 1084-1087.
• Xi, Y.; Sullivan, G.A.; Jackson, A.L.; Zhou, G.H.; Sebranek, J.G. 2012. Effects of natural antimicrobials on inhibition of Listeria monocytogenes and on chemical, physical and sensory attributes of naturally cured frankfurters. Meat Science 90: 130-138.
• Zhang, H.; Sun, C.; Han, W.; Zhang, J.; Hou, J. 2018. Analysis of the monitoring status of residual nitrite in meat products in China from 2000 to 2011. Meat Science 136: 30-34.
• Zipser, M.W.; Watts, B.M. 1962. A modified 2-thiobarbituric acid (TBA) method for determination of malonaldehyde in cured meats. Food Technology 16: 102-104.

Edited by

Edited by: Pedro Esteves Duarte Augusto

Publication Dates

• Publication in this collection
  18 May 2020
• Date of issue
  2021

History

• Received
  08 Aug 2019
• Accepted
  08 Oct 2019