Acessibilidade / Reportar erro

Hordein polypeptide patterns in relation to malting quality in Brazilian barley varieties

Padrões de polipeptídios de hordeína em relação à qualidade de malteação em variedades brasileiras de cevada

Abstracts

Since there is evidence that malting quality is related to the storage protein (hordein) fraction, in the present work the hordein polypeptide patterns from 13 barley (Hordeum vulgare L.) varieties of different malting quality were analysed in order to explore the feasibility of using hordein electrophoresis to assist in the selection of malting barleys. The formation of clusters separating the varieties with higher malting quality from the others with lower quality suggests that there is a relationship between the general hordein polypeptide pattern and malting quality in the varieties analysed. By the Sperman's correlation test three hordein bands correlated negatively with malting quality in the germplasm studied.

Hordeum vulgare; storage proteins; electrophoresis


No presente trabalho foi analisado o padrão de polipeptídios de hordeína de 13 variedades de cevada (Hordeum vulgare L.) que apresentam diferentes qualidades de malteação, com o objetivo de verificar a viabilidade de se usar eletroforese de hordeínas na seleção de cevadas usadas para malteação. A formação de agrupamentos separando as variedades que apresentam altos níveis de malteação daquelas com baixa qualidade sugere haver uma clara associação entre a qualidade de malteação e os padrões de hordeína, pelo menos com relação às variedades analisadas. Pelo teste de correlação de Sperman, três bandas apresentaram correlação negativa com a qualidade de malteação.

Hordeum vulgare; proteínas de reserva; eletroforese


Hordein polypeptide patterns in relation to malting quality in Brazilian barley varieties(1 (1 ) Accepted for publication on October 5, 2000. Supported by FINEP, FAPERGS, CNPq, CAPES, and Companhia Cervejaria Brahma-Filial Maltaria Navegantes. (2 ) Universidade Federal do Rio Grande do Sul, Dep. de Genética, Caixa Postal 15053, CEP 91501-970 Porto Alegre, RS, Brazil. E-mail: ciechart@if.ufrgs.br, scmolina@if.ufrgs.br )

Cinara Echart-Almeida(2 (1 ) Accepted for publication on October 5, 2000. Supported by FINEP, FAPERGS, CNPq, CAPES, and Companhia Cervejaria Brahma-Filial Maltaria Navegantes. (2 ) Universidade Federal do Rio Grande do Sul, Dep. de Genética, Caixa Postal 15053, CEP 91501-970 Porto Alegre, RS, Brazil. E-mail: ciechart@if.ufrgs.br, scmolina@if.ufrgs.br ) and Suzana Cavalli-Molina(2 (1 ) Accepted for publication on October 5, 2000. Supported by FINEP, FAPERGS, CNPq, CAPES, and Companhia Cervejaria Brahma-Filial Maltaria Navegantes. (2 ) Universidade Federal do Rio Grande do Sul, Dep. de Genética, Caixa Postal 15053, CEP 91501-970 Porto Alegre, RS, Brazil. E-mail: ciechart@if.ufrgs.br, scmolina@if.ufrgs.br )

Abstract – Since there is evidence that malting quality is related to the storage protein (hordein) fraction, in the present work the hordein polypeptide patterns from 13 barley (Hordeum vulgare L.) varieties of different malting quality were analysed in order to explore the feasibility of using hordein electrophoresis to assist in the selection of malting barleys. The formation of clusters separating the varieties with higher malting quality from the others with lower quality suggests that there is a relationship between the general hordein polypeptide pattern and malting quality in the varieties analysed. By the Sperman's correlation test three hordein bands correlated negatively with malting quality in the germplasm studied.

Index terms: Hordeum vulgare, storage proteins, electrophoresis.

Padrões de polipeptídios de hordeína em relação à qualidade de malteação em variedades brasileiras de cevada

Resumo – No presente trabalho foi analisado o padrão de polipeptídios de hordeína de 13 variedades de cevada (Hordeum vulgare L.) que apresentam diferentes qualidades de malteação, com o objetivo de verificar a viabilidade de se usar eletroforese de hordeínas na seleção de cevadas usadas para malteação. A formação de agrupamentos separando as variedades que apresentam altos níveis de malteação daquelas com baixa qualidade sugere haver uma clara associação entre a qualidade de malteação e os padrões de hordeína, pelo menos com relação às variedades analisadas. Pelo teste de correlação de Sperman, três bandas apresentaram correlação negativa com a qualidade de malteação.

Termos para indexação: Hordeum vulgare, proteínas de reserva, eletroforese.

Introduction

Barley is an important crop in southern Brazil where its production is almost totally used in the brewing industry and for this purpose the malting quality must be continuously improved. Characteristics of importance for malting quality, which can differ considerably among barley cultivars, include grain size, grain protein concentration, amount of extract obtained from the malt, diastatic power and seed nitrogen (Morgan et al., 1981; Henry, 1990; Weston et al., 1993; Eagles et al., 1995).

Another factor that has been proposed as affecting the malting quality is the storage protein quality. The most abundant proteins in the cereal endosperm are the prolamins (Shewry, 1995). In barley they are known as hordeins and comprise about 40% of all the protein found in the grain (Shewry et al., 1977). Hordein was first described by Osborne (1895) as the barley seed protein soluble in aqueous alcohol. Improved methods for hordein extraction have been developed including the use of reducing agents (Shewry et al., 1978a), the modification of solvent constituents (Shewry et al., 1980b) and the addition of a buffer in the extraction medium (Doll & Andersen, 1981).

Barley is highly polymorphic regarding the hordein polypeptide composition as revealed by sodium dodecyl sulphate (SDS) electrophoretic analyses (Doll & Brown, 1979). As the migration pattern is a varietal characteristic and independent of environmental influences (Shewry et al., 1978b), electrophoresis is particularly attractive as a screening test to differentiate cultivars (Shewry et al., 1980a; Marchylo, 1987) and to determine malting quality (Baxter & Wainwright, 1979; Shewry et al., 1980a). Hordein has also been investigated through different approaches including RFLP analysis (Shewry et al., 1985; Molnar & McKay, 1991), DNA sequencing (Brandt et al., 1985; Entwistle, 1988; Chernyshev et al., 1989; Vicente-Carbajosa et al., 1992; Kanazin et al., 1993), analysis of the regulatory control of hordein genes (Forde et al., 1985), and determination of the mRNA encoded by each locus (Kreis et al., 1983).

The influence of hordein polypeptides on malting quality has already been investigated. Baxter & Wainwright (1979), after studying the B fraction of hordein proteins from 16 varieties, suggested that potential malting quality is related to variations in this fraction. Shewry et al. (1980a) studied 28 barley varieties from United States which could be divided into 11 groups on the basis of hordein band patterns but the authors did not find a clear-cut relationship between B-polypeptides and malting quality. Riggs et al. (1983), in a study of 84 varieties, identified 13 groups based on the band patterns of the B-hordeins, but were unable to demonstrate that varieties known to have good potential malting quality exhibited specific or even related band patterns, although two groups contained only poor malting types. Smith & Simpson (1983) examined 35 barley varieties considering the occurrence of each one of 40 polypeptide bands detected and did not find a relationship between the different bands with malting quality.

The strategies used in these previous studies consisted in separating the varieties based on the number (and intensity in some cases) of the hordein bands (or only B-hordein bands) and to verify a possible association between presence or absence (and more or less intense staining) of these bands in varieties of good or poor malting quality. Considering the importance of identifying factors that influence malting quality and the apparent disagreement between the results obtained using these approaches, the objective of this study was to compare the total hordein pattern from barley varieties of different malting quality,in order to look for relationships between malting quality and band patterns and to explore the feasibility of using hordein electrophoresis to assist in the selection of cultivars for malting.

Material and Methods

Seeds of nine Brazilian malting varieties and four feeding varieties were analysed for the hordein electrophoretic patterns (Table 1). These varieties were selected because they represent a wide range of malting quality. Cultivar Hanna was used as an electrophoretic standard. The possibility of variability in each variety was investigated analysing at least ten seeds from each one.

The malting quality score of each variety was determined and supplied by the quality control laboratory of Companhia Cervejaria Brahma-Filial Maltaria Navegantes, Rio Grande do Sul, Brazil. The score was based on 14 malt characteristics (fine milling, extract, diastatic power, total proteins, and viscosity are the most important ones) and 10 plant characteristics (germinative power, total proteins in dry material, kernel size, among others). Seeds of the Brazilian varieties were obtained directly from breeder stocks, which are routinely subjected to accurate analysis verifying the morphological uniformity of their plants and seeds.

Hordein was extracted from single dry seeds in buffered alcohol, reduced and alkylated as described by Doll & Andersen (1981). Electrophoresis was carried out in vertical sodium dodecyl sulphate polyacrylamide gel (SDS-PAGE) in a discontinuous system with Tris borate buffer (0.125 M Tris, 0.0638 M boric acid) as described by Shewry et al. (1978b). Electrophoresis was performed at a constant current of 20 mA until the tracking dye moved 12 cm into the separating gel. Gels were fixed in methanol and acetic acid, washed and then stained with trichloroacetic acid, methanol and Coomansie brilliant blue R-250, as described by Doll & Andersen (1981). Molecular weights were estimated by comparison with the standards phosphorylase b (MW 94,000), albumin (67,000), ovalbumin (43,000), carbonic anhydrase (30,000), trypsin inhibitor (20,100), and a-lactalbumin (14,400), supplied by Amersham Pharmacia Biotech. Cultivar Hanna was included as a control in all gels.

Phenograms using each variety as an OTU (operational taxonomic unit) were constructed to verify the relationship between the malting quality scores and whole hordein patterns. These phenograms were based on Manhattan distance (Sneath & Sokal, 1973) calculated from frequencies of hordein bands of each variety, and clusterings by Neighbor-joining method using TREECON for Windows program (Peer & Wachter, 1994). The existence or not of an association between single hordein polypeptides and the malting quality scores was estimated by the Sperman's correlation test (Zar, 1996).

Results and Discussion

SDS-PAGE separation of hordein polypeptides from individual endosperms of the varieties analysed are shown in Figure 1. As within-variety variability was found, a compound pattern formed by joining all the bands detected in each variety was constructed (Figure 2). The frequency of each band of hordein polypeptide in each variety is shown in the Table 2.



Twenty-six different hordein polypeptide bands were found in the varieties. A range of 10 to 17 bands was detected for each variety individually. The number of bands in individual seeds ranged from 3 to 13. These numbers are similar to those obtained by Marchylo & Laberge (1981), who found a maximum of 15 bands in each Canadian-grown barley cultivar analysed individually.

Hordein polypeptides have been separated by SDS-PAGE in three fractions which were denominated A, B and C (KÆie et al., 1976). Different analyses have indicated that C-hordein can be separated into polypeptides with molecular weight ranging between 67,000 and 86,000 Da, B-hordein between 30,000 and 60,000 Da, and A-hordein between 13,000 and 20,000 Da (Brandt, 1976; Shewry et al., 1977). In this work, the molecular weight of the polypeptides analysed ranged from approximately 43,000 to 94,000 Da, the majority of them between 43,000 and 67,000 Da. The bands observed in the present study were those of B and C fractions, the major groups of hordein that account for approximately 95% of the total hordein fraction (Entwistle, 1988). A-hordein comprises only 1-2% of the total of the three fractions and apparently is not a true hordein (Miflin & Shewry, 1977).

The phenogram which compares the different varieties shows a clear association between malting quality and the observed hordein patterns (Figure 3). The varieties with the highest malting quality scores (MN-599, MN-668, MN-656, MN-681, MN-682 and BR-2) got together in a unique block while the varieties with lower malting quality scores and the feed types were joined in two different blocks. This indicates that the total hordein pattern was effective in separating the varieties studied based on malting quality. These clusters could have also been obtained as a result of a higher genetic relationship between the grouped varieties due to common ancestors, independently of the malting quality. Nevertheless, this is not the situation of the varieties analysed as shown by their pedigrees (Table 1).


The relationship between single hordein polypeptides and malting quality was verified using the Sperman's correlation test (Table 3). Bands 5 and 12 (P>0.05) and band 19 (P>0.001) correlated negatively with malting quality scores. Thus, the occurrence of these bands, specially band 19, can be used as an indicator of low malting quality.

The Sperman's correlation test did not indicate any relation between band molecular weight and malting quality as was found by Baxter & Wainwright (1979), who related B-hordein with this characteristic, since the bands 5, 12, and 19, which showed significant correlation, have much different molecular weights.

Conclusions

1.The total hordein band pattern can be considered as an effective method based on malting quality scores to discriminate the varieties and can therefore be used as an early screening test to select genotypes for this characteristic in genetic improvement programs.

2.The presence of the hordein bands 5, 12 and 19 can be useful as molecular indicator of a low malting quality.

Acknowledgements

To Dr. Sidia Maria Callegari Jacques for the suggestions on statistical analyses; to Embrapa-Centro Nacional de Pesquisa de Trigo, Embrapa-Centro Nacional de Pesquisa de Recursos Genéticos e Biotecnologia, Estação Experimental de Capão Bonito, and Companhia Cervejaria Brahma-Filial Maltaria Navegantes for supplying the seeds; to FINEP, FAPERGS, CNPq, CAPES and Companhia Cervejaria Brahma for supporting the research.

  • BAXTER, E. D.; WAINWRIGHT, T. Hordein and malting quality. American Society of Brewing Chemists Journal, St. Paul, v. 37, p. 8-12, 1979.
  • BRANDT, A. Endosperm protein formation during kernel development of wild type and a high-lysine barley mutant. Cereal Chemistry, St. Paul, v. 53, p. 890-901, 1976.
  • BRANDT, A.; MONTEMBAULT, A.; CAMERON-MILLS, V.; RASMUSSEN, S. K. Primary structure of a B1 hordein gene from barley. Carlsberg Research Communications, Copenhagen, v. 50, p. 333-345, 1985.
  • CHERNYSHEV, A. I.; KHADIRZHANOVA, D. K.; POMORTSEV, A. A.; ANANIEV, E. V.; SOZINOV, A. A. Nucleotide sequence of a B1 hordein gene of barley Hordeum vulgare L. Genetika, Belgrade, v. 8, p. 1349-1355, 1989.
  • DOLL, H.; ANDERSEN, B. Preparation of barley storage protein, hordein, for analytical sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Analytical Biochemistry, San Diego, v. 115, p. 61-66, 1981.
  • DOLL, H.; BROWN, A. H. D. Hordein variation in wild (Hordeum spontaneum) and cultivated (H. vulgare) barley. Canadian Journal of Genetics and Cytology, Ottawa, v. 21, p. 391-404, 1979.
  • EAGLES, H. A.; BEDGGOOD, A. G.; PANOZZO, J. F.; MARTIN, P. J. Cultivar and environmental effects on malting quality in barley. Australian Journal of Agricultural Research, Collingwood, v. 46, p. 831-844, 1995.
  • ENTWISTLE, J. Primary structure of a C-hordein gene from barley. Carlsberg Research Communications, Copenhagen, v. 53, p. 247-258, 1988.
  • FORDE, B. G.; HEYWORTH, A.; PYWELL, J.; KREIS, M. Nucleotide sequence of a B1 hordein gene and the identification of possible upstream regulatory elements in endosperm storage protein genes from barley, wheat and maize. Nucleic Acids Research, Oxford, v. 13, p. 7327-7339, 1985.
  • HENRY, R. J. Barley quality: an Australian perspective. Aspects of Applied Biology, Madison, v. 25, p. 5-14, 1990.
  • KANAZIN, V.; ANANIEV, E.; BLAKE, T. Variability among members of the Hor-2 multigene family. Genome, Ottawa, v. 36, p. 397-403, 1993.
  • KREIS, M.; RAHMAN, S.; FORDE, B. G.; PYWELL, P. R.; SHEWRY, P. R.; MIFLIN, B. J. Sub-families of hordein mRNA encoded at the Hor 2 locus of barley. Molecular and General Genetics, Berlin, v. 191, p. 194-200, 1983
  • KĆIE, B.; INGVERSEN, J.; ANDERSEN, A. J.; DOLL, H.; EGGUM, B. O. Composition and nutritional quality of barley protein. In: RESEARCH CO-ORDINATION MEETING OF THE SEED PROTEIN IMPROVEMENT PROGRAMME, 3., 1975, Hahnenklee-Bockswiese. Evaluation of seed protein alterations by mutation breeding: proceedings. Vienna : International Atomic Energy Agency, 1976. p. 55-61.
  • MARCHYLO, B. A. Barley cultivar identification by SDS gradient page analysis of hordein. Canadian Journal of Plant Science, Ottawa, v. 67, p. 927-944, 1987.
  • MARCHYLO, B. A.; LABERGE, D. E. Barley cultivar identification by electrophoretic analysis of hordein proteins. II. Catalogue of electrophoregram formulae for Canadian-grown barley cultivars. Canadian Journal of Plant Science, Ottawa, v. 61, p. 859-870, 1981.
  • MIFLIN, B. J.; SHEWRY, P. R. An introduction to the extraction and characterization of barley and maize proteins. In: MIFLIN, B. J.; SHEWRY, P. R. (Ed.). Techniques for the separation of barley and maize proteins Luxembourg : Commission of the European Communities, 1977. p. 13-25.
  • MOLNAR, S. J.; McKAY, A. Restriction fragment analysis of hordein genes in western Canadian two-rowed barleys. Genome, Ottawa, v. 34, p. 298-302, 1991.
  • MORGAN, A. G.; SMITH, D. B.; GILL, A. A. Enzyme activity and interaction with endosperm in barley varieties of varying malting quality during the early stages of germination. In: INTERNATIONAL BARLEY GENETICS SYMPOSIUM, 4., 1981, Edinburgh. Proceedings.. Edinburgh : Edinburgh University Press, 1981. p. 586-595.
  • OSBORN, T. B. The proteins of barley. American Chemical Society Journal, Easton, v. 17, p. 539-567, 1895.
  • PEER, Y. van de; WACHTER, R. de. TREECON for Windows version 1.1: a software package for the construction and drawing of evolutionary trees for the Microsoft Windows environment. Computer Applications in the Biosciences, Oxford, v. 10, p. 569-570, 1994.
  • RIGGS, T. J.; SANADA, M.; MORGAN, A. G.; SMITH, D. B. Use of acid gel electrophoresis in the characterization of "B" hordein protein in relation to malting quality and mildew resistance of barley. Journal of the Science of Food and Agriculture, Chichester, v. 34, p. 576-586, 1983.
  • SHEWRY, P. R. Plant storage proteins. Biological Reviews, Cambridge, Great Britain, v. 70, p. 375-426, 1995.
  • SHEWRY, P. R.; BUNCE, N. A.; KREIS, M.; FORDE, B. G. Polymorphism at the Hor 1 locus of barley (Hordeum vulgare L.). Biochemical Genetics, New York, v. 23, n. 5/6, p. 391-404, 1985.
  • SHEWRY, P. R.; ELLIS, J. R. S.; PRARR, H. M.; MIFLIN, B. J. A comparison of methods for the extraction and separation of hordein fractions from 29 barley varieties. Journal of the Science of Food and Agriculture, Chichester, v. 29, p. 433-441, 1978a.
  • SHEWRY, P. R.; FAULKS, A. J.; PARMAR, S.; MIFLIN, B. J. Hordein polypeptide pattern in relation to malting quality and the varietal identification of malted barley grain. Journal of the Institute of Brewing, London, v. 86, p. 138-141, 1980a.
  • SHEWRY, P. R.; FIELD, J. M.; KIRKMAN, M. A.; FAULTS, A. J.; MIFLIN, B. J. The extraction, solubility, and characterization of two groups of barley storage polypeptides. Journal of Experimental Botany, Oxford, v. 31, p. 393-407, 1980b.
  • SHEWRY, P. R.; PRATT, H. M.; CHARLTON, M. J.; MIFLIN, B. J. Two-dimensional separation of the prolamins of normal and high lysine barley (Hordeum vulgare L.). Journal of Experimental Botany, Oxford, v. 104, p. 597-606, 1977.
  • SHEWRY, P. R.; PRATT, H. M.; FINCH, R. A.; MIFLIN, B. J. The genetic analysis of hordein polypeptides from single seeds of barley. Heredity, Oxford, v. 40, p. 463-466, 1978b.
  • SMITH, D. B.; SIMPSON, P. A. Relationships of barley proteins soluble in sodium dodecyl sulphate to malting quality and varietal identification. Journal of Cereal Science, London, v. 1, p. 185-197, 1983.
  • SNEATH, P. H. A.; SOKAL, R. R. Numerical taxonomy San Francisco : W. H. Freeman, 1973. 573 p.
  • VICENTE-CARBAJOSA, J.; BERITASHVILI, D. R.; KRAEV, A. S.; SKRYABIN, K. G. Conserved structure and organization of B hordein genes in the Hor 2 locus of barley. Plant Molecular Biology, Dordrecht, v. 18, p. 453-458, 1992.
  • WESTON, D. T.; HORSLEY, R. D.; SCHWARZ, P. B.; GOOS, R. J. Nitrogen and planting date effects on low-protein spring barley. Agronomy Journal, Madison, v. 85, p. 1170-1174, 1993.
  • ZAR, J. H. Biostatistical analysis 3. ed. Upper Saddle River : Prentice-Hall, 1996. 662 p.
  • (1
    ) Accepted for publication on October 5, 2000. Supported by FINEP, FAPERGS, CNPq, CAPES, and Companhia Cervejaria Brahma-Filial Maltaria Navegantes.
    (2
    ) Universidade Federal do Rio Grande do Sul, Dep. de Genética, Caixa Postal 15053, CEP 91501-970 Porto Alegre, RS, Brazil. E-mail:
  • Publication Dates

    • Publication in this collection
      22 May 2001
    • Date of issue
      Feb 2001

    History

    • Accepted
      05 Oct 2000
    Embrapa Secretaria de Pesquisa e Desenvolvimento; Pesquisa Agropecuária Brasileira Caixa Postal 040315, 70770-901 Brasília DF Brazil, Tel. +55 61 3448-1813, Fax +55 61 3340-5483 - Brasília - DF - Brazil
    E-mail: pab@embrapa.br