Acessibilidade / Reportar erro

The effect of hot air, vacuum and microwave drying on drying characteristics, rehydration capacity, color, total phenolic content and antioxidant capacity of Kumquat (Citrus japonica)

Abstract

Sliced kumquats were dried by using three different drying methods, microwave (375 W), hot air (70 and 80 °C), and vacuum (70 and 80 °C with 100 and 300 mbar) to determine drying characteristics, antioxidant capacity and total phenolic content and color. All color parameters (L, a, b, Cab, ΔE and ) changed depending on the drying methods. Page and Modified Page models are the best fitted drying methods with the highest value of R2 (0.9994) and the lowest values of RMSE (0.000635-0.000735) and χ2 (0.000010-0.000013) compared to other models. Effective moisture diffusivity values for dried kumquats ranged from 1.54 × 10-8 to 8.24 × 10-8 in vacuum drying at 70 °C-300 mbar and microwave drying at 375 W, respectively. In comparison to the fresh sample, the dried samples showed an increase in both total phenolic content and antioxidant capacity. The total phenolic content (3095.71 ± 101.41 mg GA/100g d.w) and antioxidant activity (10.51 ± 0.19 µmol TE/g d.w) with DPPH assay showed the highest levels for the vacuum drying at 70 °C-100 mbar method. Microwave dried samples had the highest antioxidant activity with CUPRAC assay as (17.58 ± 0.63 µmol TE/g d.w.). This study indicated that microwave drying and vacuum drying at 70 °C-100 mbar were able to yield high-quality kumquat slices.

Keywords:
kumquat; drying methods; drying characteristics; rehydration; antioxidant capacity

1 Introduction

Kumquats (Citrus japonica) the smallest of the citrus fruits ( Young, 1986 Young, R. H. (1986). Fresh fruit cultivars. In V. F. Wardowski, S. Nagy, & W. Grierson (Eds.), Fresh citrus fruit (pp. 101-126). Westport: AVI Publishing. http://dx.doi.org/10.1007/978-1-4684-8792-3_5.
http://dx.doi.org/10.1007/978-1-4684-87...
), can be eaten as fresh, pickled, candied, marmalade or jelly. It has sweet rind and the acidic pulp. The nutrient profile of raw kumquat (exclude seeds) was determined and reported as: water 80.85 g, energy 71 kcal, carbohydrate 15.90 g, total sugars 9.36 g, total dietary fiber 6.5 g, protein 1.88 g, total lipid 0.86 g, ash 0.52 g, per 100 g edible portion. It is also rich in minerals and vitamins; it contains potassium 186 mg, calcium 62 mg, magnesium 20 mg, phosphate 19 mg, sodium 10 mg, vitamin C 43.9 mg per 100 g edible portion ( United States Department of Agriculture Agricultural Research Service, 2016 United States Department of Agriculture Agricultural Research Service – USDA. (2016). National Nutrient Database for Standard Reference Software v.3.8.6.1 2017-07-28 . Washington: The National Agricultural Library. ). Kumquat is planted as ornamental in gardens, parks and as ornamental house plant in patios and terraces. Cultivation of this fruit become widespread in south regions of Turkey as it is rich in several nutritious and bioactive compounds.

Citrus fruits have many health benefits including anticold, antiallergic, antiinflammatory, anticancer activity and antiviral activity ( Attaway & Moore, 1992 Attaway, J. A., & Moore, E. L. (1992). Newly discovered health benefits of citrus fruit and juices. In E. Tribulato, A. Gentile, & G. Reforgiato (Eds.), Proceedings of the International Society for Citriculture (pp. 1136-1139). Acireale: ISC. ; Economos & Clay, 1999 Economos, C., & Clay, W. D. (1999). Nutritional and health benefits of citrus fruit (pp. 11-18). Rome: FAO. ). Kumquats are also used to cure inflammatory respiratory disorders as a part of folk medicine.

Drying is one of the most important preserving methods used in the food industry. This process is mostly used to minimize chemical, microbiological and enzymatic reactions which limit shelf life of fresh fruit and vegetables. Dried foods can consume every season and low moisture content allows them to store longer time than fresh food. Many suitable drying methods present for kumquat such as convective drying, microwave drying and vacuum drying. Air drying is one of the most popular and effective method for drying of foods. It takes a long time with low energy performance to dried foods. Apart from this technique, alternative methods such as vacuum and microwave drying have more advantage such as lower drying temperature, higher drying rate, homogeneous energy delivery on the material, better space utilization, formation of suitable final product characteristics and giving better process control ( Demiray et al., 2017 Demiray, E., Seker, A., & Tulek, Y. (2017). Drying kinetics of onion (Allium cepa L.) slices with convective and microwave drying. Heat and Mass Transfer , 53(5), 1817-1827. http://dx.doi.org/10.1007/s00231-016-1943-x.
http://dx.doi.org/10.1007/s00231-016-19...
; İncedayi et al., 2016 İncedayi, B., Tamer, C. E., Sinir, G. Ö., Suna, S., & Çopur, Ö. U. (2016). Impact of different drying parameters on color, β-carotene, antioxidant activity and minerals of apricot (Prunus armeniaca L.). Food Science and Technology, 36(1), 171-178. http://dx.doi.org/10.1590/1678-457X.0086.
http://dx.doi.org/10.1590/1678-457X.008...
). Mathematical models of drying processes, which are important in the design and optimization of those processes, have been widely utilized for the definition of drying characteristics of foods ( Krokida & Marinos-Kouris, 2003 Krokida, M. K., & Marinos-Kouris, D. (2003). Rehydration kinetics of dehydrated products. Journal of Food Engineering, 57(1), 1-7. http://dx.doi.org/10.1016/S0260-8774(02)00214-5.
http://dx.doi.org/10.1016/S0260-8774(02...
; Babalis & Belessiotis, 2004 Babalis, S. J., & Belessiotis, V. G. (2004). Influence of the drying conditions on the drying constants and moisture diffusivity during thin-layer drying of figs. Journal of Food Engineering, 65(3), 449-458. http://dx.doi.org/10.1016/j.jfoodeng.2004.02.005.
http://dx.doi.org/10.1016/j.jfoodeng.20...
; Alibas, 2012 Alibas, İ. (2012). Microwave drying of grapevine (Vitis vinifera L.) leaves and determination of some quality parameters. Journal of Agricultural Sciences, 18, 43-53. ).

Several studies have been performed about the drying kinetics of orange skin ( Garau et al., 2006 Garau, M. C., Simal, S., Femenia, A., & Rosselló, C. (2006). Drying of orange skin: drying kinetics modelling and functional properties. Journal of Food Engineering , 75(2), 288-295. http://dx.doi.org/10.1016/j.jfoodeng.2005.04.017.
http://dx.doi.org/10.1016/j.jfoodeng.20...
), lemon slices ( Darvishi et al., 2014 Darvishi, H., Khoshtaghaza, M. H., & Minaei, S. (2014). Drying kinetics and color change of lemon slices. International Agrophysics, 28(1), 1-6. http://dx.doi.org/10.2478/intag-2013-0021.
http://dx.doi.org/10.2478/intag-2013-00...
), strawberry ( Méndez-Lagunas et al., 2017 Méndez-Lagunas, L., Rodríguez-Ramírez, J., Cruz-Gracida, M., Sandoval-Torres, S., & Barriada-Bernal, G. (2017). Convective drying kinetics of strawberry (Fragaria ananassa): effects on antioxidant activity, anthocyanins and total phenolic content. Food Chemistry, 230, 174-181. http://dx.doi.org/10.1016/j.foodchem.2017.03.010. PMid:28407898.
http://dx.doi.org/10.1016/j.foodchem.20...
), kiwi ( Kaya et al., 2010 Kaya, A., Aydın, O., & Kolaylı, S. (2010). Effect of different drying conditions on the vitamin C (ascorbic acid) content of Hayward kiwifruits (Actinidia deliciosa Planch). Food and Bioproducts Processing, 88(2-3), 165-173. http://dx.doi.org/10.1016/j.fbp.2008.12.001.
http://dx.doi.org/10.1016/j.fbp.2008.12...
). However there is very limited number of studies which focus on thin-layer drying of the kumquats ( Mohamadi et al., 2012 Mohamadi, M., Asadı, M., Pourfallah, Z., & Nahardani, M. (2012). Mathematical modeling and measure of effective moisture diffusivity in drying process of thin layer kumquat fruit slabs. Journal of Food Science and Technology, 4(2), 47-56. ).

The aim of this study was to determine the hot air, vacuum and microwave drying characteristics of kumquat based on thin-layer drying models at different temperatures, select the best mathematical model for the drying curves and evaluate the effect of drying techniques’ on rehydration capacity, color, total phenolic contents and antioxidant capacity of the kumquats.

2 Materials and methods

2.1 Materials

Fresh kumquats (Citrus japonica, Fortunella japonica Swingle) were purchased from wholesale food market in Antalya, Turkey and stored at 4 ± 0.5 °C. Kumquats were washed, blanched in boiling water for 30 sec, cooled down in cold water and sliced. The average diameter of slices was 20.00 ± 0.25 mm and thickness of sliced pieces was 4.00 ± 0.08 mm. Moisture contents of kumquats were determined by using moisture analyzer (Sartorius MA150, Germany). The initial moisture content of kumquats was 3.01 g water/g dry base.

2.2 Drying processes

Oven drying, vacuum drying and microwave drying methods were used. All experiments were performed in triplicate to obtain the reproducibility in the results of the experiments.

Hot air drying

Hot air drying treatments were performed with a cabinet type laboratory dryer which was produced by Yucebas Machine Analytical Equipment Industry (Y35, Izmir, Turkey) with the technical features of 220 V, 50-60 Hz, 200 W. The temperature and relative humidity in the dryer was measured by temperature sensor (± 2 °C) and relative humidity sensor (± 2%). 50 g of kumquats slices were placed uniformly as a thin layer on an aluminum plate with a 300 mm diameter. Drying experiments were performed at temperatures of 70 and 80 °C and a constant 20% relative humidity. During drying, the samples were weighed at 30 min intervals for 2 hours and followed by every 15 min. The loss of moisture was determined by weighing the plate using a digital balance (Mettler Toledo, MS3002S) measuring to accuracy of 0.01 g.

Vacuum drying

The drying experiments were performed in a vacuum dryer (Memmert VO400, Germany, 49 L volume) at temperature of 70 and 80 °C and absolute pressures of 100 and 300 mbar. 50 g of samples were put down the aluminum plate as it was in convective drying. The moisture loss of samples during drying was recorded at 30 min intervals for 3 hours and followed by every 15 min.

Microwave drying

For this method a domestic digital microwave oven (Hotpoint Ariston, MWHA 2824 B, Italy, 28 L volume) with technical features of 230V~ 50 Hz and maximum output of 900 W was used. The dimensions of the microwave cavity were 520 cm × 479 cm × 341 cm in size and consisted of a rotating glass plate of 315 mm diameter at the base of the oven. Drying treatments were performed at 375 W microwave power level. In the experiments, 50 g of kumquats slices were put down in a thin layer on a rotating glass plate in the microwave oven. During drying, the rotating glass plate was removed from the microwave oven at predetermined intervals (2 min) and weighed using a digital balance (Mettler Toledo, MS3002S). All drying experiments continued until the moisture content of kumquats fell down to about 0.10 g water/g dry base. Every weighing process was carried out in maximum 10 s during drying treatment.

2.3 Mathematical modelling of drying curve

Five different thin-layer drying models were used to select the best model for describing the drying curve of kumquat slices in Table 1 . The moisture ratio (MR) of kumquats slices during drying were calculated using the following Equation 1:

M R = M M e M i M e (1)

where: MR is moisture ratio; M is the moisture content at a specific time (g water/g dry base); Mi is the initial moisture content (g water/g dry base); Me is the equilibrium moisture content (g water/g dry base) ( Arslan & Musa Özcan, 2010 Arslan, D., & Musa Özcan, M. (2010). Study the effect of sun, oven and microwave drying on quality of onion slices. Lebensmittel-Wissenschaft + Technologie , 43(7), 1121-1127. http://dx.doi.org/10.1016/j.lwt.2010.02.019.
http://dx.doi.org/10.1016/j.lwt.2010.02...
).

Table 1
Mathematical models applied to drying characteristics of kumquats slices.

RMSE gives deviation between the estimated and experimental values for the models. The higher correlation coefficient (R2), reduced root mean square error (RMSE) and reduced Chi square (χ2), were used to determine the goodness of fit model in the oven, vacuum and microwave drying curves of kumquats slices. These parameters could be calculated using the following Equations 2 and 3:

R M S E = [ 1 N i = 1 N ( M R exp , i M R p r e , i ) 2 ] 1 2 (2)
χ 2 = i = 1 N ( M R exp , i M R p r e , i ) 2 N n (3)

where: MRexp,i is the experimentally dimensionless moisture ratio for test i; MRpre,i is the predicted dimensionless moisture ratio for test i; N is the number of observation; and n is the number of constants in the model ( Avhad & Marchetti, 2016 Avhad, M. R., & Marchetti, J. M. (2016). Mathematical modelling of drying kinetics of Hass avocado seeds. Industrial Crops and Products, 91, 76-87. http://dx.doi.org/10.1016/j.indcrop.2016.06.035.
http://dx.doi.org/10.1016/j.indcrop.201...
).

2.4 Calculation of effective moisture diffusivity

Fick’s diffusion equation has been widely used to describe the drying process of biological products during the falling rate period ( Dadalı et al., 2007a Dadalı, G., Kılıç Apar, D., & Özbek, B. (2007a). Microwave drying kinetics of okra. Drying Technology, 25(5), 917-924. http://dx.doi.org/10.1080/07373930701372254.
http://dx.doi.org/10.1080/0737393070137...
). The solution of Fick’s second law in slab geometry is given by Crank (1975) Crank, J. (1975). The mathematics of diffusion (2nd ed.). London: Oxford University Press. as shown in Equation 4 , assuming moisture change being only by diffusion, constant temperature and effective moisture diffusivity, and negligible shrinkage ( Demiray et al., 2017 Demiray, E., Seker, A., & Tulek, Y. (2017). Drying kinetics of onion (Allium cepa L.) slices with convective and microwave drying. Heat and Mass Transfer , 53(5), 1817-1827. http://dx.doi.org/10.1007/s00231-016-1943-x.
http://dx.doi.org/10.1007/s00231-016-19...
).

M R = 8 π 2 n = 1 1 ( 2 n 1 ) 2 exp ( ( 2 n 1 ) 2 π 2 D e f f t 4 L 2 ) (4)

where: Deff is effective moisture diffusivity (m2/s); L is the half thickness of the slab in samples (m); and n is a positive integer. In practice, only the first term Equation 5 is written in a logarithmic form as follows:

M R = 8 π 2 exp ( π 2 D e f f t 4 L 2 ) (5)

The effective moisture diffusivity can be calculated by plotting experimental drying data in terms of ln MR versus drying time, using the following Equation 6:

D e f f = s l o p e 4 L 2 π 2 (6)

2.5 Rehydration capacity

Dried kumquats with different methods were rehydrated at 25 °C by using water bath (Memmert, WNE14, Germany) to measure moisture content recovery during rehydration. Five grams of samples added to 150 mL distilled water, in a 250 mL flask beaker. The rehydration process continued for 24 hours, weight increments measured the first 7 hours every 60 minutes and at the end of 24 hours with digital balance (Mettler Toledo, MS3002S). Rehydration capacity was expressed as moisture content over rehydration time. Determinations were made in triplicate ( Demiray & Tulek, 2017a Demiray, E., & Tulek, Y. (2017a). Effect of temperature on water diffusion during rehydration of sun-dried red pepper (Capsicum annuum L.). Heat and Mass Transfer , 53(5), 1829-1834. http://dx.doi.org/10.1007/s00231-016-1940-0.
http://dx.doi.org/10.1007/s00231-016-19...
).

2.6 Color analysis

The color of fresh and dried kumquats was determined by using a Hunter Lab MiniScan EZ4500L (Virginia, USA) calorimeter. The calibration was done with a black and white ceramic plate before the experiments. The Hunter L, a, b values were displayed in lightness, redness and yellowness, respectively. The Hunter L, a, b values were used to calculate total color difference (ΔE), Chroma (C ab) and hue angle (h°) to describe color changes during drying ( Dadalı et al., 2007b Dadalı, G., Demirhan, E., & Ozbek, B. (2007b). Color change kinetics of spinach undergoing microwave drying. Drying Technology, 25(10), 1713-1723. http://dx.doi.org/10.1080/07373930701590988.
http://dx.doi.org/10.1080/0737393070159...
; Suna et al., 2014 Suna, S., Tamer, C. E., Incedayi, B., Ozcan Sinir, G., & Copur, O. U. (2014). Impact of drying methods on physicochemical and sensory properties of apricot pestil. Indian Journal of Traditional Knowledge, 13(1), 47-55. http://dx.doi.org/10.1590/1678-457X.0086.
http://dx.doi.org/10.1590/1678-457X.008...
). Cab changes from 0 (dull) to 60 (vivid) and was calculated by using the following Equation 7:

C h r o m a ( C a b ) = ( a ) 2 + ( b ) 2 (7)

The color of food samples generally characterizes by calculating Hue angle (ho ) value as shown in the Equation 8 . This value is explained in angles of 0°, 90°, 180° and 270°, which represent the color of red, yellow, green and blue, respectively ( Karaaslan & Tuncer, 2008 Karaaslan, S. N., & Tuncer, I. K. (2008). Development of a drying model for combined microwave-fan-assisted convection drying of spinach. Biosystems Engineering, 100(1), 44-52. http://dx.doi.org/10.1016/j.biosystemseng.2007.12.012.
http://dx.doi.org/10.1016/j.biosystemse...
).

h ° = arctan ( b a ) (8)

Total color difference (ΔE) which indicates the saturation of color and was evaluated by using Equation 9 ( Šumić et al., 2013 Šumić, Z., Tepić, A., Vidović, S., Jokić, S., & Malbaša, R. (2013). Optimization of frozen sour cherries vacuum drying process. Food Chemistry, 136(1), 55-63. http://dx.doi.org/10.1016/j.foodchem.2012.07.102. PMid:23017392.
http://dx.doi.org/10.1016/j.foodchem.20...
).

Δ E = ( L L 0 ) 2 + ( a a 0 ) 2 + ( b b 0 ) 2 (9)

where: L0, a0, b0 indicate the value of fresh kumquats color and L, a, b are the individual readings at each processing time.

2.7 Extraction of samples for total phenolic content and antioxidant capacity

The extracts of fresh and dried kumquats were prepared according to Vitali et al. (2009) Vitali, D., Dragojević, I. V., & Šebečić, B. (2009). Effects of incorporation of integral raw materials and dietary fibre on the selected nutritional and functional properties of biscuits. Food Chemistry, 114(4), 1462-1469. http://dx.doi.org/10.1016/j.foodchem.2008.11.032.
http://dx.doi.org/10.1016/j.foodchem.20...
with some modifications. 2 g of grinded (Moulinex, China) kumquat samples was mixed with 20 mL HCl/methanol/water (1:80:10) mixture and shaken by using a rotary shaker (JB50-D; China) at 250 rpm for 2 h at 20 °C. Then the mixture was centrifuged at 3500 rpm for 10 min at 20 °C in a centrifuge (Sigma 3K 30, Germany). The supernatants were stored in falcon tubes at -20 °C until used.

Determination of total phenolic content and antioxidant capacity

Folin-Ciocalteu spectrophotometric method was used for the determination of total phenolics as defined by Spanos & Wrolstad (1990) Spanos, G. A., & Wrolstad, R. E. (1990). Influence of processing and storage on the phenolic composition of Thompson Seedless grape juice. Journal of Agricultural and Food Chemistry, 38(7), 1565-1571. http://dx.doi.org/10.1021/jf00097a030.
http://dx.doi.org/10.1021/jf00097a030 ...
. Total phenolic content was described as mg gallic acid equivalents (GAE) per 100 g dry weight (mg GAE/100g d.w.). Antioxidant capacity of the fresh and dried kumquat slices were measured according to CUPRAC ( Apak et al., 2004 Apak, R., Güçlü, K., Özyürek, M., & Karademir, S. E. (2004). A novel total antioxidant capacity index for dietary polyphenols, vitamin C and E, using their cupric ion reducing capability in the presence of neocuproine: CUPRAC method. Journal of Agricultural and Food Chemistry, 52(26), 7970-7981. http://dx.doi.org/10.1021/jf048741x. PMid:15612784.
http://dx.doi.org/10.1021/jf048741x ...
), DPPH ( Katalinic et al., 2006 Katalinic, V., Milos, M., Kulisic, T., & Jukic, M. (2006). Screening of 70 medicinal plant extracts for antioxidant capacity and total phenols. Food Chemistry , 94(4), 550-557. http://dx.doi.org/10.1016/j.foodchem.2004.12.004.
http://dx.doi.org/10.1016/j.foodchem.20...
) and FRAP ( Benzie & Strain, 1996 Benzie, I. F. F., & Strain, J. J. (1996). The Ferric Reducing Ability of Plasma (FRAP) as a measure of “antioxidant power”: the FRAP assay. Analytical Biochemistry , 239(1), 70-76. http://dx.doi.org/10.1006/abio.1996.0292. PMid:8660627.
http://dx.doi.org/10.1006/abio.1996.029...
) methods and the results were given as µmol Trolox equivalent (TE) per g dry weight (µmol TE/g d.w.) in all assays. All reagents were used in analytical grade.

2.8 Statistical analysis

The experiment was conducted in a completely randomized design with three replications. The results were statistically evaluated by one-way analysis of variance (ANOVA) using the JMP software package version 6.0 (SAS Institute Inc. NC, 27513). When significant differences were found (p < 0.05), the Least Significant Difference (LSD) test was used to determine the differences among means.

3 Results and discussion

3.1 Drying kinetics

The experimental results indicated that the time required for significant reduction in the moisture content was related with the drying techniques. While vacuum drying at 70 °C-300 mbar had the longest drying duration (315 min), microwave of 375 W (42 min) had the shortest one. According to data, total drying time was shortened (86.67%) by microwave drying comparing to vacuum drying at 70 °C-300 mbar. The drying time of kumquats which were hot air dried were respectively 195 and 190 minutes at drying air temperatures of 70 and 80 °C at a constant relative humidity (20%) while vacuum drying at 70 °C-100 mbar, vacuum drying at 80 °C-100 mbar, vacuum drying at 80 °C-300 mbar were respectively 285, 210 and 300 minutes ( Figure 1 ).

Figure 1
Moisture ratio of kumquat slices versus drying time at microwave (A), hot air drying (B) and vacuum drying (C) conditions determined by Page’s equation.

When air temperature raised from 70 °C to 80 °C, the average total drying time decreased 2.56, 26.32, 4.76% under the condition of hot air, 100 mbar vacuum and 300 mbar vacuum, respectively. Moreover, total drying time also decreased (9.52% at 70 °C, 30.00% at 80 °C) when the vacuum increased. Increase in vacuum and temperature allowed decrease in the drying time by accelerating moisture migration from the center to the outside ( Kingsly & Singh, 2007 Kingsly, A. R. P., & Singh, D. B. (2007). Drying kinetics of pomegranate arils. Journal of Food Engineering, 79(2), 741-744. http://dx.doi.org/10.1016/j.jfoodeng.2006.02.033.
http://dx.doi.org/10.1016/j.jfoodeng.20...
). Similar results were attained at air dried orange peel by Garau et al. (2006) Garau, M. C., Simal, S., Femenia, A., & Rosselló, C. (2006). Drying of orange skin: drying kinetics modelling and functional properties. Journal of Food Engineering , 75(2), 288-295. http://dx.doi.org/10.1016/j.jfoodeng.2005.04.017.
http://dx.doi.org/10.1016/j.jfoodeng.20...
, hot air dried apples by Vega-Gálvez et al. (2012) Vega-Gálvez, A., Ah-Hen, K., Chacana, M., Vergara, J., Martínez-Monzó, J., García-Segovia, P., Lemus-Mondaca, R., & Di Scala, K. (2012). Effect of temperature and air velocity on drying kinetics, antioxidant capacity, total phenolic content, color, texture and microstructure of apple (var. Granny Smith) slices. Food Chemistry , 132(1), 51-59. http://dx.doi.org/10.1016/j.foodchem.2011.10.029. PMid:26434262.
http://dx.doi.org/10.1016/j.foodchem.20...
, and vacuum oven dried tomato slices by Azeez et al. (2017) Azeez, L., Adebisi, S. A., Oyedeji, A. O., Adetoro, R. O., & Tijani, K. O. (2017). Bioactive compounds’ contents, drying kinetics and mathematical modelling of tomato slices influenced by drying temperatures and time. Journal of the Saudi Society of Agricultural Sciences. http://dx.doi.org/10.1016/j.jssas.2017.03.002.
http://dx.doi.org/10.1016/j.jssas.2017....
.

3.2 Modelling of drying curves

Statistical results of the different thin-layer drying models, including the suitability of models, drying model coefficients of determination R2, root mean square error (RMSE) and Chi square (χ2), are used to evaluate the quality of dried kumquats ( Table 2 ). The statistical parameter predictions exhibited that R2 values varied between 0.8925 to 0.9994, RMSE values varied between 0.000635 to 0.042941 and χ2 values varied between 0.000010 to 0.026342. The suitable drying methods with the highest value of R2 (0.9994) and the lowest values of RMSE (0.000635-0.000735) and χ 2 (0.000010-0.000013) were obtained from Page and Modified Page models. For this reason, Page and Modified Page models were chosen as the most appropriate models to show the thin-layer drying characteristics of the kumquats when a decision was made between the five models. Akdaş & Başlar (2015) Akdaş, S., & Başlar, M. (2015). Dehydration and degradation kinetics of bioactive compounds for mandarin slices under vacuum and oven drying conditions. Journal of Food Processing and Preservation, 39(6), 1098-1107. http://dx.doi.org/10.1111/jfpp.12324.
http://dx.doi.org/10.1111/jfpp.12324 ...
also determined the best fitted mathematical model as Page for mandarin slices under oven and vacuum drying conditions. Figure 2 shows the moisture content determined by Page’s equation.

Table 2
Statistical values obtained from the modelling of dried kumquats.
Figure 2
Drying curves of kumquat samples at microwave (A), hot air drying (B) and vacuum drying (C).

3.3 Effective moisture diffusivity

The effective moisture diffusivity (Deff) values for different drying methods, calculated from Equation 6 , ranged from 1.54 × 10-8 to 8.24 × 10-8 m2 /s in vacuum drying at 70 °C-300 mbar and microwave drying at 375 W respectively. It was observed that Deff values increased with the rise in temperature of air drying from 2.32 × 10-8 (70 °C) to 2.67 × 10-8 (80 °C) and vacuum drying from 1.54 × 10-8 (70 °C-300mbar) to 2.42 × 10-8 (80 °C-100mbar). The values of Deff in our study were within the general range 10-12-10-8 for drying of food materials ( Demiray & Tulek, 2017b Demiray, E., & Tulek, Y. (2017b). The effect of pretreatments on air drying characteristics of persimmons. Heat and Mass Transfer, 53(1), 99-106. http://dx.doi.org/10.1007/s00231-016-1797-2.
http://dx.doi.org/10.1007/s00231-016-17...
) and comparable to 1.87-3.59 × 10-8 m2/s for dried lemon slices ( Darvishi et al., 2014 Darvishi, H., Khoshtaghaza, M. H., & Minaei, S. (2014). Drying kinetics and color change of lemon slices. International Agrophysics, 28(1), 1-6. http://dx.doi.org/10.2478/intag-2013-0021.
http://dx.doi.org/10.2478/intag-2013-00...
), 9.44 × 10-8-2.56 × 10-7 m2/s for onion slices ( Demiray et al., 2017 Demiray, E., Seker, A., & Tulek, Y. (2017). Drying kinetics of onion (Allium cepa L.) slices with convective and microwave drying. Heat and Mass Transfer , 53(5), 1817-1827. http://dx.doi.org/10.1007/s00231-016-1943-x.
http://dx.doi.org/10.1007/s00231-016-19...
) and 0.35-0.87 × 10-8 m2/s for watermelon pomace ( Oberoi & Sogi, 2015 Oberoi, D. P. S., & Sogi, D. S. (2015). Drying kinetics, moisture diffusivity and lycopene retention of watermelon pomace in different dryers. Journal of Food Science and Technology, 52(11), 7377-7384. http://dx.doi.org/10.1007/s13197-015-1863-7.
http://dx.doi.org/10.1007/s13197-015-18...
).

3.4 Rehydration capacity

The rehydration characteristics are usually considered an important quality parameter of dried products ( Lewicki, 1998 Lewicki, P. P. (1998). Some remarks on rehydration of dried foods. Journal of Food Engineering, 36(1), 81-87. http://dx.doi.org/10.1016/S0260-8774(98)00022-3.
http://dx.doi.org/10.1016/S0260-8774(98...
). The moisture content against rehydration time was shown in Figure 3 . Moisture content was significantly increased within the beginning period of 3 hours whereas water absorption slowed as the curve reached the equilibrium state. The high rate of water absorption at the initial period of rehydration may be clarified by the quick rehydration of capillaries and cavities near the surface, which are rapidly filled up with water ( García-Pascual et al., 2006 García-Pascual, P., Sanjuan, N., Melis, R., & Mulet, A. (2006). Morchella esculenta (morel) rehydration process modelling. Journal of Food Engineering , 72(4), 346-353. http://dx.doi.org/10.1016/j.jfoodeng.2004.12.014.
http://dx.doi.org/10.1016/j.jfoodeng.20...
; Markowski et al., 2009 Markowski, M., Bondaruk, J., & Blaszczak, W. (2009). Rehydration behavior of vacuum-microwave-dried potato cubes. Drying Technology, 27(2), 296-305. http://dx.doi.org/10.1080/07373930802606600.
http://dx.doi.org/10.1080/0737393080260...
). The increase of moisture content during rehydration ranged from 2.09 to 2.58 g water/g dry matter in all dried kumquat samples and the highest moisture content obtained from microwave dried samples. Similar results indicating that microwave energy causes the highest rehydration capacity, were reported by some authors for banana ( Maskan, 2000 Maskan, M. (2000). Microwave/air and microwave finish drying of banana. Journal of Food Engineering, 44(2), 71-78. http://dx.doi.org/10.1016/S0260-8774(99)00167-3.
http://dx.doi.org/10.1016/S0260-8774(99...
), apple ( Askari et al., 2006 Askari, G. R., Emam-Djomeh, Z., & Mousavi, S. M. (2006). Effects of combined coating and microwave assisted hot-air drying on the texture, microstructure and rehydration characteristics of apple slices. Food Science & Technology International, 12(1), 39-46. http://dx.doi.org/10.1177/1082013206062480.
http://dx.doi.org/10.1177/1082013206062...
) and sour cherry ( Horuz et al., 2017 Horuz, E., Bozkurt, H., Karataş, H., & Maskan, M. (2017). Effects of hybrid (microwave-convectional) and convectional drying on drying kinetics, total phenolics, antioxidant capacity, vitamin C, color and rehydration capacity of sour cherries. Food Chemistry, 230, 295-305. http://dx.doi.org/10.1016/j.foodchem.2017.03.046. PMid:28407914.
http://dx.doi.org/10.1016/j.foodchem.20...
). According to Askari et al. (2006) Askari, G. R., Emam-Djomeh, Z., & Mousavi, S. M. (2006). Effects of combined coating and microwave assisted hot-air drying on the texture, microstructure and rehydration characteristics of apple slices. Food Science & Technology International, 12(1), 39-46. http://dx.doi.org/10.1177/1082013206062480.
http://dx.doi.org/10.1177/1082013206062...
, the intercellular gaps caused by microwave energy resulted in the absorption of a high amount of water which concludes an increment in rehydration capacity of dried fruits.

Figure 3
Moisture content uptake against rehydration time of dried kumquats with different methods.

3.5 Color analysis

Color is an important part of food quality, because the color of food is consumers’ first appraise when making purchasing decisions. The results of color changes in fresh sample for all drying conditions were given in Table 3 . Yildiz Turgut et al. (2015) Yildiz Turgut, D., Gölükcü, M., & Tokgöz, H. (2015). Some physical and chemical properties of kumquat (Fortunella margarita Swing .) fruit and jam. Derim, 32(1), 71-80. http://dx.doi.org/10.16882/derim.2015.00773.
http://dx.doi.org/10.16882/derim.2015.0...
reported the L (lightness) value of fresh kumquat as 61.56 ± 0.24 similar to our findings. The L value were significantly affected by different drying treatments (p < 0.05) and resulted with a 2.05-70.77% decrease. The lowest L value obtained from microwave dried samples which had darker color than other drying methods. Compared to the fresh sample, a (redness) values significantly increased (p < 0.05) with vacuum and air drying methods whereas this value reduced in microwave dried kumquats. The increase of a value might be due to the Maillard reaction and degradation of pigments such as carotenoids ( Maskan, 2001 Maskan, M. (2001). Kinetics of colour change of kiwifruits during hot air and microwave drying. Journal of Food Engineering, 48(2), 169-175. http://dx.doi.org/10.1016/S0260-8774(00)00154-0.
http://dx.doi.org/10.1016/S0260-8774(00...
; Lavelli et al., 2007 Lavelli, V., Zanoni, B., & Zaniboni, A. (2007). Effect of water activity on carotenoid degradation in dehydrated carrots. Food Chemistry, 104(4), 1705-1711. http://dx.doi.org/10.1016/j.foodchem.2007.03.033.
http://dx.doi.org/10.1016/j.foodchem.20...
; Xiao et al., 2012 Xiao, H. W., Yao, X. D., Lin, H., Yang, W. X., Meng, J. S., & Gao, Z. J. (2012). Effect of SSB (superheated steam blanching) time and drying temperature on hot air impingement drying kinetics and quality attributes of yam slices. Journal of Food Process Engineering , 35(3), 370-390. http://dx.doi.org/10.1111/j.1745-4530.2010.00594.x.
http://dx.doi.org/10.1111/j.1745-4530.2...
). b values of dried kumquats with vacuum drying at 70 °C-100 mbar, 70 °C-300 mbar and air drying at 80 °C increased with respect to fresh kumquat samples. However, compared to fresh sample, microwave drying caused 58.50% decrease in b value and this was closely followed for Chroma (Cab ) (57.71%). (Cab) values were used to comprehend intensity of color. Vacuum dried samples at 70 °C-300 mbar showed the highest C ab value (72.70 ± 0.29) as compared to other treatments. The lowest ΔE value (3.24 ± 0.17) was obtained from vacuum drying at 80 °C-100 mbar sample while the highest value (35.47 ± 0.57) was obtained from vacuum drying at 70 °C-300 mbar. Hawlader et al. (2006) Hawlader, M. N. A., Perera, C. O., & Tian, M. (2006). Properties of modified atmosphere heat pump dried foods. Journal of Food Engineering, 74(3), 392-401. http://dx.doi.org/10.1016/j.jfoodeng.2005.03.028.
http://dx.doi.org/10.1016/j.jfoodeng.20...
explained that the reduction in values is an expression of more darkening color. Vacuum drying at 70 °C-100 mbar caused a smaller reduction of values. Besides pigment decompositions, non-enzymatic and enzymatic reactions are responsible for the formation of browning pigments ( Albanese et al., 2013 Albanese, D., Cinquanta, L., Cuccurullo, G., & Di Matteo, M. (2013). Effects of microwave and hot‐air drying methods on color β‐carotene and radical scavenging activity of apricots. International Journal of Food Science & Technology , 48(6), 1327-1333. http://dx.doi.org/10.1111/ijfs.12095.
http://dx.doi.org/10.1111/ijfs.12095 ...
).

Table 3
Color values of fresh and dried kumquat.

3.6 Total phenolic content

The total phenolic contents (TPC) of fresh and dried kumquats were given in Figure 4 . Fresh kumquats had 266.68 ± 14.57 mg GA/100 g d.w. TPC. Lou et al. (2015) Lou, S. N., Lai, Y. C., Huang, J. D., Ho, C. T., Ferng, L. H. A., & Chang, Y. C. (2015). Drying effect on flavonoid composition and antioxidant activity of immature kumquat. Food Chemistry, 171, 356-363. http://dx.doi.org/10.1016/j.foodchem.2014.08.119. PMid:25308680.
http://dx.doi.org/10.1016/j.foodchem.20...
reported the total phenolic content of hot water extracts of fresh immature kumquats as approximately 1500 GAE mg/100 g dry extract which is higher than our findings. Hot water extraction might lead destruction of the cell wall structure which may allow an increase in extracted phenolic constituents.

Figure 4
The effect of drying treatments on kumquats’ antioxidant capacities and total phenolic content. *TE = trolox equivalent; **GAE = gallic acid equivalent; d.w. = dry weight.

Different drying techniques provide a variety of TPC. The highest TPC (3095.71 ± 101.41 mg GA/100g d.w.) was attained by vacuum drying at 70 °C-100 mbar (p < 0.05) ( Figure 4 ). Several studies reported that vacuum drying technique is allow minimum degradation in phenolic content compared to hot air drying ( Karaman et al., 2014 Karaman, S., Toker, O. S., Çam, M., Hayta, M., Doğan, M., & Kayacier, A. (2014). Bioactive and physicochemical properties of persimmon as affected by drying methods. Drying Technology, 32(3), 258-267. http://dx.doi.org/10.1080/07373937.2013.821480.
http://dx.doi.org/10.1080/07373937.2013...
; Ruiz et al., 2014 Ruiz, N. A. Q., Demarchi, S. M., & Giner, S. A. (2014). Effect of hot air, vacuum and infrared drying methods on quality of rose hip (Rosa rubiginosa) leathers. International Journal of Food Science & Technology, 49(8), 1799-1804. http://dx.doi.org/10.1111/ijfs.12486.
http://dx.doi.org/10.1111/ijfs.12486 ...
). The results indicated that degradation of phenolic components in kumquats during hot air drying at 70 °C was highest, with lowest TPC (2181.32 ± 52.16 mg GA/100 g d.w.) determined (p < 0.05).

Ramful et al. (2011) Ramful, D., Tarnus, E., Aruoma, O. I., Bourdon, E., & Bahorun, T. (2011). Polyphenol composition, vitamin C content and antioxidant capacity of Mauritian citrus fruit pulps. Food Research International, 44(7), 2088-2099. http://dx.doi.org/10.1016/j.foodres.2011.03.056.
http://dx.doi.org/10.1016/j.foodres.201...
measured TPC of freeze dried kumquat pulp powders, extracted with 80% methanol, as 1412 ± 16 and 1694 ± 19 μg g−1 f.w. Ishiwata et al. (2004) Ishiwata, K., Yamaguchi, T., Takamura, H., & Matoba, T. (2004). DPPH radical-scavenging activity and poly phenol content in dried fruits. Food Science and Technology Research , 10(2), 152-156. http://dx.doi.org/10.3136/fstr.10.152.
http://dx.doi.org/10.3136/fstr.10.152 ...
investigated the total polyphenol content in dried kumquats bought from local market in Japan. According to their findings, TPC content was 530 ± 4 mg GAE/100g d.w. which was much lower than our results.

The similar increment in total phenolic content was obtained by Türkmen et al. (2005) Türkmen, N., Sari, F., & Velioğlu, S. (2005). The effect of cooking methods on total phenolics and antioxidant activity of selected green vegetables. Food Chemistry, 93(4), 713-718. http://dx.doi.org/10.1016/j.foodchem.2004.12.038.
http://dx.doi.org/10.1016/j.foodchem.20...
and Priecina & Karklina (2014) Priecina, L., & Karklina, D. (2014). Natural antioxidant changes in fresh and dried spices and vegetables. International Scholarly and Scientific Research & Innovation , 8(5), 492-496. .

3.7 Antioxidant capacity

The antioxidant capacity of the fresh and the dried kumquats were given in Figure 4 . Antioxidant capacity can be measured by several methods which have different mechanisms Antioxidant capacity of the fresh sample was found as 1.84 and 2.50 µmol TE/g d.w. respectively in DPPH and CUPRAC methods.

Antioxidant capacity of fresh kumquat was significantly lower compared to dried kumquats (p < 0.05). The highest antioxidant capacity was obtained from vacuum drying at 70 °C-100 mbar (10.51 ± 0.19 µmol TE/g d.w.) and vacuum drying at 80 °C-300 mbar (10.30 ± 0.49 µmol TE/g d.w.) in DPPH assay and microwave drying (17.58 ± 0.63 µmol TE/g d.w.) in CUPRAC assay. The lowest antioxidant capacity was determined in hot air drying technique at 70 °C both in DPPH (5.13 ± 0.07 µmol TE/g d.w.) and CUPRAC (6.47 ± 0.04 µmol TE/g d.w.) assays. Vega-Gálvez et al. (2012) Vega-Gálvez, A., Ah-Hen, K., Chacana, M., Vergara, J., Martínez-Monzó, J., García-Segovia, P., Lemus-Mondaca, R., & Di Scala, K. (2012). Effect of temperature and air velocity on drying kinetics, antioxidant capacity, total phenolic content, color, texture and microstructure of apple (var. Granny Smith) slices. Food Chemistry , 132(1), 51-59. http://dx.doi.org/10.1016/j.foodchem.2011.10.029. PMid:26434262.
http://dx.doi.org/10.1016/j.foodchem.20...
determined an increase in DPPH free radical scavenging activity of hot air dried pepper slabs. Türkmen et al. (2005) Türkmen, N., Sari, F., & Velioğlu, S. (2005). The effect of cooking methods on total phenolics and antioxidant activity of selected green vegetables. Food Chemistry, 93(4), 713-718. http://dx.doi.org/10.1016/j.foodchem.2004.12.038.
http://dx.doi.org/10.1016/j.foodchem.20...
found an enhancement in antioxidant activity as a result of cooking methods (boiling, steaming and microwave) in pepper, green beans, broccoli, and spinach. In line with our study, Priecina & Karklina (2014) Priecina, L., & Karklina, D. (2014). Natural antioxidant changes in fresh and dried spices and vegetables. International Scholarly and Scientific Research & Innovation , 8(5), 492-496. also identified increment in antioxidant activity of some vegetables.

Drying with microwave technique, which had the lowest L value, allowed more browning reactions compared to the other techniques. In this situation, the highest measured antioxidant capacity with CUPRAC could be explained by formation of Maillard reaction products which have high antioxidant properties ( Manzocco et al., 2000 Manzocco, L., Calligaris, S., Mastrocola, D., Nicoli, M. C., & Lerici, C. R. (2000). Review of non-enzymatic browning and antioxidant capacity in processed foods. Trends in Food Science & Technology, 11(9-10), 340-346. http://dx.doi.org/10.1016/S0924-2244(01)00014-0.
http://dx.doi.org/10.1016/S0924-2244(01...
).

4 Conclusion

Drying kinetics, rehydration capacity, color, TPC and antioxidant capacity of kumquats dried with hot air, vacuum and microwave were investigated. Microwave drying significantly shortened the drying duration in proportion to hot air and vacuum drying. Also the highest effective moisture diffusivity was observed by microwave drying. Among the mathematical models, the Page and Modified Page models were considered to be the best models to describe the drying characteristics of kumquats. While L and values decreased, a value increased in dried samples except microwave dried one. Microwave dried kumquats had the lowest L, a, b and C ab values. In addition, the highest rehydration capacity was obtained by microwave dried samples. Vacuum drying was defined as the best method for preserving color values. Total phenolic content and antioxidant capacity of dried kumquats were increased after drying. The total phenolic content and antioxidant activity with DPPH assay showed the highest levels for the vacuum drying at 70 °C-100 mbar method. Microwave dried samples had the highest antioxidant activity with CUPRAC assay. In consequence, microwave drying was found applicable for kumquats in order to reduce the drying time as well as enhancing bioactive content, but color of dried kumquats were not preferable. This was the first study not only investigate the effect of different drying methods on kumquat quality but also reveal the bioactive contents of dried fruit. More studies are need for further comparison.

Acknowledgements

The authors would like to thank to Laetitia Dupuy for her review of the article and constructive suggestions.

  • Practical Application: Optimum drying conditions were evaluated and dried fruit and food ingredient were obtained.

References

  • Akdaş, S., & Başlar, M. (2015). Dehydration and degradation kinetics of bioactive compounds for mandarin slices under vacuum and oven drying conditions. Journal of Food Processing and Preservation, 39(6), 1098-1107. http://dx.doi.org/10.1111/jfpp.12324.
    » http://dx.doi.org/10.1111/jfpp.12324
  • Albanese, D., Cinquanta, L., Cuccurullo, G., & Di Matteo, M. (2013). Effects of microwave and hot‐air drying methods on color β‐carotene and radical scavenging activity of apricots. International Journal of Food Science & Technology , 48(6), 1327-1333. http://dx.doi.org/10.1111/ijfs.12095.
    » http://dx.doi.org/10.1111/ijfs.12095
  • Alibas, İ. (2012). Microwave drying of grapevine (Vitis vinifera L.) leaves and determination of some quality parameters. Journal of Agricultural Sciences, 18, 43-53.
  • Apak, R., Güçlü, K., Özyürek, M., & Karademir, S. E. (2004). A novel total antioxidant capacity index for dietary polyphenols, vitamin C and E, using their cupric ion reducing capability in the presence of neocuproine: CUPRAC method. Journal of Agricultural and Food Chemistry, 52(26), 7970-7981. http://dx.doi.org/10.1021/jf048741x. PMid:15612784.
    » http://dx.doi.org/10.1021/jf048741x
  • Arslan, D., & Musa Özcan, M. (2010). Study the effect of sun, oven and microwave drying on quality of onion slices. Lebensmittel-Wissenschaft + Technologie , 43(7), 1121-1127. http://dx.doi.org/10.1016/j.lwt.2010.02.019.
    » http://dx.doi.org/10.1016/j.lwt.2010.02.019
  • Askari, G. R., Emam-Djomeh, Z., & Mousavi, S. M. (2006). Effects of combined coating and microwave assisted hot-air drying on the texture, microstructure and rehydration characteristics of apple slices. Food Science & Technology International, 12(1), 39-46. http://dx.doi.org/10.1177/1082013206062480.
    » http://dx.doi.org/10.1177/1082013206062480
  • Attaway, J. A., & Moore, E. L. (1992). Newly discovered health benefits of citrus fruit and juices. In E. Tribulato, A. Gentile, & G. Reforgiato (Eds.), Proceedings of the International Society for Citriculture (pp. 1136-1139). Acireale: ISC.
  • Avhad, M. R., & Marchetti, J. M. (2016). Mathematical modelling of drying kinetics of Hass avocado seeds. Industrial Crops and Products, 91, 76-87. http://dx.doi.org/10.1016/j.indcrop.2016.06.035.
    » http://dx.doi.org/10.1016/j.indcrop.2016.06.035
  • Azeez, L., Adebisi, S. A., Oyedeji, A. O., Adetoro, R. O., & Tijani, K. O. (2017). Bioactive compounds’ contents, drying kinetics and mathematical modelling of tomato slices influenced by drying temperatures and time. Journal of the Saudi Society of Agricultural Sciences http://dx.doi.org/10.1016/j.jssas.2017.03.002.
    » http://dx.doi.org/10.1016/j.jssas.2017.03.002
  • Babalis, S. J., & Belessiotis, V. G. (2004). Influence of the drying conditions on the drying constants and moisture diffusivity during thin-layer drying of figs. Journal of Food Engineering, 65(3), 449-458. http://dx.doi.org/10.1016/j.jfoodeng.2004.02.005.
    » http://dx.doi.org/10.1016/j.jfoodeng.2004.02.005
  • Benzie, I. F. F., & Strain, J. J. (1996). The Ferric Reducing Ability of Plasma (FRAP) as a measure of “antioxidant power”: the FRAP assay. Analytical Biochemistry , 239(1), 70-76. http://dx.doi.org/10.1006/abio.1996.0292. PMid:8660627.
    » http://dx.doi.org/10.1006/abio.1996.0292
  • Crank, J. (1975). The mathematics of diffusion (2nd ed.). London: Oxford University Press.
  • Dadalı, G., Kılıç Apar, D., & Özbek, B. (2007a). Microwave drying kinetics of okra. Drying Technology, 25(5), 917-924. http://dx.doi.org/10.1080/07373930701372254.
    » http://dx.doi.org/10.1080/07373930701372254
  • Dadalı, G., Demirhan, E., & Ozbek, B. (2007b). Color change kinetics of spinach undergoing microwave drying. Drying Technology, 25(10), 1713-1723. http://dx.doi.org/10.1080/07373930701590988.
    » http://dx.doi.org/10.1080/07373930701590988
  • Darvishi, H., Khoshtaghaza, M. H., & Minaei, S. (2014). Drying kinetics and color change of lemon slices. International Agrophysics, 28(1), 1-6. http://dx.doi.org/10.2478/intag-2013-0021.
    » http://dx.doi.org/10.2478/intag-2013-0021
  • Demiray, E., & Tulek, Y. (2017a). Effect of temperature on water diffusion during rehydration of sun-dried red pepper (Capsicum annuum L.). Heat and Mass Transfer , 53(5), 1829-1834. http://dx.doi.org/10.1007/s00231-016-1940-0.
    » http://dx.doi.org/10.1007/s00231-016-1940-0
  • Demiray, E., & Tulek, Y. (2017b). The effect of pretreatments on air drying characteristics of persimmons. Heat and Mass Transfer, 53(1), 99-106. http://dx.doi.org/10.1007/s00231-016-1797-2.
    » http://dx.doi.org/10.1007/s00231-016-1797-2
  • Demiray, E., Seker, A., & Tulek, Y. (2017). Drying kinetics of onion (Allium cepa L.) slices with convective and microwave drying. Heat and Mass Transfer , 53(5), 1817-1827. http://dx.doi.org/10.1007/s00231-016-1943-x.
    » http://dx.doi.org/10.1007/s00231-016-1943-x
  • Doymaz, I. (2006). Drying kinetics of black grapes treated with different solutions. Journal of Food Engineering, 76(2), 212-217. http://dx.doi.org/10.1016/j.jfoodeng.2005.05.009.
    » http://dx.doi.org/10.1016/j.jfoodeng.2005.05.009
  • Economos, C., & Clay, W. D. (1999). Nutritional and health benefits of citrus fruit (pp. 11-18). Rome: FAO.
  • Garau, M. C., Simal, S., Femenia, A., & Rosselló, C. (2006). Drying of orange skin: drying kinetics modelling and functional properties. Journal of Food Engineering , 75(2), 288-295. http://dx.doi.org/10.1016/j.jfoodeng.2005.04.017.
    » http://dx.doi.org/10.1016/j.jfoodeng.2005.04.017
  • García-Pascual, P., Sanjuan, N., Melis, R., & Mulet, A. (2006). Morchella esculenta (morel) rehydration process modelling. Journal of Food Engineering , 72(4), 346-353. http://dx.doi.org/10.1016/j.jfoodeng.2004.12.014.
    » http://dx.doi.org/10.1016/j.jfoodeng.2004.12.014
  • Hawlader, M. N. A., Perera, C. O., & Tian, M. (2006). Properties of modified atmosphere heat pump dried foods. Journal of Food Engineering, 74(3), 392-401. http://dx.doi.org/10.1016/j.jfoodeng.2005.03.028.
    » http://dx.doi.org/10.1016/j.jfoodeng.2005.03.028
  • Horuz, E., Bozkurt, H., Karataş, H., & Maskan, M. (2017). Effects of hybrid (microwave-convectional) and convectional drying on drying kinetics, total phenolics, antioxidant capacity, vitamin C, color and rehydration capacity of sour cherries. Food Chemistry, 230, 295-305. http://dx.doi.org/10.1016/j.foodchem.2017.03.046. PMid:28407914.
    » http://dx.doi.org/10.1016/j.foodchem.2017.03.046
  • İncedayi, B., Tamer, C. E., Sinir, G. Ö., Suna, S., & Çopur, Ö. U. (2016). Impact of different drying parameters on color, β-carotene, antioxidant activity and minerals of apricot (Prunus armeniaca L.). Food Science and Technology, 36(1), 171-178. http://dx.doi.org/10.1590/1678-457X.0086.
    » http://dx.doi.org/10.1590/1678-457X.0086
  • Ishiwata, K., Yamaguchi, T., Takamura, H., & Matoba, T. (2004). DPPH radical-scavenging activity and poly phenol content in dried fruits. Food Science and Technology Research , 10(2), 152-156. http://dx.doi.org/10.3136/fstr.10.152.
    » http://dx.doi.org/10.3136/fstr.10.152
  • Karaaslan, S. N., & Tuncer, I. K. (2008). Development of a drying model for combined microwave-fan-assisted convection drying of spinach. Biosystems Engineering, 100(1), 44-52. http://dx.doi.org/10.1016/j.biosystemseng.2007.12.012.
    » http://dx.doi.org/10.1016/j.biosystemseng.2007.12.012
  • Karaman, S., Toker, O. S., Çam, M., Hayta, M., Doğan, M., & Kayacier, A. (2014). Bioactive and physicochemical properties of persimmon as affected by drying methods. Drying Technology, 32(3), 258-267. http://dx.doi.org/10.1080/07373937.2013.821480.
    » http://dx.doi.org/10.1080/07373937.2013.821480
  • Katalinic, V., Milos, M., Kulisic, T., & Jukic, M. (2006). Screening of 70 medicinal plant extracts for antioxidant capacity and total phenols. Food Chemistry , 94(4), 550-557. http://dx.doi.org/10.1016/j.foodchem.2004.12.004.
    » http://dx.doi.org/10.1016/j.foodchem.2004.12.004
  • Kaya, A., Aydın, O., & Kolaylı, S. (2010). Effect of different drying conditions on the vitamin C (ascorbic acid) content of Hayward kiwifruits (Actinidia deliciosa Planch). Food and Bioproducts Processing, 88(2-3), 165-173. http://dx.doi.org/10.1016/j.fbp.2008.12.001.
    » http://dx.doi.org/10.1016/j.fbp.2008.12.001
  • Kingsly, A. R. P., & Singh, D. B. (2007). Drying kinetics of pomegranate arils. Journal of Food Engineering, 79(2), 741-744. http://dx.doi.org/10.1016/j.jfoodeng.2006.02.033.
    » http://dx.doi.org/10.1016/j.jfoodeng.2006.02.033
  • Krokida, M. K., & Marinos-Kouris, D. (2003). Rehydration kinetics of dehydrated products. Journal of Food Engineering, 57(1), 1-7. http://dx.doi.org/10.1016/S0260-8774(02)00214-5.
    » http://dx.doi.org/10.1016/S0260-8774(02)00214-5
  • Lavelli, V., Zanoni, B., & Zaniboni, A. (2007). Effect of water activity on carotenoid degradation in dehydrated carrots. Food Chemistry, 104(4), 1705-1711. http://dx.doi.org/10.1016/j.foodchem.2007.03.033.
    » http://dx.doi.org/10.1016/j.foodchem.2007.03.033
  • Lewicki, P. P. (1998). Some remarks on rehydration of dried foods. Journal of Food Engineering, 36(1), 81-87. http://dx.doi.org/10.1016/S0260-8774(98)00022-3.
    » http://dx.doi.org/10.1016/S0260-8774(98)00022-3
  • Lou, S. N., Lai, Y. C., Huang, J. D., Ho, C. T., Ferng, L. H. A., & Chang, Y. C. (2015). Drying effect on flavonoid composition and antioxidant activity of immature kumquat. Food Chemistry, 171, 356-363. http://dx.doi.org/10.1016/j.foodchem.2014.08.119. PMid:25308680.
    » http://dx.doi.org/10.1016/j.foodchem.2014.08.119
  • Manzocco, L., Calligaris, S., Mastrocola, D., Nicoli, M. C., & Lerici, C. R. (2000). Review of non-enzymatic browning and antioxidant capacity in processed foods. Trends in Food Science & Technology, 11(9-10), 340-346. http://dx.doi.org/10.1016/S0924-2244(01)00014-0.
    » http://dx.doi.org/10.1016/S0924-2244(01)00014-0
  • Markowski, M., Bondaruk, J., & Blaszczak, W. (2009). Rehydration behavior of vacuum-microwave-dried potato cubes. Drying Technology, 27(2), 296-305. http://dx.doi.org/10.1080/07373930802606600.
    » http://dx.doi.org/10.1080/07373930802606600
  • Maskan, M. (2000). Microwave/air and microwave finish drying of banana. Journal of Food Engineering, 44(2), 71-78. http://dx.doi.org/10.1016/S0260-8774(99)00167-3.
    » http://dx.doi.org/10.1016/S0260-8774(99)00167-3
  • Maskan, M. (2001). Kinetics of colour change of kiwifruits during hot air and microwave drying. Journal of Food Engineering, 48(2), 169-175. http://dx.doi.org/10.1016/S0260-8774(00)00154-0.
    » http://dx.doi.org/10.1016/S0260-8774(00)00154-0
  • Méndez-Lagunas, L., Rodríguez-Ramírez, J., Cruz-Gracida, M., Sandoval-Torres, S., & Barriada-Bernal, G. (2017). Convective drying kinetics of strawberry (Fragaria ananassa): effects on antioxidant activity, anthocyanins and total phenolic content. Food Chemistry, 230, 174-181. http://dx.doi.org/10.1016/j.foodchem.2017.03.010. PMid:28407898.
    » http://dx.doi.org/10.1016/j.foodchem.2017.03.010
  • Mohamadi, M., Asadı, M., Pourfallah, Z., & Nahardani, M. (2012). Mathematical modeling and measure of effective moisture diffusivity in drying process of thin layer kumquat fruit slabs. Journal of Food Science and Technology, 4(2), 47-56.
  • Oberoi, D. P. S., & Sogi, D. S. (2015). Drying kinetics, moisture diffusivity and lycopene retention of watermelon pomace in different dryers. Journal of Food Science and Technology, 52(11), 7377-7384. http://dx.doi.org/10.1007/s13197-015-1863-7.
    » http://dx.doi.org/10.1007/s13197-015-1863-7
  • Overhults, D. D., White, G. M., Hamilton, M. E., & Ross, I. J. (1973). Drying soybeans with heated air. Transactions of the ASAE. American Society of Agricultural Engineers , 16(1), 195-200. http://dx.doi.org/10.13031/2013.37459.
    » http://dx.doi.org/10.13031/2013.37459
  • Priecina, L., & Karklina, D. (2014). Natural antioxidant changes in fresh and dried spices and vegetables. International Scholarly and Scientific Research & Innovation , 8(5), 492-496.
  • Ramful, D., Tarnus, E., Aruoma, O. I., Bourdon, E., & Bahorun, T. (2011). Polyphenol composition, vitamin C content and antioxidant capacity of Mauritian citrus fruit pulps. Food Research International, 44(7), 2088-2099. http://dx.doi.org/10.1016/j.foodres.2011.03.056.
    » http://dx.doi.org/10.1016/j.foodres.2011.03.056
  • Ruiz, N. A. Q., Demarchi, S. M., & Giner, S. A. (2014). Effect of hot air, vacuum and infrared drying methods on quality of rose hip (Rosa rubiginosa) leathers. International Journal of Food Science & Technology, 49(8), 1799-1804. http://dx.doi.org/10.1111/ijfs.12486.
    » http://dx.doi.org/10.1111/ijfs.12486
  • Sarsavadia, P. N., Sawhney, R. L., Pangavhane, D. R., & Singh, S. P. (1999). Drying behaviour of brined onion slices. Journal of Food Engineering, 40(3), 219-226. http://dx.doi.org/10.1016/S0260-8774(99)00058-8.
    » http://dx.doi.org/10.1016/S0260-8774(99)00058-8
  • Spanos, G. A., & Wrolstad, R. E. (1990). Influence of processing and storage on the phenolic composition of Thompson Seedless grape juice. Journal of Agricultural and Food Chemistry, 38(7), 1565-1571. http://dx.doi.org/10.1021/jf00097a030.
    » http://dx.doi.org/10.1021/jf00097a030
  • Šumić, Z., Tepić, A., Vidović, S., Jokić, S., & Malbaša, R. (2013). Optimization of frozen sour cherries vacuum drying process. Food Chemistry, 136(1), 55-63. http://dx.doi.org/10.1016/j.foodchem.2012.07.102. PMid:23017392.
    » http://dx.doi.org/10.1016/j.foodchem.2012.07.102
  • Suna, S., Tamer, C. E., Incedayi, B., Ozcan Sinir, G., & Copur, O. U. (2014). Impact of drying methods on physicochemical and sensory properties of apricot pestil. Indian Journal of Traditional Knowledge, 13(1), 47-55. http://dx.doi.org/10.1590/1678-457X.0086.
    » http://dx.doi.org/10.1590/1678-457X.0086
  • Türkmen, N., Sari, F., & Velioğlu, S. (2005). The effect of cooking methods on total phenolics and antioxidant activity of selected green vegetables. Food Chemistry, 93(4), 713-718. http://dx.doi.org/10.1016/j.foodchem.2004.12.038.
    » http://dx.doi.org/10.1016/j.foodchem.2004.12.038
  • United States Department of Agriculture Agricultural Research Service – USDA. (2016). National Nutrient Database for Standard Reference Software v.3.8.6.1 2017-07-28 . Washington: The National Agricultural Library.
  • Vega-Gálvez, A., Ah-Hen, K., Chacana, M., Vergara, J., Martínez-Monzó, J., García-Segovia, P., Lemus-Mondaca, R., & Di Scala, K. (2012). Effect of temperature and air velocity on drying kinetics, antioxidant capacity, total phenolic content, color, texture and microstructure of apple (var. Granny Smith) slices. Food Chemistry , 132(1), 51-59. http://dx.doi.org/10.1016/j.foodchem.2011.10.029. PMid:26434262.
    » http://dx.doi.org/10.1016/j.foodchem.2011.10.029
  • Vitali, D., Dragojević, I. V., & Šebečić, B. (2009). Effects of incorporation of integral raw materials and dietary fibre on the selected nutritional and functional properties of biscuits. Food Chemistry, 114(4), 1462-1469. http://dx.doi.org/10.1016/j.foodchem.2008.11.032.
    » http://dx.doi.org/10.1016/j.foodchem.2008.11.032
  • Westerman, P. W., White, G. M., & Ross, I. J. (1973). Relative humidity effect on the high temperature drying of shelled corn. Transactions of the ASAE. American Society of Agricultural Engineers, 16(6), 1136-1139. http://dx.doi.org/10.13031/2013.37715.
    » http://dx.doi.org/10.13031/2013.37715
  • Xiao, H. W., Yao, X. D., Lin, H., Yang, W. X., Meng, J. S., & Gao, Z. J. (2012). Effect of SSB (superheated steam blanching) time and drying temperature on hot air impingement drying kinetics and quality attributes of yam slices. Journal of Food Process Engineering , 35(3), 370-390. http://dx.doi.org/10.1111/j.1745-4530.2010.00594.x.
    » http://dx.doi.org/10.1111/j.1745-4530.2010.00594.x
  • Yagcioglu, A. (1999). Drying technique of agricultural products (Faculty of Agriculture Publications, Vol. 536). Bornova: Ege University.
  • Yildiz Turgut, D., Gölükcü, M., & Tokgöz, H. (2015). Some physical and chemical properties of kumquat (Fortunella margarita Swing .) fruit and jam. Derim, 32(1), 71-80. http://dx.doi.org/10.16882/derim.2015.00773.
    » http://dx.doi.org/10.16882/derim.2015.00773
  • Young, R. H. (1986). Fresh fruit cultivars. In V. F. Wardowski, S. Nagy, & W. Grierson (Eds.), Fresh citrus fruit (pp. 101-126). Westport: AVI Publishing. http://dx.doi.org/10.1007/978-1-4684-8792-3_5.
    » http://dx.doi.org/10.1007/978-1-4684-8792-3_5

Publication Dates

  • Publication in this collection
    22 Oct 2018
  • Date of issue
    Apr-Jun 2019

History

  • Received
    16 Oct 2017
  • Accepted
    29 May 2018
Sociedade Brasileira de Ciência e Tecnologia de Alimentos Av. Brasil, 2880, Caixa Postal 271, 13001-970 Campinas SP - Brazil, Tel.: +55 19 3241.5793, Tel./Fax.: +55 19 3241.0527 - Campinas - SP - Brazil
E-mail: revista@sbcta.org.br