SciELO - Scientific Electronic Library Online

 
vol.19 issue1SIMULTANEOUS SCHEDULING AND OPERATIONAL OPTIMIZATION OF MULTIPRODUCT, CYCLIC CONTINUOUS PLANTSGROWTH AND ENZYME PRODUCTION DURING CONTINUOUS CULTURES OF A HIGH AMYLASE-PRODUCING VARIANT OF Aspergillus Oryzae author indexsubject indexarticles search
Home Pagealphabetic serial listing  

Services on Demand

Journal

Article

Indicators

Related links

Share


Brazilian Journal of Chemical Engineering

Print version ISSN 0104-6632On-line version ISSN 1678-4383

Braz. J. Chem. Eng. vol.19 no.1 São Paulo Jan./Mar. 2002

http://dx.doi.org/10.1590/S0104-66322002000100004 

a04v19n1

LIQUID-LIQUID EQUILIBRIA OF THE ACETIC ACID-WATER-MIXED SOLVENT (CYCLOHEXYL ACETATE-CYCLOHEXANOL) SYSTEM

 

S.Çehreli
Department of Chemical Engineering,
Istanbul University, 34850 Aveilar, Istanbul, Turkey.
E-mail : cehreli@istanbul.edu.tr 

 

(Received: May 10, 2001 ; Accepted: November 20, 2001)

 

 

Abstract - Mixtures of cyclohexyl acetate and cyclohexanol were used as a mixed solvent to study liquid-liquid equilibria (LLE) of the acetic acid-water-cyclohexanol-cyclohexyl acetate quaternary system. The solubility diagram and tie-line data were determined at 298±0.20 K and atmospheric pressure, using various compositions of mixed solvent. Reliability of the data was ascertained by making Othmer-Tobias and Hand plots.
Keywords:
liquid-liquid equilibria, mixed solvent, tie-line.

 

 

INTRODUCTION

Liquid extraction of acetic acid from aqueous solutions with various solvents has been reviewed by several researchers (Correa et al., 1989; Torul et al., 1992; Fahim et al., 1997; Aljimaz et al., 2000; Tamura et al., 2000). In addition, some advantages of high boiling separating agents have recently been reported (Ulusoy and Dramur, 1981; Tatli et al., 1987; Dramur and Tatli, 1993) and some quaternary systems have been investigated (Ruiz et al., 1985; Nagata, 1986 and 1993). In this research the mixtures of cyclohexanol and cyclohexyl acetate were used as mixed solvent in order to determine liquid-liquid equilibria (LLE) data for the water-acetic acid- cyclohexanol-cyclohexyl acetate quaternary system. LLE data for water-acetic acid-cyclohexyl acetate and water-acetic acid-cyclohexanol ternaries had been presented previously (Sayar et al.,1991:Tatli at al., 2000). It is seen that cyclohexanol has high distribution coefficient and low separation factor values, on the other hand cyclohexyl acetate shows lower distribution coefficient and higher separation factor values when the LLE data for water-acetic acid-cyclohexanol and water-acetic acid-cyclohexyl acetate ternary systems are compared. In this study our aim was to determine the LLE data of quaternary systems by using the mixture of this solvents in different composition and to show the trend of the distribution coefficients and separation factors for this quaternary systems. The mixed solvent of cyclohexanol and cyclohexyl acetate, which consists of completely miscible components, was prepared in three compositions (10%, 50% and 90%).

 

EXPERIMENTAL

Acetic acid (100 mass %), cyclohexanol (reagent grade,99 mass %) and cyclohexyl acetate (reagent grade,99 mass %) were furnished by Merck. The purity of the chemicals was checked on the basis of their refractive indexes and densities at 293±0.20 K and their boiling points at 760±2 mmHg. Refractive indexes were measured with an Abbé-Hilger refractometer; its stated accuracy is ±0.0001 nD. Densities were measured with a Westphal balance. Boiling point measurements were obtained by using a Fischer boiling point apparatus. The physical properties measured are listed in Table 1, along with (Weast, 1990) values from the literature.

 

 

Deionized water was further distilled before use.

Data for the solubility curve of the quaternary systems were determined by cloud point method. Solubility curve data determinations were made in an equilibrium cell equipped with a magnetic stirrer and an isothermal fluid jacket. The temperature of the mixture was regulated by a thermostated bath with an accuracy of ±0.2 K. The inner temperature of the cell was measured within an accuracy of ±0.1 K by a certified Fischer thermometer.

The cell, designed to contain a solution of 50-200 cm3, was filled with homogeneous water+acetic acid mixtures prepared by weighing. An electronic Sauter balance with an accuracy of ±0.1 mg was used. The mixed solvent was added by means of an automatic microburet with an accuracy of ±0.005 cm3 . The end point was determined by observing the transition from a homogeneous to a heterogeneous mixture. This pattern was convenient for providing the water-rich side of the curves. The data for the solvent-rich side of the curves were therefore obtained by titrating homogeneous acetic acid+mixed solvent with water until turbidity had appeared. Composition determinations were accurate to ±0.0005 weight fraction.

The mutual solubilities of water and mixed solvent were determined by applying a synthetic method. A weighed amount of a substance was introduced into the cell; the other was added until a permanent heterogeneity had been observed. An ultraaccurate titrator of ±0.001 cm3 was used.

The tie-line data determinations were obtained by using the equilibrium apparatus described above. Six different mixtures within the heterogeneous gap were prepared for the three study sets. The cell was filled with each of these mixtures and vigorously stirred for 1 h under isothermal conditions. After the stirrer was turned off, the contents were immediately introduced into the vertical settler, also equipped with an isothermal jacket. After the complete separation of the phases, a suitable amount of each layer was withdrawn for analysis. The acid contents of the samples were determined by volumetric titration with 0.1 N NaOH solutions to the ethanolic phenolphthalein end point. Several check determinations on known samples showed that the accuracy of the method was within ±0.001 of the weight fraction.

The mixed solvent was used in three compositions. Representation of the mixed solvent composition was characterized by a value of M which was defined as

where mCHA and mCHO were the amount of cyclohexyl acetate and cyclohexanol, respectively.

 

RESULTS AND DISCUSSION

The measured values for solubility curves and experimental mutual solubilities for the water-acetic acid-mixed solvent (cyclohexyl acetate-cyclohexanol) systems are reported in Table 2 (for M = 0.1, M = 0.5 and M = 0.9). The tie-line compositions for the water-acetic acid-mixed solvent systems are given in Table 3. The experimental tie-line compositions and solubility values of the systems for M = 0.1, M = 0.5 and M = 0.9 are plotted in Figures 1-3, respectively. The tetrahedral representation of the solubility surface of the quaternary system obtained from the experimental data is shown in Figure 4. The data for M = 1 and M = 0 are taken from the literature (Sayar et al., 1991; Tatlý et al., 2000).

 

 

 

 

 

 

 

 

 

 

 

 

Othmer-Tobias and Hand Correlations:

The reliability of experimentally measured tie-line data can be ascertained by applying Othmer-Tobias and Hand Equations (Othmer and Tobias, 1942; Brandani and Ross, 1985). The Othmer-Tobias and Hand Correlation equations are given as equations (2) and (3), respectively.

The correlations are shown in Figures 5 and 6. The correlation coefficients and correlation factor (R2) values were determined by the least-squares method and are given in Table 4. A correlation factor (R2) close to 1 suggests a high degree of consistency of the related data.

 

 

 

 

 

 

In Figure 7 selectivity diagrams on a solvent-free basis are plotted for M = 0.1, M = 0.5 and M = 0.9.

 

 

Distribution coefficients, Di, for acetic acid (i = 2) and water (i = 1) and separation factors, S, were determined as follows;

The results are listed in Table 5. These are expected results; distribution coefficients for M=0.1 (cyclohexyl acetate 10%,cyclohexanol 90%) are high and separation factor values are low like pure cyclohexanol, on the other hand for M=0.9 (cyclohexyl acetate 90%,cyclohexanol 10%) distributon coefficients are low and separation factors are high like pure cyclohexyl acetate. It can be concluded that by increasing the cyclohexyl acetate concentration in the mixture, the values of the distribution coefficients are decreased, but on the contrary the separation factor values increase. Another result is that the mixtures of cyclohexyl acetate and cyclohexanol may be used instead of these pure solvents.

 

 

NOMENCLATURE

a1, b1 Othmer-Tobias equation constant
a2, b2

 Hand equation constant

nD  refractive index
Di  distribution coefficient of the ith component
S separation factor
Wi

 weight fraction of the ith component

W11  weight fraction of water (1) in the aqueous phase
W21 weight fraction of acetic acid (2) in the aqueous phase
W31 weight fraction of mixed solvent (3) in the aqueous phase
W13 weight fraction of water (1) in the solvent phase
W23 weight fraction of acetic acid (2) in the solvent phase
W33  weight fraction of mixed solvent (3) in the solvent phase

 

REFERENCES

Aljimaz, A.S., Fandary, M.S.H., Alkandary, C.A. and Fahim, M.A., Liquid-Liquid Equilibria of the Ternary System Water+Acetic Acid +1-Heptanol. J.Chem.Eng.Data, 45(2), 301 (2000).        [ Links ]

Brandani, V. and Ross, M., Ternary Liquid-Liquid Equilibrium Data for the Water-Ethanol-Benzene System. J.Chem.Eng.Data, 30, 27 (1985).        [ Links ]

Correa, J.M., Blanco, A. and Arce, A., Liquid-Liquid Equilibria of the System Water+Acetic Acid+Methyl Isopropyl Ketone Between 25 and 55 oC. J.Chem.Eng.Data, 34, 415 (1989).        [ Links ]

Dramur, U. and Tatlý, B., Liquid-Liquid Equilibria of Water+Acetic Acid+Phthalic Esters (Dimethyl Phthalate and Diethyl Phthalate) Ternaries. J.Chem.Eng.Data, 38, 23 (1993).        [ Links ]

Fahim, M.A., Al-Muhtaseb, S.A. and Al-Nashef, I.M., Liquid-Liquid Equilibria of the Ternary System Water + Acetic Acid+1-Hexanol. J.Chem.Eng.Data, 42(1), 183 (1997).        [ Links ]

Nagata, I., Liquid-Liquid Equilibria of (Acetonitrile+Methyl Ethanoate+Cyclohexane) and of (Acetonitrile+Methyl Ethanoate+Benzene). Thermochimica Acta, 101, 205 (1986).        [ Links ]

Nagata, I., Quaternary Liquid-Liquid Equilibria for Two Systems Containing Acetonitrile, Two Alcohols and Cyclohexane. Thermochimica Acta, 214, 339 (1993).        [ Links ]

Othmer, D.F. and Tobias, P.E., Tie Line Correlation. Ind.Eng.Chem., 34, 693 (1942).        [ Links ]

Ruiz, F., Prats, D. and Gomis, V., Quaternary Liquid-Liquid Equilibrium: Water-Ethanol-Chloroform-Toluene at 25 0C. Experimental Determination and Graphical and Analytical Correlation of Equilibrium Data. J.Chem.Eng.Data, 30, 412 (1985).        [ Links ]

Sayar, A.A., Tatlý, B. and Dramur, U., Liquid-Liquid Equilibria of the Water+Acetic Acid+Cyclohexyl Acetate Ternary. J.Chem.Eng.Data, 36, 378 (1991).        [ Links ]

Tamura, K., Morishita, N. and Yamada, T., Ternary and Quaternary Liquid-Liquid Equilibria for the Water+Cyclohexane+Ethyl Acetate and Water+ Water+Cyclohexane+Ethyl Acetate+Acetic Acid Systems at the Temperature 298.15 K. J.Chem.Eng.Data, 45(4), 555 (2000).        [ Links ]

Tatlý, B., Dramur, U. and Ulusoy, E., Recovery of Acetic Acid from Vinegar with High Boiling Solvents. Chim. Acta Turc., 15, 57 (1987).        [ Links ]

Tatlý, B., Kýrbaþlar, Þ.Ý., Hasdemir, M. and Meriçli, F.T., Examination of Liquid-Liquid Equilibria of Water+Acetic Acid+Cyclohexanol Ternaries at 298, 303, 316 K. Journal of Engineering Science, 6(1), 65 (2000).        [ Links ]

Torul, O., Gültekin, N., Nohut, S. and Duran, C., Liquid-Liquid Equilibrium for the Systems Composed of Diethyl Phenylmalonate+Acetic Acid+Water and Diethyl Methylmalonate+Acetic Acid+Water at 294, 298 and 308 K. J.Chem.Eng.Data, 37, 474 (1992).        [ Links ]

Ulusoy, E. and Dramur, U., Die Untersuchung der Extraktiven Trennung der Essigsäure Von Wasser Mit Hochsiedenden Lösungsmitteln. Chim. Acta Turc., 9, 137 (1981).        [ Links ]

Weast, R.C., Handbook of Chemistry and Physics. CRC Press, Boca Raton, Florida (1989-1990).        [ Links ]

Creative Commons License All the contents of this journal, except where otherwise noted, is licensed under a Creative Commons Attribution License