Acessibilidade / Reportar erro

Correlation between antioxidant activity and coffee beverage quality by Electron Spin Resonance Spectroscopic

Correlação entre a atividade antioxidante e qualidade de bebida de café por Espectroscopia de Ressonância de Spin Eletrônico

Abstracts

Brazil is the largest producer of coffee in the world and coffee prices are directly linked to grain quality. In this work, the antioxidant activity of coffee was related to its quality through Electron Spin Resonance Spectroscopy (ESR), as an attempt to establish a non-subjective method to classify the grain quality. For that purpose, the IC50 and temporal monitoring of its non-oxidized fraction were determined for three bean qualities: Soft (High), Hard (Medium) and Rio (Low). Methanolic solution of 2,2-difenil-1-picril-hidrazila (DPPH), that has a stable radical and a JEOL FA-200 (X-Band) spectrometer were used for these tests. The temporal monitoring of reaction between radical and coffee was performed. The rate of reduced or of antioxidated radicals was determined on time and for each coffee beverage quality were found different slopes of curve: Soft (0.32±0.02), Hard (0.47±0.02) and Rio (0.60±0.02). The IC50 result of Rio quality (2.7 ± 0.9) was different from the Soft (7.8 ± 1.9) and Hard (6.5 ± 1.5) values, but there was no difference between the High and Medium results due to the uncertainty associated. Therefore the results found, mainly for monitoring temporal, establish a new quantitative methodology for classifying the coffee beverage quality.

Classify; method; IC50


O Brasil é o maior produtor mundial de café e os preços dessa mercadoria são diretamente influenciados pela qualidade dos grãos. A atividade antioxidante do café foi relacionada com a sua qualidade de bebida através de Espectroscopia de Ressonância de spin eletrônico (ESR), como uma tentativa de estabelecer um método não subjetivo para classificar a qualidade do grão. O teste IC50 e o monitoramento temporal da fração do radical DPPH não reduzida pelas três qualidades de bebida Mole (Alta), Dura (Média) e Rio (Baixa) foram determinados. Uma solução metanólica de 2,2-difenil-1-picril-hidrazila (DPPH), que tem um radical estável e um espectrômetro JEOL FA-200 (banda-X) foram utilizados para os ensaios. O monitoramento temporal da reação entre o radical e o café foi registrado por espectros de ESR. A taxa de radicais reduzidos ou antioxidados foi determinada no tempo e para cada qualidade da bebida do café foram encontrados diferentes inclinações da curva: Mole (0,32 ± 0,02), Dura (0,47 ± 0,02) e Rio (0,60 ± 0,02). O resultado de IC50 de qualidade Baixa (2,7 ± 0,9) foi diferente dos valores de Mole (7,8 ± 1,9) e Dura (6,5 ± 1,5), mas não existiu nenhuma diferença entre os resultados de Mole e Dura, em razão da incerteza associada. Portanto, os resultados encontrados, principalmente para o monitoramento temporal, estabelecem uma nova metodologia quantitativa para classificar a qualidade de bebida dos grãos de café.

Classificação; método; IC50


AGRICULTURAL SCIENCES

Jeam Haroldo Oliveira BarbosaI; Jorge Antonio Gómez LunaII; Angela Mitie Otta KinoshitaIII; Oswaldo Baffa FilhoII

IUniversidade de São Paulo/USP - FFCLRP - Departamento de Física - Avenida Bandeirantes - 3900 - Monte Alegre - 14040-901 - Ribeirão Preto - SP -Brasil - jeamharoldo@hotmail.com

IIUniversidade de São Paulo/USP - FFCLRP - Departamento de Física - Avenida Bandeirantes - 3900 - Monte Alegre - 14040-901 - Ribeirão Preto - SP - Brasil

IIIUniversidade do Sagrado Coração/USC - Bauru - SP - Brasil

ABSTRACT

Brazil is the largest producer of coffee in the world and coffee prices are directly linked to grain quality. In this work, the antioxidant activity of coffee was related to its quality through Electron Spin Resonance Spectroscopy (ESR), as an attempt to establish a non-subjective method to classify the grain quality. For that purpose, the IC50 and temporal monitoring of its non-oxidized fraction were determined for three bean qualities: Soft (High), Hard (Medium) and Rio (Low). Methanolic solution of 2,2-difenil-1-picril-hidrazila (DPPH), that has a stable radical and a JEOL FA-200 (X-Band) spectrometer were used for these tests. The temporal monitoring of reaction between radical and coffee was performed. The rate of reduced or of antioxidated radicals was determined on time and for each coffee beverage quality were found different slopes of curve: Soft (0.32±0.02), Hard (0.47±0.02) and Rio (0.60±0.02). The IC50 result of Rio quality (2.7 ± 0.9) was different from the Soft (7.8 ± 1.9) and Hard (6.5 ± 1.5) values, but there was no difference between the High and Medium results due to the uncertainty associated. Therefore the results found, mainly for monitoring temporal, establish a new quantitative methodology for classifying the coffee beverage quality.

Index terms: Classify, method, IC50.

RESUMO

O Brasil é o maior produtor mundial de café e os preços dessa mercadoria são diretamente influenciados pela qualidade dos grãos. A atividade antioxidante do café foi relacionada com a sua qualidade de bebida através de Espectroscopia de Ressonância de spin eletrônico (ESR), como uma tentativa de estabelecer um método não subjetivo para classificar a qualidade do grão. O teste IC50 e o monitoramento temporal da fração do radical DPPH não reduzida pelas três qualidades de bebida Mole (Alta), Dura (Média) e Rio (Baixa) foram determinados. Uma solução metanólica de 2,2-difenil-1-picril-hidrazila (DPPH), que tem um radical estável e um espectrômetro JEOL FA-200 (banda-X) foram utilizados para os ensaios. O monitoramento temporal da reação entre o radical e o café foi registrado por espectros de ESR. A taxa de radicais reduzidos ou antioxidados foi determinada no tempo e para cada qualidade da bebida do café foram encontrados diferentes inclinações da curva: Mole (0,32 ± 0,02), Dura (0,47 ± 0,02) e Rio (0,60 ± 0,02). O resultado de IC50 de qualidade Baixa (2,7 ± 0,9) foi diferente dos valores de Mole (7,8 ± 1,9) e Dura (6,5 ± 1,5), mas não existiu nenhuma diferença entre os resultados de Mole e Dura, em razão da incerteza associada. Portanto, os resultados encontrados, principalmente para o monitoramento temporal, estabelecem uma nova metodologia quantitativa para classificar a qualidade de bebida dos grãos de café.

Termos para indexação: Classificação, método, IC50.

INTRODUCTION

Coffee has a huge economic importance to Brazil and other producer countries, since it is the second largest item of trade in the international market, with Brazil being the largest producer (NACIF, 2003). Therefore, the search for new technologies that can improve the selection of this product is of great economic value.

Currently in the Brazil, the coffee quality is assessed, among other analyzes (sieving, defects, color), by classification of the beverage based on the sensorial- analysis standardized by the Brazilian Secretary of Agriculture (Ministério da Agricultura, Pecuária e Abastecimento) (BRASIL, 2003). The test consists of pouring boiling water (150mL) over roasted and ground coffee (10g, specific roast and fine grind). After few minutes, the mixture classification is made by performing a sensory evaluation with determination of the combination of smell and flavor (FARAH et al., 2006). In general, the coffee quality is classified, from best to worst, as Soft, Hard and Rio. This characteristic is the result of growth, maturation, harvesting and the post- harvesting processing (BORÉM, 2008). It should be noted that the characteristics and intensities of taste sensations, as well as flavors and aromas predominating in the drink, are analyzed by a certified technician. Obviously this is a qualitative process and therefore is a subjective classification of quality.

The coffee has several volatile compounds, these make the quantitative classification of coffee quality difficult, because some beans from a specific species or from some regions can have more types of compounds than others, and the sorter can be confused (MARIA; MOREIRA; TRUGO, 1999; MOREIRA; TRUGO; MARIA, 2000).

In the literature, physical techniques have been used for 10 years to study different properties of coffee, such as: quantification of caffeine in coffee beverage via UV-Vis spectrometry (BELAYA et al., 2008); conservation states of caffeinated samples via UV-Vis spectrometry (SOUTO et al., 2010), evaluation of green coffee bean quality using near infrared spectroscopy (SANTOS et al., 2012); authenticity of Instant Coffee via proton nuclear magnetic resonance spectroscopy (CHARLTON; FARRINGTON; BRERETON, 2002); differentiation of Arabica and Robusta varieties of coffee with the electronic Aroma-sensing Device (FREITAS; PARREIRA; VILAS-BOAS, 2001); differentiation of coffee flavor via electronic tongue (RIUL et al., 2003). But none of these related the coffee beverage quality with parameters measured by these physical techniques.

Some chemical attributes of Brazilian coffee have been reported relating the bean quality classification to the sensorial analysis. Carvalho et al. (1994) found correlation between the coffee beverage quality with polyphenoloxidase enzyme activity. They suggested that could complement the sensorial test (CARVALHO et al., 1994). However, Mazzafera, Gonçalves and Shimizu (2002) more recently showed that this technique need to be reevaluated because they found relationship between extraction method and dosage of the enzyme (MAZZAFERA; GONÇALVES; SHIMIZU, 2002). Farah et al. (2006) observed that trigonelline and 3,4-dicaffeoylquinic acid in green and roasted coffee are present in high quality beans, while the caffeoylquinic acids (predominantly 5-caffeoyilquinic acid), feruloylquinic acids, and their oxidation products are present in poor cup quality (FARAH et al., 2006). However, the authors did not applied this methodology to classify the several qualities of coffee.

Abrahão et al. (2010) have attempted to sort the beverage quality by means of the relationship with its own characteristics: bioactive compounds and antioxidant activity (ABRAHÃO et al., 2010). However, these authors could not find significant difference between these properties and the quality classification. The possible reason can rely on the fact that the antioxidant activity of coffee is very dependent on roasting due to the Maillard reaction (BEKEDAM et al., 2008; MORAIS et al., 2009; BREZOVÁ; SLEBODOVÁ, 2009). Therefore, if the roasting is excessive, it is impossible to differentiate the beverage quality by antioxidant activity.

A previous study of our group differentiated the quality of the coffee beverage using the Electron Spin Resonance (ESR) spectroscopy technique (IKEYA; BAFFA; MASCARENHAS, 1989). High doses of ionizing radiation were applied in different quality beans to create free radicals. These radicals were measured by ESR and a relationship between the amount of free radicals and quality was established. However, the use of ionizing radiation makes this methodology difficult to use in everyday practice.

In this work, we propose a simple method to differentiate the beverage quality through ESR spectroscopy without using ionizing radiation. The methodology is based on the association between antioxidant activity and quality of coffee beverage.

MATERIAL AND METHODS

Samples

Samples of green coffee (Coffea Arabica L.) from the 2010/11 crop season in southern Minas Gerais were provided by SAAG (Sociedade de Armazenamento e Agricultura) at the request of Dr. Flavio Meira Borém of the University of Lavras (UFLA).

Sample preparation

Three samples of different qualities were studied: Rio (low quality), Hard (medium quality) and Soft (high quality). All samples were selected by the Brazilian official classification method for the coffee beverage according to normative instructions from the Brazilian Ministry of Agriculture, Livestock and Food Supply (BRASIL, 2003). To control the moisture content, samples were dried in an oven for 24 hours at a temperature of 35 °C. Subsequently the samples were roasted for 12 minutes (200 °C ± 3 °C) in a muffle furnace preheated for 1 hour. Finally, samples were ground in an electric grinder. A roasting time was selected to produce a light brown color as published in Morais et al. (2009).

To study the antioxidant activity, the free radical 2,2-diphenyl-1-picryl-hidrazil (DPPH) (Sigma-Aldrich) dissolved in methanol at a concentration of 100 µM was used. A methanol solution of DPPH was chosen from a study of the temporal stability of the ESR signal of these solutions at different concentrations. Figures 2 and 3 show the temporal stability of the ESR signal of methanolic DPPH.




Studied solution

For the preparation of a bulk coffee solution (Rio, Hard, Soft Coffees), we used 50mg of ground coffee (already roasted) in 100 mL of Mili-Q water at 90 °C. Twenty minutes after this preparation, a dilution of this main solution at various concentrations: 50, 25, 10, 8, 6, 5, 4, 3, 2 and 1mg/mL was conducted.

In parallel, we prepared a methanol solution of 100 µM of DPPH and Mili-Q water at room temperature. Thus, the studied solutions comprised of a mixture, at room temperature, of 25 µL of the coffee solution (diluted at different concentrations) plus 975mL of DPPH methanol solution.

Temporal monitoring of antioxidant activity

The temporal monitoring of the reaction between the radical (975 µL methanolic solution of DPPH) and coffee (25 µL coffee beverage at a 6 mg/ml) was performed by recording the ESR spectrum every 3 minutes after reaction, until 45 minutes. The relative concentration over time (Crel(t)) was defined as the ratio of the double integral of ESR spectrum value over time (DIESR(t)) and the double integral of DPPH solution reacted with water (DIESR(DPPH)):

The rate of antioxidated radicals was determined plotting 1-(C

rel(t)) as function of time. This quantity measures the reduction of DPPH as a function of time in comparison to the initial dilution and reduction that would happen in pure water.

IC-50 test

This test consisted of recording the ESR spectra of the coffee solutions (25 µL) at different concentrations mixed with 975 µL of DPPH methanol solution. The recording of these spectra was carried out at room temperature and after 2 minutes of mixing with the methanolic solution. This procedure was performed in triplicate for each coffee quality. The IC-50 value was calculated from the values of Crel (t=2 min) as a function of each concentration. Thus, using an approximation of these exponential curves, the value of the concentration of coffee required to reduce 50% of free radicals present in the solution was obtained.

ESR measurements

To assess the relative content of the radicals, all solutions were transferred to a capillary glass tube, which was sealed and placed inside a standard ESR quartz tube (inner diameter 3.00mm). ESR spectra was recorded in an X-Band (Jeol JES-FA-200) with a central magnetic field of 339mT, scanning field of 7mT, scan time of 2 minutes, modulation amplitude of 0.1mT, modulation frequency of 100kHz and microwave power of 1m W.

RESULTS AND DISCUSSION

The solution of the 100 µM DPPH in methanol showed a constant ESR signal in the time span of the experiments (60 minutes) (Figure 1), a small variation of only 7% was noticed (Figures 2).

The ESR signal amplitude increased inversely with the beverage quality (Figure 3) after 50 minutes of reaction between DPPH and all the different coffee quality beverages. The coffee beverages classified as Rio was more antioxidant than Hard and Soft ratings.

The plot of the rate of radical reduction (1-Crel) over time for each beverage allowed to better differentiate the coffee quality (Figure 4).


The values of the slope from linear regression of plots in figure 4 are in table 1 that represents the rate of radical reduction per minute.

The inverse relation between the linear regression slope values (Table 1) and the coffee quality was expected, because we selected a specific burn degree to roast the coffee grains, hence this weighted the antioxidant activity differently for each quality beverage. Furthermore, we observed that the roasted Rio quality beans showed a slightly less dark color than the other coffee qualities after roasting. Farah et al. (2006) (FARAH et al., 2006) also observed in the process of roast that color intensity of coffee samples increased significantly with quality, but the authors did not suggested the cause for the behavior of roasted coffee.

Figure 5 shows results at IC-50 test for different beverage qualities. The IC-50 test was able to differentiate the quality of the Rio beverage from the Hard and Soft, but it was not possible to distinguish a Hard from Soft beverage by this test.


The results of this work showed that all coffee beverage qualities have an antioxidant behavior against a DPPH radical, in accordance with Abrahão et al. (2010) (ABRAHÃO et al., 2010) and Yanagimoto et al. (2004) (YANAGIMOTO et al., 2004).

As already mentioned, Abrahã, Pereira and Duarte (2010) did not found relationship between antioxidant activity and quality. In this work we established this relation through temporal monitoring and IC-50 test and we found that antioxidant character varies according to quality beverage coffee. As showed in table 1, the slope of curves are different for each bean quality, the beverage Rio has the highest rate of antioxidant radicals per minute: 0.6/min. Through IC-50 results it was possible the differentiation only the poor quality (Rio) from the others. So, the time monitoring method was more efficient to sort the beverage coffee quality.

Therefore, the time monitoring method can be used to assist or substitute the quality sorter in the marketing process. However, this method needs standardization and to undergo more validations, for example, by official regulatory.

The method proposed in this work to differentiate the beverage quality was efficient, but some limitations there were: the samples obtained were from a specific region; chemical attributes from coffee were not studied. These conditions have to be taken into account when the results are compared with others.

CONCLUSIONS

The IC50 test showed that Low quality (Rio) is different from the High and Medium qualities, but there is no difference between the High and Medium results due to the uncertainty associated. On the other hand, the temporal monitoring of the reaction showed a significant different for each bean quality. Therefore, the temporal monitoring results presented a higher specificity than IC-50 and efficient classification the coffee beverage quality. A possible application for this method is in assisting the coffee beverage quality sorter, but it is necessary to consider ways and techniques to perform in a standardized manner.

ACKNOWLEDGEMENTS

This work was supported by CNPq, Conselho Nacional de Desenvolvimento Científico e Tecnológico -Brasil. Fundação de Amparo a Pesquisa de São Paulo (FAPESP) and University of São Paulo (USP) for financial support. Also technical support from Sociedade de Armazenamento e Agricultura (SAAG), Prof. Dr. Flavio Meira Borem, Evandro Galvão Tavares Menezes, Lourenço Rocha e Carlos Alberto Brunello.

Received in september 26, 2013

Approved in october 31, 2013

  • ABRAHÃO, S. A. et al. Compostos bioativos e atividade antioxidante do café (Coffea arabica L.). Ciência e Agrotecnologia, Lavras, v. 34, n. 2, p. 414-420, 2010.
  • BEKEDAM, E. K. et al. Electron spin resonance (ESR) studies on the formation of roasting-induced antioxidative structures in coffee brews at different degrees of roast. Journal of agricultural and food chemistry, Washington, v. 56, n. 12, p. 4597-604, 2008.
  • BELAYA, A. et al. Measurement of caffeine in coffee beans with UV/vis spectrometer. Food Chemistry, Barking, v. 108, n. 1, p. 310-315, 2008.
  • BORÉM, F. M. Pós-colheita do café. Lavras:Editora UFLA, p. 631, 2008.
  • BRASIL. Ministério da Agricultura, Pecuária e Abastecimento. Instrução Normativa n. 8, de 11 de junho de 2003. Aprova o regulamento técnico da identidade e de qualidade para a classificação de café beneficiado grão cru. Brasília, p. 10, 2003. Disponível em: <http://www.ministerio.gov.br>. Acesso em: 20 jan. 20013.
  • BREZOVÁ, V.; ŠLEBODOVÁ, A.; STAŠKO, A. Coffee as a source of antioxidants: An EPR study. Food Chemistry, Barking, v. 114, n. 3, p. 859-868, 2009.
  • CARVALHO, V. D. et al. Relação entre a composição físico-química e química do grão beneficiado e a qualidade de bebida do café. Pesquisa Agropecuária Brasileira, Brasília, v. 3, p. 449-454, 1994.
  • CHARLTON, A. J.; FARRINGTON, W. H. H.; BRERETON, P. Application of 1 H NMR and Multivariate Statistics for Screening Complex Mixtures: Quality Control and Authenticity of Instant Coffee. Journal of agricultural and food chemistry, Washington, v. 50, p. 3098-3103, 2002.
  • FARAH, A. et al. Correlation between cup quality and chemical attributes of Brazilian coffee. Food Chemistry, Barking, v. 98, n. 2, p. 373-380, 2006.
  • FREITAS, A. M. C.; PARREIRA, C.; VILAS-BOAS, L. The Use of an Electronic Aroma-sensing Device to Assess Coffee DifferentiationcComparison with SPME Gas Chromatography Mass Spectrometry Aroma Patterns. Journal of Food Composition and Analysis, San Diego, v. 14, p. 513-522, 2001.
  • IKEYA, M.; BAFFA, F. O.; MASCARENHAS, S. Quality assessment of coffee beans with ESR and gamma-ray irradiation. International journal of radiation applications and instrumentation. Part A, Applied radiation and isotopes, Oxford, v. 40, n. 10-12, p. 1219-22, 1989.
  • MARIA, C. A. B. DE; MOREIRA, R. F. A.; TRUGO, L. C. Componentes voláteis do café torrado. Parte I: compostos heterocíclicos. Quimica Nova, São Paulo, v. 22, n. 2, p. 209-217, 1999.
  • MAZZAFERA, P.; GONÇALVES, K. V; SHIMIZU, M. M. Extração e dosagem da atividade da polifenoloxidase do café. Scientia Agricola, Piracicaba, v. 59, n. 4, p. 695-700, 2002.
  • MORAIS, S. A. L. et al. Compostos bioativos e atividade antioxidante do café conilon submetido a diferentes graus de torra. Química Nova, São Paulo, v. 32, n. 2, p. 327-331, 2009.
  • MOREIRA, R. F. A.; TRUGO, L. C.; MARIA, C. A. B. Componentes voláteis do café torrado. Parte II. Compostos alifáticos, alicíclicos e aromáticos. Quimica Nova, São Paulo, v. 23, n. 2, p. 195-203, 2000.
  • NACIF, A. P. O café e a saúde humana. EMBRAPA Café. (Folheto). Brasília, p. 64, 2003.
  • RIUL, J. A. et al. An electronic tongue using polypyrrole and polyaniline. Synthetic Metals, Lausanne, v. 132, p. 109-116, 2003.
  • SANTOS, J. R. et al. Evaluation of green coffee beans quality using near infrared spectroscopy: A quantitative approach. Food Chemistry, Barking, v. 135, p. 1828-1835, 2012.
  • SOUTO, U. T. C. P. et al. UV-Vis spectrometric classification of coffees by SPA-LDA. Food Chemistry, Barking, v. 119, p. 368-371, 2010.
  • YANAGIMOTO, K. et al. Antioxidative activities of fractions obtained from brewed coffee. Journal of agricultural and food chemistry, Washington, v. 52, n. 3, p. 592-6, 2004.
  • Correlation between antioxidant activity and coffee beverage quality by Electron Spin Resonance Spectroscopic

    Correlação entre a atividade antioxidante e qualidade de bebida de café por Espectroscopia de Ressonância de Spin Eletrônico
  • Publication Dates

    • Publication in this collection
      23 Jan 2014
    • Date of issue
      Dec 2013

    History

    • Received
      26 Sept 2013
    • Accepted
      31 Oct 2013
    Editora da Universidade Federal de Lavras Editora da UFLA, Caixa Postal 3037 - 37200-900 - Lavras - MG - Brasil, Telefone: 35 3829-1115 - Lavras - MG - Brazil
    E-mail: revista.ca.editora@ufla.br