Acessibilidade / Reportar erro

Chlorophyll stability in yerba maté leaves in controlled atmospheres

Abstracts

The objective of this research was to investigate the stability of chlorophyll in yerba maté leaves in controlled atmospheres of CO2/air mixtures and different water activities at 25°C.Two levels of water activity were selected corresponding to saturated salt solutions of LiCl (a w=0.113) and MgCl2(a w=0.330) and three levels of CO2/air mixtures (0/100,20/80 and 40/60). The chlorophyll content was evaluated using a liquid chromatography HPLC technique. Experimental values varied between 2.16 and 0.61 mg/g of dry matter. For each sample, 5 determination were made during 58 days. Experimental values were fitted to an equation describing a first order reaction. In all cases, the agreement was good with P<3 10-3. The initial concentration of chlorophyll dropped, in average, to 30.5% after 58 days. However, after comparing the velocity constants, no differences were found between them.

yerba maté; chlorophyll stability; controlled atmosphere


O objetivo deste trabalho foi pesquisar a estabilidade da clorofila em folhas de erva mate em misturas atmosféricas controladas de CO2/ar e diferentes atividades de vapor de água a 25ºC. Dois níveis de atividade de vapor de água foram selecionadas, correspondendo a soluçoes saturadas de LiCl (a w=0.113) e MgCl2 (a w=0.330) e três níveis de misturas CO2/ar (0/100,20/80 e 40/60). O conteúdo de clorofila foi avaliado usando a técnica de cromatografia líqüida HPLC. Os valores experimentais variaram entre 2.16 e 0.61 mg/g de matéria seca. Para cada amostra foram realizadas 5 determinaçoes durante 58 dias. Os valores experimentais foram ajustados para uma eqüação descrevendo uma reação de primeiro ordem. Em todos os casos houve boa concordância P < 3 10-3. A concentração inicial de clorofila ficou reduzida em média um 30.5% depois de 58 dias. Porém, depois da comparação das constantes de velocidade, não foram achadas diferenças entre elas.


Chlorophyll stability in yerba maté leaves in controlled atmospheres

Rubén O. Morawicki; Miguel E. Schmalko* * Author for correspondence ; Rodolfo G. Känzig

Centro de Investigación y Desarrollo Tecnológico(CIDeT)-Facultad de Ciencias Exactas, Químicas y Naturales-Universidad Nacional de Misiones -Felix de Azara 1552, 3300 Posadas, Misiones, Argentina

ABSTRACT

The objective of this research was to investigate the stability of chlorophyll in yerba maté leaves in controlled atmospheres of CO2/air mixtures and different water activities at 25°C.Two levels of water activity were selected corresponding to saturated salt solutions of LiCl (aw=0.113) and MgCl2(aw=0.330) and three levels of CO2/air mixtures (0/100,20/80 and 40/60). The chlorophyll content was evaluated using a liquid chromatography HPLC technique. Experimental values varied between 2.16 and 0.61 mg/g of dry matter. For each sample, 5 determination were made during 58 days. Experimental values were fitted to an equation describing a first order reaction. In all cases, the agreement was good with P<3 10-3. The initial concentration of chlorophyll dropped, in average, to 30.5% after 58 days. However, after comparing the velocity constants, no differences were found between them.

Key words: yerba maté, chlorophyll stability, controlled atmosphere

RESUMO

O objetivo deste trabalho foi pesquisar a estabilidade da clorofila em folhas de erva mate em misturas atmosféricas controladas de CO2/ar e diferentes atividades de vapor de água a 25ºC. Dois níveis de atividade de vapor de água foram selecionadas, correspondendo a soluçoes saturadas de LiCl (aw=0.113) e MgCl2 (aw=0.330) e três níveis de misturas CO2/ar (0/100,20/80 e 40/60). O conteúdo de clorofila foi avaliado usando a técnica de cromatografia líqüida HPLC. Os valores experimentais variaram entre 2.16 e 0.61 mg/g de matéria seca. Para cada amostra foram realizadas 5 determinaçoes durante 58 dias. Os valores experimentais foram ajustados para uma eqüação descrevendo uma reação de primeiro ordem. Em todos os casos houve boa concordância P < 3 10-3. A concentração inicial de clorofila ficou reduzida em média um 30.5% depois de 58 dias. Porém, depois da comparação das constantes de velocidade, não foram achadas diferenças entre elas.

INTRODUCTION

When selecting yerba maté (Ilex paraguarensis St. Hil.), consumers judge color as one parameter of quality. Brazil and Argentina, as main yerba maté consumers, have different preferences for color. Argentinean consumers generally life a light olive green color, while Brazilians prefer a bright green one.

Yerba maté green color is due to chlorophyll presence. Its intensity has a direct relationship with the chlorophyll concentration. During processing, every stage is responsible for decreasing the level of chlorophyll.

In general, the yerba maté processing has four stages: heat treatment, drying, grinding, and seasoning. During the seasoning, yerba maté loses a high percentage of chlorophyll. Therefore, when the product is processed for the Brazilian market, the last stage is avoided.

Yerba maté packages for Brazilian market, containing between 5 and 8% of moisture (dry basis), are kept only three months on the supermarket shelves for selling. After that, packages are removed because the green color becomes lighter. Consequently, finding a method to preserve the green color in yerba maté is an issue of great importance for this market. Temperature, water activity (aw), and inert gases are the main factors that influence chlorophyll degradation.

Temperature: Temperature influence in chlorophyll degradation was widely studied for different products. Researches were conducted by Lajollo et al. (1971) in spinach, Watada et al. (1987) in beans, spinach and pepper, Canjura et al. (1991) in spinach puree, and Steet and Tong (1996) in peas. They have shown that the chlorophyll degradation kinetics follows a pseudo-first order process. They also found that temperature behavior can be described by using the Arrhenius equation. Gomez Vara et al. (1979) studied chlorophyll stability in yerba maté at 60 and 80°C and Montiel and Avanza (1996) at 6, 30 and 50°C. All researchers reported a strong influence of the temperature on degradation rate. Gomez Vara et al. (1979) found that at 60°C, the initial concentration dropped to 25% in 11 days. Montiel and Avanza (1996) concluded that at 30°C chlorophyll content decreased to 60% from the initial concentration in 40 days.

Although temperature influences chlorophyll degradation, it is not economically feasible to control this factor. In addition, this would produce a change in the traditional commercialization approach.

Water activity (aw): Lajollo et al. (1971) have studied how water activity and inert gases affect the chlorophyll degradation in spinach. They found that water activity starting from 0.52 begins to influence heavily the degradation process. Lower values of water activity produce less important effects. These authors concluded that by an aw less than 0.52, in 120 days and a temperature of 37°C the chlorophyll concentration dropped only to a 70% of the initial content. However, in yerba maté the chlorophyll undergoes higher degradation. This was shown by Gomez Vara et al. (1979) who reported that for yerba maté naturally seasoned for less water activity and temperature (room humidity and temperature conditions) chlorophyll concentration was reduced to 50% of the initial value in 120 days.

Other researches were conducted for high values of aw in fruits and fresh vegetables. Watada et al. (1987) studied the chlorophyll degradation of peas, pepper and spinach at 10 and 20° C, by packaging them in polyethylene bags and without packaging them. They found that without packaging, spinach lost more chlorophyll than the packaged one. However, the other two vegetables have not followed the same behavior.

Controlled atmospheres: Baarsdseth and Von Elbe (1989) studied the chlorophyll degradation in fresh spinach by using two atmospheres, one of pure air and the other a mixture of ethylene and air, during 5 days. They reported no difference between both atmospheres. Bastrash et al. (1993), using different mixtures of CO2 and O2 at 4°C, found that fresh broccoli retained more chlorophyll in a controlled atmosphere of 6% of CO2, and 2 % of O2 than for other combinations of both gases or the control—composed of 20% of O2. These authors also reported an increase in chlorophyll concentration of packaged broccoli in atmospheres of CO2/O2 at 5°C after 144 hours. The control sample, air exposed, underwent a decrease in chlorophyll concentration of 60% from the initial content.

Working with an atmosphere rich in N2, Lajollo et al. (1971) studied the influence of this inert gas on chlorophyll degradation velocity in spinach. At low aw (0.11 and < 0.01) and 55° C, they found that chlorophyll maintained a 56.2 and 58.8%, respectively of the initial value in 51 days. These values were higher than those found for yerba maté.

The objective of this research was to investigate the stability of chlorophyll in yerba maté leaves in controlled atmosphere of CO2/air mixtures (0/100,20/80 and 40/60) and aw (0.113 and 0.330) at 25°C.

MATERIALS AND METHODS

Yerba maté samples for Brazilian market were obtained from a local producer. Leaves were separated from twigs and ground until the particles passed a mesh number 80.

Moisture content determination

The moisture content was determined by heating the samples in an oven at 105° C during 6 h (IRAM 20503).

Chlorophyll content analysis

The chlorophyll content was evaluated using liquid chromatography HPLC technique (Schwartz and Lorenzo, 1991). Ten ml of an acetone-water solution (80:20 in volume) was added to 1 g of the sample, and then introduced in an ultrasonic bath at 25°C for 5 min. Afterwards, a 3-ml solution was taken with a syringe, and filtered using a syringe filter with a pore size of 0.22 µm. The filtered solution was then injected into the chromatograph (Shimadzu LC6A, integrator CR3A, and detector Linear Uvis 200 with column C18, 5 Micron L 250mm x 4.6 mm). Assay conditions were: Mobile phase, ethyl acetate: methanol: water (55: 35: 10 in volume), Flow: 2 ml/min and detector: UV-Vis at 435 nm, 0.01 AUFS.

Experimental Method

Experiments were carried out by introducing the samples in modified atmospheres at three levels of CO2 (0, 20 and 40%), and two levels of water activity (0.113 and 0.330).

The water activity was controlled using saturated solutions of LiCl (aw=0.113), and MgCl2 (aw=0.330). The CO2 level was maintained by injecting periodically mixtures of CO2-air. Table 1 shows the combinations of the different levels of CO2 concentration and water activity.

Samples were introduced in special containers, which had a grille to reserve a space in the bottom to locate the saturated solutions. The containers also had an orifice to allow the injection of the CO2-air mixtures. The CO2-air mixtures were obtained by mixing previously measured flows of CO2 and air, in a mix chamber. The mixes were introduced into the containers by using a tube, whose diameter was the half of the container's orifice in order to remove the initial air. The amount injected was six times the container's volume.

The samples, previously prepared, were placed over the grille. Analysis of chlorophyll was made initially and then every 15 days. The containers were maintained at 25° C during the whole experience.

Statistical Analysis

The chlorophyll degradation was fitted to an equation describing a first order reaction:

Where,

C= Chlorophyll concentration at time t [mg/g]

C0= Initial chlorophyll concentration [mg/g]

k= constant of velocity reaction [days-1]

t= time [days]

RESULTS AND DISCUSSION

Moisture Content

After each sampling, the moisture content was determined, in duplicate, for each sample. For samples 1, 2, and 3, the moisture content varied between 4.67 and 4.82. For samples 4, 5 and 6, it varied between 7.29 and 8.13. The moisture content is expressed % dry basis.

Chlorophyll Content

Table 2 shows the total chlorophyll content (A + B) as a function of time. Experimental results were fitted to Equation 1 using linear regression. In all cases the fitting was significant with P<3.10-3 and 3.10-5. Figure 1 presents the predicted and experimental relationship between chlorophyll concentration (expressed as ln(C/C0)) and time for sample 1.


In Figure 2, the expected curves for all trials are plotted. In addition, Table 3 presents the specific velocity reaction (day-1) and the confidence limits at 95%.


From Table 3, no significant difference among the constants of specific velocity reaction were observed, since the confident limits at 95% overlapped.

It was seen that the chlorophyll content after 58 days dropped to 30.5% with respect to the initial concentration, which was lower than that one found by Gomez Vara et al. (1979) (although they did not control temperature). Montiel and Avanza (1996) reported 60% chlorophyll content after 40 days at 30° C (the moisture content was not specified). The specific velocity constants obtained by the present research were higher than those reported by these authors.

CONCLUSIONS

Studies of chlorophyll degradation in yerba maté under controlled atmospheres were carried our by controlling CO2 level and water activity.

The relative amounts of CO2/air used in the experiment were 40/60, 20/80 and 0/100. The water activity was adjusted at 0.113 and 0.330.

The chlorophyll concentrations were fitted to an equation describing a first order reaction. In all cases the fitting was significant with P<3.10-3 and 3.10-5. The initial concentration of chlorophyll dropped, in average, to 30.5% after 58 days. However, after comparing statistically the velocity constants, significant differences among them were not found. Therefore, we conclude that the chlorophyll's degradation velocity is not affected by the relations of CO2/air and water activity at the tested levels.

Received: September 02, 1998

Revised: September 04, 1998

Accepted: November 16, 1998

  • Baardseth, P. and Von Elbe, J.H. Effect of Ethylene, Free Fatty Acid, and Some Enzyme Systems on Chlorophyll Degradation, J. Fd Sci 54: 1361-1363, 1989.
  • Bastrash, S.; Makhlouf, J.; Castaigne, F. and Willemot, C. Optimal Controlled Atmosphere Conditions for Storage of Broccoli Florets. J. Fd. Sci 58: 338-341, 1993.
  • Canjura, F. L.; Schwartz, S.J. and Nunes, R. V. Degradation kinetics of Chlorophylls and Chlorophyllides, J. Fd. Sci 56:1639-1643, 1991.
  • Gomez Vara, M.E.; Brieux, J.A. y Avanza, J.R. Investigaciones sobre yerba maté Apryma, 1979.
  • IRAM. Instituto de Racionalización de Materiales de Argentina Norma 20503.
  • Lajollo, F. ; Tannenbaum, S.R. and Labuza, T. P. Reaction at Limited Water Concentration.2. Chlorophyll Degradation. J. Fd. Sci 36: 850-853, 1971.
  • Montiel, M. y Avanza, J. Estabilidad del Color en Yerba Mate Elaborada. Reunión de Comunicaciones Científicas y Tecnológicas. Universidad Nacional del Nordeste. Tomo IV. Pags: 117-120, 1996.
  • Schwartz, S.J. and Lorenzo, T.V. Chlorophyll Stability During Continuous Aseptic Processing and Storage, J. Fd. Sci 56:1059-1062, 1991.
  • Steet, J.A. and Tong, C.H. Degradation Kinetics of Green Color and Chlorophylls in Peas by Colorimetry and HPLC. J. Fd. Sci 61: 924-927, 1996.
  • Watada, A.E.; Soon, D. K. ; Kwang, S. K. and Harris, T.C. Quality of Green Beans, Bell Peppers and Spinach Stored in Polyethylene Bags. J. Fd. Sci 52: 1637-1641, 1987.
  • *
    Author for correspondence
  • Publication Dates

    • Publication in this collection
      03 June 2011
    • Date of issue
      1999

    History

    • Accepted
      16 Nov 1998
    • Reviewed
      04 Sept 1998
    • Received
      02 Sept 1998
    Instituto de Tecnologia do Paraná - Tecpar Rua Prof. Algacyr Munhoz Mader, 3775 - CIC, 81350-010 Curitiba PR Brazil, Tel.: +55 41 3316-3052/3054, Fax: +55 41 3346-2872 - Curitiba - PR - Brazil
    E-mail: babt@tecpar.br