Acessibilidade / Reportar erro

Effect of replacement of sugarcane by oilseed press cakes in greenhouse gases and volatile fatty acids production in vitro

Efeito da substituição de cana-de-açúcar por tortas oleaginosas sobre a produção in vitro de gases do efeito estufa e ácidos graxos voláteis

ABSTRACT

This study aimed to evaluate the production of methane, carbon dioxide, and volatile fatty acids and changes in ruminal pH in vitro with oilseed press cakes inclusion, such as, cottonseed, sunflower, castor bean, moringa and jatropha at four different levels (0, 30, 50 and 70%) in replacement to the sugarcane in ruminant feeding using semi-automated in vitro technique. The byproduct that produced less CO2 was cottonseed cake (p = 0.0059). The cakes that produced the least amount of CH4 were moringa at 70% (p < 0.05) and cottonseed at 70% levels (p < 0.0001). The cakes that had the highest increases in VFAs were cottonseed and castor (p < 0.0001). Additionally, greater pH was moringa at 70% and cottonseed at 50% levels (p < 0.0001). The greater acetate concentration was 70% cottonseed cake, propionate concentration with 30% cottonseed and butyrate concentration with 50% moringa in sugarcane replace. At the 70% level, the moringa cake displayed the highest decreases in methane production and reduction in energy loss. At the 50% substitution level, the cottonseed cake is the most suitable replacement for sugarcane in order to reduce the production of greenhouse gases.

Keywords:
acetate; butyrate; N-NH3; propionate; VFAs

RESUMO

Objetivou-se avaliar a produção de metano, dióxido de carbono, ácidos graxos voláteis e mudanças no pH ruminal in vitro com tortas de oleaginosas: algodão, girassol, mamona, moringa e pinhão manso incluídas em quatro níveis diferentes (0, 30, 50 e 70%) em substituição à cana-de-açúcar na dieta de ruminantes, utilizando-se a técnica semiautomática in vitro. O subproduto que produziu menos CO2 foi o algodão (p = 0,0059). As tortas de oleaginosas que produziram menos CH4 foram moringa (p < 0,05) e algodão (p < 0,0001) a 70% de inclusão. As tortas que aumentaram a produção de AGVs foram algodão e mamona (p < 0,0001). Além disso, o pH aumentou nos níveis de inclusão a 70% de moringa e 50% de algodão (p < 0,0001). A maior concentração de acetato ocorreu na torta de algodão a 70%, já o propionato na torta de algodão à 30% e a maior concentração de butirato na torta de moringa à 50% em substituição à cana-de-açúcar. Em nível de 70%, a torta de moringa apresentou maior redução no metano e na energia alimentar. Em nível de substituição de 50%, a torta de algodão foi a substituição mais adequada para a cana-de-açúcar, a fim de reduzir a produção de gases com efeito de estufa.

Palavras-chave:
acetato; butyrato; NH3; propionato; AGVs

Introduction

Research involving the production of methane (CH4) and carbon dioxide (CO2) has globally increased due to changes in the ozone layer. Brazil has the world's second largest cattle herd and has signed the Kyoto Protocol; therefore, the country monitors the amount of greenhouse gases produced by the national herd. Methane is the second main

greenhouse gas, contributing to approximately 15% of all gases to global warming (Hristov et al., 2013Hristov, A. N., Firkins, O. J., Dijkstra, J., Kebreab, E., Waghorn, G., Makkar, H. P., & Tricarico, J. M. (2013). Mitigation of methane and nitrous oxide emissions from animal operations: I. A review of enteric methane mitigation options. Journal of Animal Science91(11), 5045-5069.; Muller & Aubert, 2014Muller, A., & Aubert, C. (2014). The potential of organic agriculture to mitigate the influence of agriculture on global warming: a review. In Organic Farming, Prototype for Sustainable Agricultures (p. 239-259). New Delhi, India: Springer Netherlands.).

The gases and volatile fatty acids (VFAs) production derived from rumen fermentation depende on the feed characteristics, the intake and digestibility of the feed by animal (Moreira et al., 2014Moreira, M. N., Silva, A. M. A., Carneiro, H., Bezerra, L. R., Morais, R. K. O., & Medeiros, F. F. (2014). In vitro degradability and total gas production of biodiesel chain byproducts used as a replacement for cane sugar feed. Acta Scientiarum. Animal Science36(4), 399-403. ; Oliveira et al., 2015Oliveira, R. L., Palmieri, A. D., Carvalho, S. T., Leão, A. G., Abreu, C. L., Ribeiro, C. V. D. M., ... Bezerra, L. R. (2015). Commercial cuts and chemical and sensory attributes of meat from crossbred Boer goats fed sunflower cake-based diets. Animal Science Journal86(5), 557-562.). Thus, there is the possibility that gas mitigation could be accomplished by modifying the rumen fermentation through changes of diet and thus manipulating the microbiota of the rumen with feed additives or components naturally present in oilseed press cake (Morais et al., 2015Morais, R. K. O., Silva, A. M. A., Bezerra, L. R., Carneio, H., Moreira, M. N., & Medeiros, F. F. (2015). In vitro degradation and total gas production of byproducts generated in the biodiesel production chain. Acta Scientiarum. Animal Sciences37(4), 143-148. ; Silva et al., 2016Silva, T. M., Oliveira, R. L., Nascimento Júnior, N. G., Pellegrini, C. B., Trajano, J. S., Rocha, T. C., ... Borja, M. S. (2016). Ingestive behavior and physiological parameters of goats fed diets containing peanut cake from biodiesel. Tropical Animal Health and Production48(1), 59-66.).

The byproducts originating from biodiesel production have been presented as potential ingredients for ruminant diets to replace conventional ingredients as in the case of sugarcane, contributing to the methane mitigate and improve the microbiological fermentation of the rumen and consequently the performance of animals. Thus, studies aimed at characterizing the ruminal metabolism of these byproducts (e.g., by measuring gas production in vitro) are needed to identify potential oilseed press cakes that could be used efficiently in the diet of ruminants (Gonzaga Neto et al., 2015Gonzaga Neto, S., Oliveira, R. L., Lima, F. H. S., Medeiros, A. N., Bezerra, L. R., Viégas, J., ... Freitas Neto, M. D. (2015). Milk production, intake, digestion, blood parameters, and ingestive behavior of cows supplemented with by-products from the biodiesel industry. Tropical Animimal Health Production47(1), 191-200.; Medeiros et al., 2015Medeiros, F. F., Silva, A. M. A., Carneiro, H., Araujo, D. R. C., Morais, R. K. O., Moreira, M. N., & Bezerra, L. R. (2015). Alternative protein sources derived from the biodiesel production chain for feeding to ruminants. Arquivo Brasileiro de Medicina Veterinária e Zootecnia67(2), 519-526.; Cerutti et al., 2016Cerutti, W. G., Viegas, J., Barbosa, A. M., Oliveira, R. L., Dias, C. A., Costa, E. S., ... Silveira, A. M. (2016). Fatty acid profiles of milk and Minas frescal cheese from lactating grazed cows supplemented with peanut cake. Journal of Dairy Research83(1), 42-49. ).

These tests must determine whether an adequate supply of these feeds is available and the feed ingredients do not harm animal health, development and production. Thus, this study aims to evaluate the production of CH4, CO2, VFA and pH from several oilseed press cakes: cottonseed (Gossypium hirsutum L.), sunflower (Helianthus annuus L.), castor bean (Ricinus communis), moringa (Moringa oleifera L.) and Jatropha (Jatropha curcas L.) from the production of biodiesel when replacing sugarcane.

Material and methods

This research was conducted at the Experimental Station of Coronel Pacheco, MG (owned by Embrapa Gado de Leite - CNPGL), Minas Gerais State, Brazil. This study was carried out in strict accordance with the recommendations in the Guide for the National Council for Animal Experiments Control (Concea). The protocol was approved by the Committee on the Ethics of Animal Experiments of the Federal University of Piauí, Piauí State, Brazil (Permit Number: 16-2014).

Feeds and substrates

In this experiment, the following oilseed press cakes were used: cottonseed (Gossypium hirsutum L.), sunflower (Helianthus annuus L.), castor bean (Ricinus communis), moringa (Moringa oleifera L.), jatropha (Jatropha curcas L.) and sugarcane from the experimental field of Embrapa in Coronel Pacheco, Minas Gerais State. Approximately 300 g sample of each byproduct, derived from the processing and/or extraction of vegetable oil to produce fuel for the biodiesel industry, was collected. Subsequently, samples were transported to the laboratory, packaged and stored at 5°C prior to analysis.

In the laboratory, the samples belonging to each oilseed press cake were mixed and homogenized to form a single sample. From this sample, a portion (100 g) was used for chemical analysis, and the remainder of the material was used to formulate the test diets. Each diet was formulated to evaluate various levels of cakes, with ratios of 100/0, 70/30, 50/50 and 30/70% (sugarcane/cakes), as fed basis.

Chemical analyses

The substrates consisting of forage materials and the oilseed press cakes were pre-dried in forced air ovens at 55°C for 72 hours and then ground in a Willey mill equipped with a 1.0 mm sieve to determine dry matter (DM) (Method 967.03 - Association of Official Analytical Chemists [AOAC], 1990), ash (Method 942.05 -AOAC, 1990Association of Official Analytical Chemists. (1990). Official methods of analysis (15th ed.). Washington, DC: AOAC. ), crude protein (CP) (Method 981.10 - AOAC, 1990), and ether extract (EE) (Method 920.29 - AOAC, 1990Association of Official Analytical Chemists. (1990). Official methods of analysis (15th ed.). Washington, DC: AOAC. ). To determine the NDF and ADF contents, the methodology of Van Soest, Robertson, and Lewis (1991Van Soest, P. J., Robertson, J. B., & Lewis, B. A. (1991). Methods for dietary fiber, neutral detergent fiber and non-starch polysaccharides in relation to animal nutrition. Journal of Dairy Science 74(10), 3583-3597.) was used with the modifications that were proposed in the Ankon device manual (Ankon Technology Corporation, Macedon, New York, US). Acid detergent lignin (ADL) was determined according to method 973.18 (Association of Official Analytical Chemists [AOAC], 2002Association of Official Analytical Chemists. (2002). Official methods of analysis (12th ed.). Arlington, TX: AOAC.), in which the ADF residue was treated with 72% sulfuric acid. The proportion of ingredients and chemical composition are shown in Table 1. The total carbohydrate (TC) values were determined using the equation described by Sniffen, O'Connor, Van Soest, Fox, and Russel (1992Sniffen, C. J., O'Connor, J. D., Van Soest, P. J., Fox, D. G., & Russel, L. J. B. (1992). A net carbohydrate and protein system for evaluating cattle diets. II - Carbohydrate and protein availability. Journal of Animal Science70(11), 3562-3577. ): TC= 100 - (% CP + % EE + % Ash).

Table 1
Chemical composition (g kg-1 DM) of sugarcane and oilseed press cakes.

In vitro digestibility

In vitro digestibility of the dry matter (DDM) was performed according to the methodology of Tilley and Terry (1963Tilley, J. M. A., & Terry, R. A. (1963). A two stage techinique for the in vitro digestibility of forage crops. Journal British Grassland Society18(2), 104-111. ). Three fistulated steers were used for this in vitro test. The ruminal contents were collected in the morning, transferred to preheated thermo-flasks (39°C) and transported immediately to the laboratory. In the laboratory, the rumen fluid was filtered using three layer of gauze. A mineral buffer solution was later added to the rumen fluid in a water bath maintained at 39°C with continuous CO2 injection. The samples were incubated and rotated for 72 hours. Peptides were added to the incubators within 48 hours to act as an intermediate compound for the microorganisms.

In vitro incubations

The substrates used for the in vitro incubations were cakes of biodiesel chain, which was used to replace the sugarcane in ratios of 100/0, 70/30, 50/50 and 30/70% (sugarcane/cakes). The feed ingredients were dried at 55ºC for 24 hours and then ground to paste through a 1 mm screen. Each in vitro incubation was conducted according to the methods reported by Meale, Chaves, Baah, and Mcallister (2012Meale, S. J., Chaves, A. V., Baah, J., & Mcallister, T. A. (2012). Methane production of different forages in in vitro ruminal fermentation. Asian-Australasian Journal of Animal Science25(1), 86-91.). The entire incubation procedure was repeated twice (i.e., two incubation runs x three replicates per treatment, resulting in a total of six replicate vials per treatment).

The inoculum for the in vitro incubation was obtained from the three ruminally fistulated cows that were grazing on beard grass supplemented with 2 kg of concentrate (22 g kg-1 CP and 12.6 g kg-1 NDF in DM). Rumen fluid was collected two hours before morning milking from four distinct sites in the rumen, filtered through four layers of cheesecloth, combined in equal portions from each animal and immediately transported in a pre-warmed Thermos(r) flask to the laboratory. Inocula were prepared by mixing the rumen fluid with a mineral buffer and 0.5 mL of cysteine sulfide solution (Vitti et al., 1999Vitti, D. M. S., Abdalla, A. L., Silva Filho, J. C., Mastro, N. L. D., Mauricio, R., Owen, E., & Mould, F. (1999). Misleading relationships between in situ rumen dry mater disappearance, chemical analyzed and in vitro gas production and digestibility, of cane sugar baggage treated with varying levels of electron irradiation and ammonia. Animal Feed Science and Technology79(1-2), 145-153. ) in a ratio of 1:5. The inoculum (30 mL) was then transferred into pre-loaded, pre-warmed (39°C) vials under a stream of O2-free N gas. The vials were sealed and placed on an orbital shaker rack set at 120 oscillations per minute in an incubator set at 39ºC.

The net gas production of each vial was measured at 6:00, 12:00, 24:00 and 48:00 hour of incubation with a water displacement apparatus (Fedorah & Hrudey, 1983Fedorah, P. M., & Hrudey, S. E. (1983). A simple apparatus for measuring gas production by methanogenic cultures in serum bottles. Environmental Technology4(10), 425-432.). At 6:00 and 12:00 hour prior to the gas measurement, the headspace gas was sampled from each vial with a 20 mL syringe and immediately transferred into a 5.9 mL evacuated Exetainer(r) (Labco Ltd., High Wycombe, Buckinghamshire, UK), which was analyzed to determine the CH4 concentration using gas chromatography. CH4 and CO2 concentration was expressed as mL g-1 of incubated DM. After the gas was sampled for CH4 and CO2 was measured at 48 hour of incubation, the fermentation vials were opened, and the pH of the ruminal fluid was measured using a pH meter (Orion Model 260A, Fisher Scientific, Toronto, ON, Canada). The ANKOM(r) bags containing the residues were then removed from the bottles, rinsed thoroughly with distilled water and dried at 55°C for 48 hour to a constant weight to estimate the IVDMD.

A subsample (1.6 mL) of the ruminal fluid from each vial was transferred to a 2 mL micro-centrifuge tube and centrifuged at 14,000 x g for 10 min at 4°C (Spectrafuse 16M, National Labnet Co., Edison, NJ, USA) to precipitate the particulate matter and proteins. The supernatant was frozen at -20°C until the analysis of the VFAs concentrations. The 0 hour samples were also analyzed for ammonia-N and VFA to calculate net ammonia-N and net total VFAs production (Holtshausen et al., 2009Holtshausen, L., Chaves, A. V., Beauchemin, K. A., Mcginn, S. M., Mcallister, T. A., Odongo, N. E., ... Benchaar, B. (2009). Feeding saponin containing Yucca shidigera and Quillajasa-ponaria to decrease enteric methane production in dairy cows. Journal of Dairy Science92(6), 2809-2821. ).

Statistical analyses

The experimental design used was completely randomized in a 5 x 4 factorial arrangement (cakes and substitution levels). Four experimental observations were removed from the initial four periods, and an additional period was added to the experiment to provide 4 replications per treatment. Effects were considered significant at a p value of ≤ 0.05. The results of increasing levels were interpreted through regression models using Proc Reg of Statistical Analysis System (SAS, 2004Statistical Analysis System. (2004). SAS/STAT user guide, version 9.1.2. Cary, NC: SAS Institute Inc.). Interaction effects were assessed using Tukey's test between the cakes within each level of substitution and levels substitution within each oilseed press cake.

Results

From the results of the chemical composition shown in Table 1, the sugarcane contained 22.5 g kg CP-1 and 11.9 g kg EE-1. The moringa and cottonseed cakes showed the highest CP and in vitro dry matter digestibility. For levels of neutral detergent fiber, acid detergent fiber and ash were highest in the castor bean and sunflower cake. Jatropha cake had greater amounts of lipids.

The production of methane (CH4) was dependent of the substitution of sugarcane with oilseed press cakes (Table 2). All cakes increased the production of CH4 compared to sugarcane, and moringa and cottonseed cake produced the lowest amount of CH4 (p < 0.05). Other cakes led to relatively high CH4 production; however, 70% castor bean cake substitution (p < 0.0001) produced the highest amount of CH4 among all cakes tested at all levels.

Table 2
Mean values, probability (p value) and regression equations of the effects on production of CH4 (mL g-1) and CO2 (mL g-1) of substitution of sugarcane by oilseed press cakes.

All oilseed cakes increased the production of CH4. With moringa and cottonseed cake the increase was lower (p < 0.05) than with the other cakes. The highest increase in CH4 production was observed with castor bean cake that had a minimum level of 16% when producing 1.54 mL g DM-1 CH4, and 59% of jatropha cake was the maximum point when producting 7.11 mL g DM-1 CH4. The production of carbon dioxide (CO2) was dependent on cakes level used to replace sugarcane. In Table 2, we note that the most effective cakes substituted for sugarcane to reduce CO2 production were cottonseed (p = 0.0059) and jatropha (p = 0.0019).

Sunflower, castor bean and moringa cake the greater level of addition (70%) produced the greater the amount of CO2. Already for moringa, 30 and 50% levels in replacing sugar cane had the greater CO2 production; the sunflower cake at 70% level produced the most amont of CO2 (p < 0.0001). Analyzing the equations of the four levels of each replacement byproduct, the oilseed press cakes of cottonseed and jatropha have decreasing linear equations where as sunflower cake, castor bean and moringa have quadratic equations. In summary, 25.8% sunflower cake replacing sugar cane produced 26.65 mL g DM-1 CO2, castor bean at 25.7% sugar cane substitution produced 30.54 mL g DM-1 CO2 and moringa cake 33.9% of sugar cane substitution produced 50.27 mL g DM-1 CO2.

The oilseed press cakes of moringa, among the five tested cakes, showed decreased acetate production; even at a high substitution level of 70%, the acetate production levels were lower than with sugarcane (p < 0.0001) (Table 3).

Table 3
Mean values, probability (p value) and regression equations illustrating of the effects on production of volatile fatty acids (VFAs) of substitution of sugarcane by oilseed press cakes.

The greater acetate concetration was presented by cottonseed and castor bean cake (p < 0.0001) (Table 3). However, the sunflower cake showed a constant production of acetate regardless of the substitution levels. Observing the equations presented in the acetate production, the oilseed press cakes of cottonseed and castor bean showed increasing linear equations, while the other cakes showed quadratic equations. The maximum points occurred for 54% substitution with sunflower cake (producing 32.35 mmol mL-1 acetate), 53% substitution with jatropha cake (producing 29.65 mmol mL-1 acetate) and 37% substitution with moringa cake (producing 20.37 mmol mL-1 acetate)

Propionate concentration indicated that VFA production decreased for all cakes, where as the 30% substitution level with any of the cakes, except for moringa, increased the propionate production. At substitution levels of 50 and 70%, the cakes showed a decreased production of propionate (p < 0.0001), and castor bean cake produced more propionate than the other cakes at the three levels tested (p < 0.05). Observing the equations, the sunflower cake had an increasing linear equation, the other cakes showed quadratic equations. The maximum points occurred with 24% cottonseed cake substitution leading to the production of 24.08 mmol mL-1 VFA, 25% castor bean cake substitution leading to the production of 24.21 mmol mL-1 VFA, 56% moringa cake substitution yielding 21.85 mmol mL-1 VFA and the 16% jatropha cake leading to the production of 22.64 mmol mL-1 VFA.

The production of butyrate from substitutions with the cottonseed, castor bean and jatropha cakes were stable, except for the butyrate production from 70% oilseed press cake substitutions, for which there was a decrease in the butyrate production (p < 0.0001).

The sunflower cake showed the lowest butyrate production levels. Adding moringa cake did not increase the production of butyrate at 30 and 50% substitution levels; however, the butyrate production decreased at the 70% level. According to the regression equations, the sunflower cake showed a decreasing linear equation and the moringa and jatropha cakes showed quadratic equations. The minimum point occurred with the substitution of moringa cake at a level of 29% leading to the production of 13.36 mmol mL-1 butyrate and minimalmaximum point to jatropha cake at a level of 22% leading to the production of 10.62 mmol mL-1 butyrate.

Regarding the ratio of acetate to propionate, all cakes and levels displayed an increase in this ratio (p < 0.0001). Comparing the cakes within the levels of substitution to sugar cane, moringa had the lowest proportions acetate: propionate while cottonseed and sunflower showed the greatest relationship.This increase in the ratio indicated that with increasing levels of substitution of sugarcane by cakes, an increased production of acetate occurred compared to propionate, except for 0 to 30% for which the opposite occurred.

Changes in pH (Table 4) were dependent on the levels of replacement of sugarcane with the cakes. With the addition of the cakes, no increase in the pH was noted for all levels. The highest pH values at the 30% substitution level occurred with the moringa cake, while at 50% substitution level, the highest pH was induced the sunflower cake. The highest pH values were observed in the castor bean and jatropha cakes at the 70% substitution level (p < 0.0001). From the equations, all cakes showed increasing linear equations for pH.

Table 4
Mean values, probability (p value) and regression equations of the pH when substituting sugarcane by oilseed press cakes.

Discussion

The low protein values of the sugarcane (22.5 g kg-1), compared to the cakes, support the need to utilize alternative sources that can correct this deficiency. Feed supplied to ruminants with a protein deficiency can cause a reduction in the degradability by the rumen microorganisms. Reducing the digestibility of feed decreases the utilization of nutrients by the animal, causes damage in various systems of the ruminant (digestive, reproductive, immune) and reduces animal production. Thus, the use of cottonseed (549.9 g kg-1), sunflower (329.4 g kg-1), castor bean (420.2 g kg-1) moringa (577.6 g kg-1) and jatropha cakes (356.9 g kg-1) can correct this deficiency and improve the digestibility of the diet for the animals.

Depending on the type of feed supplied to a ruminant, fermentation and the production of gases (CO2, CH4 and VFAs) respond differently. With the addition of the cottonseed and moringa cakes, no reduction in CO2 production was observed. This lack of change was because of the incubation was rich in proteins. Substrates high in protein may to reduce the production of CO2 (Khazaal, Dentinho, Ribeiro, & Ørskov, 1995Khazaal, K., Dentinho, M. T., Ribeiro, J. M., & Ørskov, E. R. (1995). Prediction of apparent digestibility and voluntary intake of hays fed to sheep: comparison between using fiber components, in vitro digestibility or characteristics of gas production or nylon bag degradation. Journa of Animal Science61(3), 527-538.; Manatbay, Cheng, Mao, & Zhu, 2014Manatbay, B., Cheng, Y., Mao, S., & Zhu, W. (2014). Effect of Gynosaponin on rumen in vitro methanogenesis under different forage-concentrate ratios. Journa of Animal Science 27(8), 1088-1097. ). Therefore, CO2 production decreases with increases in the level of cakes, even in moringa that had the highest production among all cakes.

However, the castor bean and sunflower cakes had a greater CO2 production with increasing levels of substitution. According to Mizubuti et al. (2011Mizubuti, I. Y., Ribeiro, E. L. A., Pereira, E. S., Pinto, A. P., Franco, A. L. C., Syperreck, M. A., ... Muniz, E. B. (2011). In vitro rumen fermentation kinetics of some co-products generated in the biodiesel production chain by gas production technique. Semina: Ciências Agrárias32(1), 2021-2028. ), the production of acetate yields two moles of CO2 per mole of glucose produced. By monitoring acetate production (Table 3), we noted that castor bean and sunflower cakes showed increased production of acetate. CO2 production occurs during the formation of acetate and butyrate, along with H2 production during the feed fermentation. The results for the jatropha cake may be due to the high quantity of fat that coats the jatropha fibers. This high quantity of fat consequently causes difficulties for the rumen microbial attack on the feed. Subsequently, this difficulty caused antinutritional effects for the microorganisms, thus causing inefficiency and reducing the availability of cations by combining with the fatty acids (Becker et al., 2014Becker, P. M., Wikselaar, P. G., Franssen, M. C. R., Vos, R. C. H., Hall, R. D., & Beekwilder, J. (2014). Evidence for a hydrogen-sink mechanism of (+) catechin-mediated emission reduction of the ruminant greenhouse gas methane. Metabolomics10(3), 179-189.). Overall, this reduces the degradability of the cakes and can reduce the production of gases.

The main pathway for methanogenesis requires CO2 and H2, and methanogenesis occurs at greater production rate of H2. During this fermentation, the production of acetic and butyric acids increases (Williams, Fisher, Berrisford, Moate, & Reynard, 2014Williams, S. R. O., Fisher, P. D., Berrisford, T., Moate, P. J., & Reynard, K. (2014). Reducing methane on-farm by feeding diets high in fat may not always reduce life cycle greenhouse gas emissions. The International Journal of Life Cycle Assessment19(1), 69-78.). The CH4 production presented by the cottonseed cake may have occurred because of the poor release of H2 in the in vitro environment. The production of CO2 from the cottonseed cake was low; therefore, the methane production was lower. Moringa cake was hemagglutinating and bactericidal to the rumen.

Ruminants use VFAs as a source of energy (Martin, Morgavi, & Doreau, 2009Martin, C., Morgavi, D. P., & Doreau, M. (2009). Methane mitigation in ruminants: from microbes to the farm scale. Animal4(3), 351-365.); the production of VFA is directly influenced by the amount of structural and non-structural carbohydrates. As ethyls, increase for fat, propionate increasingly contributes to the production of butyrate. Butyrate is used as the main supplier of energy for the animal, thus resulting in the tables of the chemical composition and the production of acetate, propionate and butyrate. Sunflower and castor bean cakes showed increasing levels of acetate. These greater levels of acetate can be explained by the amount of NDF and ADF, which contributes to the formation of acetate and butyrate production. Increases in NDF and ADF increase the VFAs, H2 and CO2 produced. These greater concentrations increase methane production.

The cottonseed cake had a greater acetate production. Horner, Coppock, Schelling, Labore, and Nave (1998Horner, J. L., Coppock, C. E., Schelling, G. T., Labore, J. M., & Nave, D. H. (1998). Effects of whole cottonseed on ruminal fermentation, protein degradability, milk yield and composition and responses of dairy cows. Journal of Dairy Science 71(5), 1239-1247.) showed that diets with cottonseed increases in the concentration of acetate 15-30%. This increase is a result of the fermentation of the cottonseed fiber, which is highly digestible and produces high amounts of acetate. However, the moringa cake produced less acetate and butyrate for all addition levels. This lower production occurred because moringa cake have bactericidal lectins that bind to carbohydrates, lipopolysaccharide and teichoic acid. Therefore, the presence of these lectins cause decreased ruminal flora, reduced fermentation and decreased production of acetate and butyrate (Martínez-Fernández et al., 2014Martínez-Fernández, G., Abecia, L., Ramos-Morales, E., Martin-García, A. I., Molina-Alcaide, E., & Yáñez-Ruiz, D. R. (2014). Effects of propyl propane thiosulfinate on nutrient utilization, ruminal fermentation, microbial population and methane emissions in goats. Animal Feed Science and Technology191(5), 16-25.). This oilseed press cake also decreases the production of propionate. This decrease may have occurred because the moringa cake display cationic properties. According to Olivares-Palma et al. (2013Olivares-Palma, S. M., Meale, S. J., Pereira, L. G. R., Machado, F. S., Carneiro, H., Lopes, F. C. F., ... Chaves, A. V. (2013). In vitro fermentation, digestion kinetics and methane production of oilseed press cakes from biodiesel production. Asian-Australasian Journa of Animal Science26(8), 1102-1110. ), moringa will kidnap H2 thus decreasing the production of propionate (glucose + 2 H2) and further reduce the production of methane.

The sunflower and jatropha cake showed a decrease in acetate production because pH increased lipids in the diet. Lipids cover fibrous feed, reducing the degradability, production of acetate and production of propionate. The ether extract assists in the removal of the H2 + free rumen by biohydrogenation. Removing the H2 process will decrease the production of propionate.

The low pH values can be justified by the presence of soluble carbohydrates contained mainly in the sugarcane, which have been slightly degraded in the rumen. According to Owens and Goetsch (1993Owens, F. N., & Goetsch, A. L. (1993). Ruminal fermentation. In D. C. Church (Ed.), The ruminant animal: digestive physiology and nutrition (p. 145-171). Englewood Cliffs: Waveland Press.), the low amount of acetate and high concentration of propionate directly influences the pH. The acetate:propionate ratio increased with increased levels of these cakes. Therefore, the pH was initially low, and with the addition of cakes, the pH values increased. Whereas low pH values are not suitable for the maintenance of ruminal microflora, these values are not notable below 70% substitution levels of sugarcane with cakes.

Conclusion

According with in vitro tests the moringa (70%) and cottonseed (50%) cakes promove (70%) highest reduce greenhouse gases promoving reduction in energy loss. The highest acetate concentration was 70% cottonseed cake, propionate concentration with 30% cottonseed and butyrate concentration with 50% moringa in sugarcane replace.

Acknowledgements

The authors wish to thank the Conselho Nacional de Desenvolvimento Científico e Tecnológico (CNPq), Embrapa Dairy Cattle and Fundação de Amparo à Pesquisa do Estado de Minas Gerais (Fapemig - Minas Gerais State).

References

  • Association of Official Analytical Chemists. (1990). Official methods of analysis (15th ed.). Washington, DC: AOAC.
  • Association of Official Analytical Chemists. (2002). Official methods of analysis (12th ed.). Arlington, TX: AOAC.
  • Becker, P. M., Wikselaar, P. G., Franssen, M. C. R., Vos, R. C. H., Hall, R. D., & Beekwilder, J. (2014). Evidence for a hydrogen-sink mechanism of (+) catechin-mediated emission reduction of the ruminant greenhouse gas methane. Metabolomics10(3), 179-189.
  • Cerutti, W. G., Viegas, J., Barbosa, A. M., Oliveira, R. L., Dias, C. A., Costa, E. S., ... Silveira, A. M. (2016). Fatty acid profiles of milk and Minas frescal cheese from lactating grazed cows supplemented with peanut cake. Journal of Dairy Research83(1), 42-49.
  • Fedorah, P. M., & Hrudey, S. E. (1983). A simple apparatus for measuring gas production by methanogenic cultures in serum bottles. Environmental Technology4(10), 425-432.
  • Gonzaga Neto, S., Oliveira, R. L., Lima, F. H. S., Medeiros, A. N., Bezerra, L. R., Viégas, J., ... Freitas Neto, M. D. (2015). Milk production, intake, digestion, blood parameters, and ingestive behavior of cows supplemented with by-products from the biodiesel industry. Tropical Animimal Health Production47(1), 191-200.
  • Holtshausen, L., Chaves, A. V., Beauchemin, K. A., Mcginn, S. M., Mcallister, T. A., Odongo, N. E., ... Benchaar, B. (2009). Feeding saponin containing Yucca shidigera and Quillajasa-ponaria to decrease enteric methane production in dairy cows. Journal of Dairy Science92(6), 2809-2821.
  • Horner, J. L., Coppock, C. E., Schelling, G. T., Labore, J. M., & Nave, D. H. (1998). Effects of whole cottonseed on ruminal fermentation, protein degradability, milk yield and composition and responses of dairy cows. Journal of Dairy Science 71(5), 1239-1247.
  • Hristov, A. N., Firkins, O. J., Dijkstra, J., Kebreab, E., Waghorn, G., Makkar, H. P., & Tricarico, J. M. (2013). Mitigation of methane and nitrous oxide emissions from animal operations: I. A review of enteric methane mitigation options. Journal of Animal Science91(11), 5045-5069.
  • Khazaal, K., Dentinho, M. T., Ribeiro, J. M., & Ørskov, E. R. (1995). Prediction of apparent digestibility and voluntary intake of hays fed to sheep: comparison between using fiber components, in vitro digestibility or characteristics of gas production or nylon bag degradation. Journa of Animal Science61(3), 527-538.
  • Manatbay, B., Cheng, Y., Mao, S., & Zhu, W. (2014). Effect of Gynosaponin on rumen in vitro methanogenesis under different forage-concentrate ratios. Journa of Animal Science 27(8), 1088-1097.
  • Martin, C., Morgavi, D. P., & Doreau, M. (2009). Methane mitigation in ruminants: from microbes to the farm scale. Animal4(3), 351-365.
  • Martínez-Fernández, G., Abecia, L., Ramos-Morales, E., Martin-García, A. I., Molina-Alcaide, E., & Yáñez-Ruiz, D. R. (2014). Effects of propyl propane thiosulfinate on nutrient utilization, ruminal fermentation, microbial population and methane emissions in goats. Animal Feed Science and Technology191(5), 16-25.
  • Meale, S. J., Chaves, A. V., Baah, J., & Mcallister, T. A. (2012). Methane production of different forages in in vitro ruminal fermentation. Asian-Australasian Journal of Animal Science25(1), 86-91.
  • Medeiros, F. F., Silva, A. M. A., Carneiro, H., Araujo, D. R. C., Morais, R. K. O., Moreira, M. N., & Bezerra, L. R. (2015). Alternative protein sources derived from the biodiesel production chain for feeding to ruminants. Arquivo Brasileiro de Medicina Veterinária e Zootecnia67(2), 519-526.
  • Mizubuti, I. Y., Ribeiro, E. L. A., Pereira, E. S., Pinto, A. P., Franco, A. L. C., Syperreck, M. A., ... Muniz, E. B. (2011). In vitro rumen fermentation kinetics of some co-products generated in the biodiesel production chain by gas production technique. Semina: Ciências Agrárias32(1), 2021-2028.
  • Morais, R. K. O., Silva, A. M. A., Bezerra, L. R., Carneio, H., Moreira, M. N., & Medeiros, F. F. (2015). In vitro degradation and total gas production of byproducts generated in the biodiesel production chain. Acta Scientiarum. Animal Sciences37(4), 143-148.
  • Moreira, M. N., Silva, A. M. A., Carneiro, H., Bezerra, L. R., Morais, R. K. O., & Medeiros, F. F. (2014). In vitro degradability and total gas production of biodiesel chain byproducts used as a replacement for cane sugar feed. Acta Scientiarum. Animal Science36(4), 399-403.
  • Muller, A., & Aubert, C. (2014). The potential of organic agriculture to mitigate the influence of agriculture on global warming: a review. In Organic Farming, Prototype for Sustainable Agricultures (p. 239-259). New Delhi, India: Springer Netherlands.
  • Olivares-Palma, S. M., Meale, S. J., Pereira, L. G. R., Machado, F. S., Carneiro, H., Lopes, F. C. F., ... Chaves, A. V. (2013). In vitro fermentation, digestion kinetics and methane production of oilseed press cakes from biodiesel production. Asian-Australasian Journa of Animal Science26(8), 1102-1110.
  • Oliveira, R. L., Palmieri, A. D., Carvalho, S. T., Leão, A. G., Abreu, C. L., Ribeiro, C. V. D. M., ... Bezerra, L. R. (2015). Commercial cuts and chemical and sensory attributes of meat from crossbred Boer goats fed sunflower cake-based diets. Animal Science Journal86(5), 557-562.
  • Owens, F. N., & Goetsch, A. L. (1993). Ruminal fermentation. In D. C. Church (Ed.), The ruminant animal: digestive physiology and nutrition (p. 145-171). Englewood Cliffs: Waveland Press.
  • Silva, T. M., Oliveira, R. L., Nascimento Júnior, N. G., Pellegrini, C. B., Trajano, J. S., Rocha, T. C., ... Borja, M. S. (2016). Ingestive behavior and physiological parameters of goats fed diets containing peanut cake from biodiesel. Tropical Animal Health and Production48(1), 59-66.
  • Sniffen, C. J., O'Connor, J. D., Van Soest, P. J., Fox, D. G., & Russel, L. J. B. (1992). A net carbohydrate and protein system for evaluating cattle diets. II - Carbohydrate and protein availability. Journal of Animal Science70(11), 3562-3577.
  • Statistical Analysis System. (2004). SAS/STAT user guide, version 9.1.2. Cary, NC: SAS Institute Inc.
  • Tilley, J. M. A., & Terry, R. A. (1963). A two stage techinique for the in vitro digestibility of forage crops. Journal British Grassland Society18(2), 104-111.
  • Van Soest, P. J., Robertson, J. B., & Lewis, B. A. (1991). Methods for dietary fiber, neutral detergent fiber and non-starch polysaccharides in relation to animal nutrition. Journal of Dairy Science 74(10), 3583-3597.
  • Vitti, D. M. S., Abdalla, A. L., Silva Filho, J. C., Mastro, N. L. D., Mauricio, R., Owen, E., & Mould, F. (1999). Misleading relationships between in situ rumen dry mater disappearance, chemical analyzed and in vitro gas production and digestibility, of cane sugar baggage treated with varying levels of electron irradiation and ammonia. Animal Feed Science and Technology79(1-2), 145-153.
  • Williams, S. R. O., Fisher, P. D., Berrisford, T., Moate, P. J., & Reynard, K. (2014). Reducing methane on-farm by feeding diets high in fat may not always reduce life cycle greenhouse gas emissions. The International Journal of Life Cycle Assessment19(1), 69-78.

Publication Dates

  • Publication in this collection
    Sept 2016

History

  • Received
    09 Apr 2016
  • Accepted
    23 May 2016
Editora da Universidade Estadual de Maringá - EDUEM Av. Colombo, 5790, bloco 40, CEP 87020-900 , Tel. (55 44) 3011-4253, Fax (55 44) 3011-1392 - Maringá - PR - Brazil
E-mail: actaanim@uem.br