Acessibilidade / Reportar erro

USO DE ESTUFA SOLAR PARA SECAGEM DE MADEIRA SERRADA1 1 Parte da Dissertação do primeiro autor apresentada no Programa de Pós-Graduação em Engenharia Florestal, Centro de Ciências Rurais, Universidade Federal de Santa Maria, Av. Roraima, 1000, CEP: 97105-900, Santa Maria (RS).

USE OF SOLAR KILN FOR THE DRYING OF SAWN WOOD

RESUMO

O objetivo desse estudo foi avaliar o uso da estufa solar para secagem das madeiras de Eucalyptus tereticornis, Eucalyptus saligna e Corymbia citriodora, bem como comparar essa metodologia com a secagem ao ar livre. Para tanto, foi desenvolvido um secador solar constituído por estruturas de madeira, cobertura com dupla camada de plástico PVC (policloreto de vinila), sistema coletor interno de energia solar e sistema de circulação do ar aquecido. A eficiência do secador solar foi comparada com a secagem ao ar livre quanto ao tempo de secagem e qualidade da madeira. Cada espécie foi submetida, no mesmo período, aos dois métodos de secagem, sendo utilizadas cargas com 55 tábuas em cada método. Os resultados obtidos indicaram que a estufa solar foi mais eficiente apresentando tempo de secagem de duas a cinco vezes menores que a secagem ao ar livre e com teor de umidade final mais baixo. A madeira seca, tanto na estufa solar quanto ao ar livre, apresentou boa qualidade, não sendo verificada a incidência de defeitos como encanoamento e colapso. Além disso, o correto empilhamento e a tecnologia de secagem utilizados proporcionaram poucos empenos do tipo encurvamento. A incidência de arqueamentos, rachaduras de superfície e de topo não apresentaram diferença significativa entre a secagem em estufa solar e ao ar livre para as três madeiras estudadas.

Palavras-chave:
secagem solar; qualidade da madeira; taxa de secagem; madeiras refratárias

ABSTRACT

This study aimed at evaluating the use of a solar kiln for the drying of woods of Eucalyptus tereticornis, Eucalyptus saligna and Corymbia citriodora, as well as comparing such a methodology to the air seasoning practice. In order to do so, it was built a solar kiln composed basically of wood structures, roofing with a double layer of PVC, sunlight internal collector and hot air circulation systems. The efficiency of the solar kiln was compared to the air seasoning in drying time and wood quality. In the same drying schedule, each species was submitted to the two drying approaches using a load of 55 boards in each method. Results indicated that the solar kiln was more efficient in drying time, around 2 to 5 times faster and final moisture content lower than the air drying. Adequate wood quality was observed in both drying methods, and no defects such as cup or collapse were observed. Furthermore, the correct piling up and drying process provided minimization of defects such as bow. The incidence of crook, end and surface checks were not significantly distinct between solar drying and air seasoning for the three woods studied.

Keywords:
solar drying; wood quality; drying rate; refractory wood

Texto completo disponível apenas em PDF.

Full text available only in PDF format.

REFERÊNCIAS BIBLIOGRÁFICAS

  • BANKS, C. H. Solar drying of timber - a development study. Pretoria: CSIR Timber Research Unit, 1969. 27 p.
  • BAUER, K. Development and optimisation of a low-temperature drying schedule for Eucalyptus grandis (Hill) ex Maiden in a solar-assisted timber dryer. 2003. 178 f. Tese (Doutorado em Ciências Agrárias) - Fakultät Agrarwissenschaften der Universität Hohenheim, Hohenheim.
  • BEKELE, T. Degradation of boards of Eucalyptus globulus Labill. and Eucalyptus camaldulensis Dehnh. during air drying. Holz als Roh-und Werkstoff, München, v. 53, n. 6, p. 407-412, 1995.
  • BOND, B. Design and operation of a solar-heated dry kiln. Blacksburg: Department of Wood Science and Forest Products, Virginia Tech, Virginia Cooperative Extension, 2006. 10 p.
  • BOIS, P. J. Constructing and operating a small solar-heated lumber dryer. Madison: Department of Agriculture, Forest Service, State and Private Forest, Forest Products Utilities, 1977. 12 p. (Technical Report n.7).
  • CAMPBELL, G. S.; HARTLEY, J. Drying and dried wood. In: HILLIS, W.E.; BROWN, A.G. (Ed.). Eucalyptus for wood production. Melbourne: Academic Press, 1988. cap. 16, p. 328-336.
  • CASIN, R. F. Solar dryer for lumber. Los Banõs: For. Prod. Res. Inst., 1967. 3 p. (Technical Note, n. 76).
  • CHEN, P. Y. S. et al. Pilot plant studies of solar and solar-dehumidification lumber drying. In: INTERSOCIETY ENERGY CONVERSION ENGINEERING CONFERENCE, 15., 1980, Seattle. Proceedings... Seattle: IECEC, 1980. p. 18-22.
  • CHEN, P. Y. S. et al. Experimental solar-dehumidification kiln for lumber drying. Forest Products Journal, Madison, v. 32, n. 9, p. 35-41, 1982.
  • CHEN, P. Y. S.; ROSEN, H. N. Drying yellow-poplar in a highly efficient solar kiln. In: ANNUAL WESTERN DRY KILN CLUBS, 30., 1979, Corvallis. Proceedings... Corvallis: Western Dry Kiln Clubs, 1979. p. 23-32.
  • CHUDNOFF, M. et al. Solar drying of tropical hardwoods. Rio Piedras: U.S. Department of Agriculture, Forest Service, International Institute of Tropical Forestry, Paper ITF-2, 1966. 26 p.
  • CUETO, E. M. P. Diseño y ensayo de un secador solar para madera. Madera y Bosques, Xalapa v. 3, n. 2, p. 13-28, 1997.
  • GALVÃO, A. P. M.; JANKOWSKY, I. P. Secagem racional da madeira. São Paulo, Brasil: Nobel, 1985. 111 p.
  • GOUGH, D. K. The design and operation of a solar timber kiln. Suva, Fiji: Fiji Timbers and their uses, Department of Forestry, 1977. 17 p.
  • HAQUE, M. N. Modelling of solar kilns and the development of an optimized schedule for drying hardwood timber. 2002. 354 f. Tese (Doutorado em Engenharia Química) - University of Sidney, Sidney.
  • IBDF. Norma para classificação de madeira serrada de folhosas. Brasília: Ministério da Agricultura. 1983. 67 p.
  • LUMLEY, T. G.; CHOONG, E. T. Solar drying of wood in Louisiana. Baton Rouge: Louisiana State University and Agricultural and Mechanical College, 1981. 55 p. (Bulletin n. 732).
  • MALDONADO, E. D.; PECK, E. C. Drying by solar radiation in Puerto Rico. Forest Products Journal , Madison, v. 12, n. 10, p. 487-488, 1962.
  • PLUMPTRE, R. A. The design and operation of a small solar seasoning kiln on the Equator in Uganda. Commonwealth Forestry Review, Abingdon, v. 46, n. 4, p. 298-309, 1967.
  • PLUMPTRE, R. A. Simple solar heated timber dryers: design, performance and commercial viability. Commonwealth Forestry Review , Abingdon, v. 58, n. 4, p.243-251, 1979.
  • RASMUSSEN, E. F. Dry kiln operator’s manual. Madison, USA: U.S. Department of Agriculture, Forest Products Laboratory, 1961. 197 p.
  • READ, W. R. et al. A solar timber kiln. Solar Energy, Tampa, v. 15, n. 1, p. 309-316, 1974.
  • RIETZ, R. C.; PAGE, R. H. Air drying of lumber: a guide to industry practices. Madison: U.S. Department of Agriculture, Forest Service, 1971. 110 p.
  • SANTINI, E. J. Secagem de madeira serrada em estufa solar e sua comparação com os métodos convencionais. 1981. 185 f. Dissertação (Mestrado em Engenharia Florestal) - Universidade Federal do Paraná, Curitiba.
  • SANTINI, E. J. Umidade de equilíbrio para algumas cidades do Rio Grande do Sul. In: CONGRESSO FLORESTAL ESTADUAL, 5., 1984, Nova Prata. Anais...Santa Maria: UFSM, 1984. p. 828-840.
  • SATTAR, M. A. Comparative studies of wood seasoning with a special reference to solar drying. Bano Biggyan Patrica, Chittagong, v. 16, n. 1/2, p. 30-42, 1987.
  • SEVERO, E. T. D. Qualidade da secagem de madeira serrada de Eucalyptus dunnii. Ciência Florestal, Santa Maria, v. 10, n. 1, p. 109-124, 2000.
  • SHARMA, S. N. et al. A solar timber seasoning kiln. Journal of the Timber Development Association of India, Dehra Dun, v. 18, n. 2, p. 10-26, 1974.
  • SIMPSON, W. T. Dry kiln operator’s manual . Madison: U.S. Department of Agriculture, Forest Products Laboratory, 1991. 274 p.
  • STÖHR, H. P. The seasoning of South African grown Eucalyptus grandis and Eucalyptus saligna. South African Forestry Journal, Grahamstown, v. 102, n. 1, p. 61-66, 1977.
  • TROXELL, H. E.; MULLER, L. A. Solar lumber drying in the Central Rocky Mountain Region. Forest Products Journal , Madison, v. 18, n. 1, p. 19-24, 1968.
  • TSCHERNITZ, J. L.; SIMPSON, W. T. Solar-heated forced-air, lumber dryer for tropical latitudes. Solar Energy , Tampa, v. 22, n. 1, p. 563-566, 1979.
  • VITAL, B. R. Utilização de energia solar para secagem de madeira. Revista Ceres, Viçosa, v. 23, n. 125, p. 1-10, 1976.
  • VITAL, B. R.; COLLOM, J. L. Secador solar para madeira. Viçosa: Imprensa Universitária da Universidade Federal de Viçosa, 1974. 34 p.
  • VIEHBECK, P. Lo básico del secado de madera con energía solar. Eschborn: GTZ - GATE, 1999. 49 p.
  • WILLIAMS, D. H. The Use of Solar Energy for Timber Drying: Progress Report on Year 2 of the Rotorua Experimental Unit. Rotorua: Forest Products Division, Project Record 261, NZ Forest Service, FRI, 1983. 9 p.
  • YANG, K. C. Solar kiln perfomance at a high latitude, 48ºN. Forest Products Journal , Madison, v. 30, n. 3, p. 37-40, 1980.
  • 1
    Parte da Dissertação do primeiro autor apresentada no Programa de Pós-Graduação em Engenharia Florestal, Centro de Ciências Rurais, Universidade Federal de Santa Maria, Av. Roraima, 1000, CEP: 97105-900, Santa Maria (RS).

Datas de Publicação

  • Publicação nesta coleção
    Oct-Dec 2009
Universidade Federal de Santa Maria Av. Roraima, 1.000, 97105-900 Santa Maria RS Brasil, Tel. : (55 55)3220-8444 r.37, Fax: (55 55)3220-8444 r.22 - Santa Maria - RS - Brazil
E-mail: cienciaflorestal@ufsm.br