Acessibilidade / Reportar erro

Design, preparation and in vitro characterizations of fluconazole loaded nanostructured lipid carriers

Abstract

Present study was aimed to prepare and characterize fluconazole loaded nanostructured lipid carriers (FLZ-NLCs) for the treatment of fungal infections. Fungal infections are tremendously widespread and are the often faced dermatological condition worldwide. FLZ-NLCs was prepared by ultrasonication emulsion technique using stearic acid (SA) as solid lipid, castor oil as liquid lipid and tween 20 as a surfactant. The mean diameter of optimized FLZ-NLCs were found to be 359.15 ± 9.83 nm. The drug content and entrapment efficiency of NLCs was found to be 102.97 ± 7.45% and 87 ± 0.59%, respectively. In vitro drug release studies of FLZ-NLCs showed 37.34 ± 2.08% drug release over a period of 72 h. The above studies confirmed the prepared FLZ-NLCs may be useful for the treatment of fungal infections.

Keywords:
Fluconazole; NLCs; Nanostructured lipid carriers; Fungal infections; Full factorial design; Design of experiment


INTRODUCTION

The occurrence of superficial fungal infections have been globally increased, almost up to 40.0 million people suffer from this infection in developed as well as under developed countries. Fungal infections can cause deteriorating immune system with its progresses (Havlickova, Czaika, Friedrich, 2008Havlickova B, Czaika VA, Friedrich M. Epidemiological trends in skin mycoses worldwide. Mycoses. 2008;51(Suppl 4):2-15.; Ameen, 2010Ameen M. Epidemiology of superficial fungal infections. Clin Dermatol. 2010;28(2):197-201.). Treating fungal infections via topical route provides several advantages, such as reduction in adverse effects of antifungal agents, site specific delivery, high patient compliance and efficacious treatment. There are various topical antifungal agents used in treating dermatological skin problems. They mainly includes azoles, allylamine/benzylamines and polyenes (Güngör, Erdal, Aksu, 2013Güngör S, Erdal MS, Aksu B. New formulation strategies in topical antifungal therapy. J Cosmet Dermatol Sci Appl. 2013;3(1A):56-65.). Feasibility of a topical formulation solely depends on its permeation through the target site and also on the availability of drug concentration levels in the skin.

Novel drug delivery systems include colloidal systems, vesicular carriers and nanoparticles enhances the topical delivery of antifungals into the skin (Lee, Maibach, 2006Lee CM, Maibach HI. Deep percutaneous penetration into muscles and joints. J Pharm Sci. 2006;95(7):1405-13.). The nanoparticulate carrier systems such as nanostructured lipid carriers (NLCs) are the second generation of lipid particles, specially designed to overpower solid lipids nanoparticles (SLNs) with respect to their limitations. NLCs are blend of solid and liquid lipids. They are less toxic in nature as the lipids used are approved as safe (GRAS) and the nano range of particles enhance the penetration into stratum corneum. They exhibit a controlled release profile and in the recent years these nanoparticulate carrier systems such as SLNs and NLCs have been formulated as an effective carrier for antifungal compounds (Souto et al., 2004Souto EB, Wissing SA, Barbosa CM, Müller RH. Development of a controlled release formulation based on SLN and NLC for topical clotrimazole delivery. Int J Pharm. 2004;278(1):71-7.; Gupta, Vyas, 2012Gupta M, Vyas SP. Development, characterization and in vivo assessment of effective lipidic nanoparticles for dermal delivery of fluconazole against cutaneous candidiasis. Chem Phys Lipids. 2012;165(4):454-61.). NLC reduces the systemic absorption of the drugs and is an excellent carrier for irritant drugs at high concentrations (Li et al., 2008Li X, Nie SF, Kong J, Li N, Ju CY, Pan WS. A controlled-release ocular delivery system for ibuprofen based on nanostructured lipid carriers. Int J Pharm. 2008;363(1-2):177-82.; Selvamuthukumar, Velmurugan, 2012Selvamuthukumar S, Velmurugan R. Nanostructured lipid carriers: a potential drug carrier for cancer chemotherapy. Lipids Health Dis. 2012;11:159.). On topical application, the lipids tend to adhere to the skin due to their occlusive property that leads to increased skin hydration effect. NLCs have the ability to scatter light owing to the structural imperfections which can be used to incorporate light sensitive drugs in them (Sanad et al., 2010Sanad RA, Abdelmalak NS, Elbayoomy TS, Badawi AA. Formulation of a novel oxybenzone-loaded nanostructured lipid carriers (NLCs). AAPS PharmSciTech. 2010;11(4):1684-94.).

Fluconazole (FLZ) belongs to a class of compounds named as fluorobenzenes (Fluconazole, 2017Fluconazole. 2017. Drug Bank. [Accessed on April 04, 2017]. Available from: https://www.drugbank.ca/drugs/DB00196.
https://www.drugbank.ca/drugs/DB00196...
). It is a synthetic antifungal agent belonging to biopharmaceutical classification system (BCS) class III, which has a log P value of 0.4. It is widely used antifungal drug for most of the superficial and invasive dermatological conditions (Gaikwad et al., 2012Gaikwad VL, Yadav VD, Dhavale RP, Choudhari PB, Jadhav SD. Effect of carbopol 934 and 940 on fluconazole release from topical gel formulation: A factorial approach. Current Pharma Research. 2012;2(2):487-93.). It differs in its pharmacokinetic profile when compared to imidazoles. The structure consists of two triazole rings, which render the drug to be more hydrophilic in nature when compared to other azoles. The halogenated phenyl ring is responsible for antifungal activity. Fluconazole is commercially available as oral tablets and injections which has disadvantages such as nausea, vomiting, bloating, loss of appetite, headache, etc. (Helal et al., 2012Helal DA, Abd El-Rhman D, Abdel-Halim SA, El-Nabarawi MA. Formulation and evaluation of fluconazole topical gel. Int J Pharm Pharm Sci. 2012;4(Suppl 5):176-83.; Sawant, Khan, 2017Sawant B, Khan T. Recent advances in delivery of antifungal agents for therapeutic management of candidiasis. Biomed Pharmacotherapy. 2017;96:1478-90.). But, oral formulations cannot reach the required concentration of drug in the body to deactivate the fungi (Kumar et al., 2013Kumar L, Reddy MS, Shirodkar RK, Pai GK, Krishna VT, Verma R. Preparation and characterization of fluconazole films for the treatment of vaginal candidiasis. Indian J Pharm Sci. 2013;75(5):585-90.) and another issue associated with the oral formulations is avoidance of their administration during pregnancy (Merkus, 1990Merkus JM. Treatment of vaginal candidiasis: Orally of vaginally? J Am Acad Dermatol. 1990;23(3 Pt 2):568-72.). Parenteral are less preferable by the patients due to related pain on the site of administration and privacy which causes lack of patient compliance.

In the last few years, researchers have focused more on the lipid nanoparticles (such as SLNs, NLCs, niosomes, liposomes, ethosomes, etc.) of antifungals to avoid their side effects and to improve their efficacy (Trombino, Mellace, Cassano, 2016Trombino S, Mellace S, Cassano R. Solid lipid nanoparticles for antifungal drugs delivery for topical applications. Ther Deliv. 2016;7(9):639-47.; Behtash, Nafisi, Maibach, 2017Behtash A, Nafisi S, Maibach HI. New generation of fluconazole: A review on existing researchers and technologies. Curr Drug Deliv. 2017;14(1):2-15.; Soliman, 2017Soliman GM. Nanoparticles as safe and effective delivery systems of antifungal agents: Achievements and challenges. Int J Pharm. 2017;523(1):15-32.; Wolf et al., 2017Wolf M, Klang V, Halper M, Stix C, Heuser T, Kotisch H, Valenta C. Monoacyl-phosphotidylcholine nanostructured lipid carriers: Influence of lipid and surfactant content on in vitro skin permeation of flufenamic acid and fluconazole. J Drug Deliver Sci Technol. 2017;41:419-30.). Hence, in the present study, to overcome the problems associated with FLZ, the NLC system for topical delivery of FLZ has been proposed. The available literature justifies that FLZ loaded NLCs are limited. The NLCs formulation shows a high amount of drug accumulation in the skin which is recommended for the fungal treatment. Thus, NLCs are providing a good targeting effect and it also has proved to be a promising carrier for topical delivery of drugs exhibiting antigungal activity (Gupta, Vyas, 2012Gupta M, Vyas SP. Development, characterization and in vivo assessment of effective lipidic nanoparticles for dermal delivery of fluconazole against cutaneous candidiasis. Chem Phys Lipids. 2012;165(4):454-61.). The aim of the present study was to develop and characterize FLZ loaded NLCs.

MATERIAL AND METHODS

Material

FLZ was received as a gift sample from Ipca Laboratories, Mumbai, India. Stearic acid and potassium dihydrogen ortho phosphate were purchased from Finar Limited, Ahmedabad, India. Castor oil was procured from Jayant Agro Organics, Mumbai, India. Tween 20 was found from Encube Ethicals Pvt. Ltd., Goa, India. Poloxamer 188 was obtained as gift sample from Signet Chemical Corporation Pvt. Ltd., Mumbai, India. Methanol was obtained from Lobort Fine Chem Pvt. Ltd., Surat, India. Oleic acid and olive oil were purchased from Sigma-Aldrich Chemie, USA. Sodium hydroxide was obtained from HiMedia Laboratories Pvt. Ltd., Mumbai, India.

Methods

Selection of lipids, surfactants and method for the preparation of NLCs

Lipids, surfactants and method for preparation of NLCs were selected on the basis of the following studies:

Screening of solid lipids

The solid lipid (100 mg) was taken in a glass ria vial. Then the heat was applied to 10 ºC greater than the actual temperature of the lipid. FLZ was added in the molten mass of lipid in the increment of 1 mg until the molten lipid reached a saturated state. The solubility of FLZ was determined in two solid lipids such as stearic acid (SA) and glyceryl monostearate (GMS). Then the amount of FLZ taken up by 1 g of solid lipid was calculated.

Screening of liquid lipids (oils)

The solubility of FLZ was determined in various liquid lipids (castor oil, oleic acid and olive oil) by adding FLZ in the increment of 0.5 mg in 0.5 mL of the liquid lipids in microcentrifuge tubes. Then the micro centrifuge tubes were vortex for 2 min and physically observed. The procedure was continued with the addition of 0.5 mg increment of drug until it no longer dissolved. Then the amount of FLZ which can be taken up by 1 g of liquid lipid was calculated.

Screening of surfactants and selection of method for the preparation of NLCs

Three emulsifying agents such as tween 20, tween 80 and poloaxamer 188 were studied for their suitability. Few trials were performed with tween 20, tween 80 and poloxamer 188 using microemulsion technique (Saez, Souza, Mansur, 2018Saez V, Souza IDL, Mansur CRE. Lipid nanoparticles (SLN & NLC) for delivery of vitamin E: A comprehensive review. Int J Cosmetic Sci. 2018:40(2):103-16.) (as shown in Table I) and also few trials were performed with two surfactants such as tween 20 and tween 80 using ultrasonication emulsion technique (as shown in Table II). The surfactant which couldn’t showed very promising results while using microemulsion technique was ignored during ultrasonication emulsion technique. The particle size, polydispersity index (PDI) and zeta potential of these trials were recorded and on the basis of the obtained results a suitable emulsifier and a method for the preparation of NLCs was chosen.

TABLE I
Study of surfactants using microemulsion technique
TABLE II
Study of surfactants using ultrasonication emulsion method

Drug-excipient compatibility studies

Fourier transform infrared spectroscopy (FTIR)

Fourier transform infrared spectroscopy (FTIR) studies were performed using FTIR spectrophotometer (FTIR-8300, Shimadzu Corporation, Kyoto) to identify the compatibility of FLZ with SA. The spectrum was recorded using KBr pellet method in the range of 4000-400 cm-1. The physical mixture (PM) of FLZ and SA were stored at 40 ºC for 15 days and after the specified time the samples were analysed with FTIR spectrophotometer. The obtained results were compared with FLZ and SA results to confirm the compatibility. After analysis, the spectrum were recorded using IR solution v.1.2 software (Kumar et al., 2013Kumar L, Reddy MS, Shirodkar RK, Pai GK, Krishna VT, Verma R. Preparation and characterization of fluconazole films for the treatment of vaginal candidiasis. Indian J Pharm Sci. 2013;75(5):585-90.; Dutta et al., 2018Dutta L, Mukherjee B, Chakraborty T, Das MK, Mondal L, Bhattacharya S, Gaonkar RH, Debnath MC. Lipid-based nanocarrier efficiently delivers highly water soluble drug across the blood-brain barrier into brain. Drug Deliver. 2018;25(1):504-16.).

Attenuated total reflection Fourier transform infrared spectroscopy (ATR-FTIR)

ATR-FTIR studies were performed using attenuated total reflectance (ATR) mode on a Bruker Vertex 70 (Bruker Daltonik GmbH, Germany) spectrometer equipped with a platinum ATR, Bruker Diamond Type A225/Q to identify the compatibility of FLZ with excipients. The spectrum of FLZ, SA, tween 20 (TW), castor oil (CO), physical mixture of SA and FLZ (SFLZ), physical mixture of SA, CO and FLZ (SCFLZ) and SA, CO, TW and FLZ (SCTFLZ) were recorded in the range of 4000-600 cm-1 at a resolution speed to 8 cm-1. All the physical mixtures before ATR-FTIR studies were stored at 40 ºC for 15 days and after the specified time the samples were analysed with ATR-FTIR spectrophotometer. The obtained results were compared with FLZ, SA, CO and TW results to confirm the compatibility (Ewing et al., 2015Ewing AV, Wray PS, Clarke GS, Kazarian SG. Evaluating drug delivery with salt formation: Drug disproportionation studied in situ by ATR-FTIR imaging and Ramam mapping. J Pharm Biomed Anal. 2015;111:248-56.; Ledeţi et al., 2015Ledeţi I, Vlase G, Vlase T, Şuta LM, Todea A, Fuliaş A. Selection of solid-state excipients for simvastatin dosage forms through thermal and nonthermal techniques. J Therm Anal Calorim. 2015;121(3):1093-1102.).

Preparation of fluconazole nanostructured lipid carriers (NLCs)

FLZ loaded NLCs were prepared by using constant temperature ultrasonication emulsion technique (Sharma et al., 2009Sharma P, Ganta S, Denny WA, Garg S. Formulation and pharmacokinetics of lipid nanoparticles of a chemically sensitive nitrogen mustard derivative: Chlorambucil. Int J Pharm. 2009;367(1-2):187-194.; Kumar et al., 2016Kumar L, Reddy MS, Verma R, Koteshwara KB. Selection of cryoprotective agent for freeze drying of valsartan solid lipid nanoparticles. Latin Am J Pharm. 2016;35(2):284-90.). All the ingredients were weighed accurately. The aqueous phase and the lipid phase were prepared separately. The lipid phase was containing SA (200 mg or 300 mg) as solid lipid, castor oil (20 µL) as liquid lipid and FLZ (50 mg) whereas aqueous phase was containing surfactant (tween 20) in a sufficient quantity (10 mL) of milli Q water. A constant temperature was maintained at 10 ºC above the actual melting point of solid lipid.

Aqueous phase (10 mL) was taken into a glass beaker (25 mL) which contains tween 20 (2% v/v or 3% v/v). The temperature of aqueous phase was adjusted equivalent to the temperature of lipid phase. Then the aqueous phase was added to the lipid phase and immediately sonicated using a probe sonicator (Ultrasonic Processor VC130, Sonics and Materials Inc., USA) with an amplitude of 21 ± 2 W or 27 ± 2 W, pulses were maintained to 10 sec and the sonication was carried for 10 min (Kumar et al., 2016Kumar L, Reddy MS, Verma R, Koteshwara KB. Selection of cryoprotective agent for freeze drying of valsartan solid lipid nanoparticles. Latin Am J Pharm. 2016;35(2):284-90.).

Design and optimization of NLCs

Two levels and three factors full factorial design was opted in the present study using Design Expert® v.9.0.5.1 software.

For NLCs, amount of solid lipid (stearic acid), surfactant concentration (tween 20) and sonication amplitude were considered as variables whereas particle size, polydispersity index and zeta potential were considered as responses. The levels of these variables are reported in Table III. On the basis of these levels and factors, software has suggested eight runs to be performed as reported in Table VI. The number of runs were performed and the responses were entered into the software.

TABLE III
Levels and variables of NLCs
TABLE IV
Fourier transform infrared spectroscopy studies of FLZ, SA and physical mixture
TABLE V
Attenuated total reflection Fourier transform infrared spectroscopy studies of FLZ, SA and physical mixtures
TABLE VI
Formulation design with variables and responses of FLZ-NLCs

Particle size, polydispersity index and zeta potential

The particle size analysis of FLZ-NLCs formulations was performed using a Zetasizer (ZEN 3600, Malvern Instruments, Malvern, U.K.) which works on the principle of photon correlation spectroscopy (PCS). The PCS provides mean particle size so referred as z-average of the nanoformulations as well as the polydispersity index (PDI), which measures the width of the distribution. The particles size, polydispersity index and zeta potential was determined by diluting the formulations up to 50 fold with milli Q (Garud, Singh, Garud, 2012Garud A, Singh D, Garud N. Solid lipid nanoparticles (SLN): Method, characterization and applications - Review. Int Curr Pharm J. 2012;1(11):384-93.; Kumar et al., 2016Kumar L, Reddy MS, Verma R, Koteshwara KB. Selection of cryoprotective agent for freeze drying of valsartan solid lipid nanoparticles. Latin Am J Pharm. 2016;35(2):284-90.; Srinivas et al., 2017Srinivas NSK, Verma R, Kulyadi GP, Kumar L. A quality by design approach on polymeric nanocarrier delivery of gefitinib: formulation, in vitro and in vivo characterization. Int J Nanomed. 2017;12:15-28.).

Drug content (DC) and entrapment efficiency (EE) of NLCs

For total drug content in FLZ-NLCs formulation, 0.2 mL of the formulation and placebo NLCs were taken in two different microcentrifuge tubes and diluted with 0.8 mL of methanol which was centrifuged using cooling centrifuge (Sigma Laborzentrifugen GmbH, 3K30, Germany) at 54,200 g for 30 min at 4 ºC. The supernatant was collected and filtered using a syringe filter (0.22 µ). The absorbance of filtrate was measured using placebo NLCs formulation as a blank at 261 nm after 10 times dilution by using UV-Spectrophotometer (UV-1601PC, Shimadzu Corporation, Kyoto). The drug content (DC) of FLZ-NLCs was calculated using the formula given below:

Percent drug content % = Actual Drug Content mg Theoretical Drug Content mg × 100

For presence of free drug in FLZ-NLCs formulation, 0.5 mL of the formulation and placebo NLCs were taken in two different microcentrifuge tubes and diluted with 0.5 mL of milli Q water which was centrifuged using cooling centrifuge (Sigma Laborzentrifugen GmbH, 3K30, Germany) at 54,200 g for 30 min at 4 ºC. The supernatant was collected and filtered using a syringe filter (0.22 µ). The absorbance of filtrate was measured at 261 nm by using UV - Spectrophotometer (UV-1601PC, Shimadzu Corporation, Kyoto) (Pardeike et al., 2011Pardeike J, Weber S, Haber T, Wagner J, Zarfl HP, Plank H, Zimmer A. Development of an itraconazole-loaded nanostructured lipid carrier (NLC) formulation for pulmonary application. Int J Pharm. 2011;419(1-2):329-38.). The entrapment efficiency (EE) of FLZ-NLCs was calculated using the formula:

Percent drug entrapment % = Total Drug Content mg Free Drug mg Total Drug Content mg × 100

In vitro release study

In vitro drug release study FLZ-NLCs was performed in phosphate buffer pH 7.4. The study was carried out in 500 mL dissolution media using United States Pharmacopoeia (USP) Dissolution Apparatus II (Electrolab TDT-08L with temperature controller Electrolab ETC-11L, Electrolab Dissolution Tester (USP), Electrolab India Pvt. Ltd. Mumbai) by taking NLCs (4 mL) in dialysis bag (molecular cut off 12-14 kDa, HiMedia® Laboratories Pvt. Ltd., Mumbai). Throughout the study, the stirring speed and the temperature were maintained at 50 rpm and 37 ± 0.5 ºC, respectively. Sink conditions were maintained by collecting 2 mL samples and replacing with the same volume of fresh dissolution media at pre-decided time intervals (i.e., 0, 0.5, 1, 2, 3, 4, 8, 12, 24, 36, 48 and 72 h). The collected samples were passed through 0.22 µ membrane filter and absorbance was measured at 261 nm (Srinivas et al., 2017Srinivas NSK, Verma R, Kulyadi GP, Kumar L. A quality by design approach on polymeric nanocarrier delivery of gefitinib: formulation, in vitro and in vivo characterization. Int J Nanomed. 2017;12:15-28.).

RESULTS AND DISCUSSION

Selection of lipids, surfactants and method for the preparation of NLCs

Screening of solid lipids and liquid lipids

Solubility of FLZ was observed in SA and GMS. The highest solubility of FLZ was found in SA as depicted in Figure 1A. These results are also supported by the earlier research on FLZ (Moazeni et al., 2016Moazeni M, Kelidari HR, Saeedi M, Morteza-Semnani K, Nabili M, Gohar AA, Akbari J, Lotfali E, Nokhodchi A. Time to overcome fluconazole resistant Candida isolates: Solid lipid nanoparticles as a novel antifungal drug delivery system. Colloid Surf B Biointerfaces. 2016;142:400-7.; Kelidari et al., 2017Kelidari HR, Moazeni M, Babaei R, Saeedi M, Akbari J, Parkoohi PI, Nabili M, Gohar AA, Morteza-Semnani K, Nokhodchi A. Improved yeast delivery of fluconazole with a nanostructured lipid carrier system. Biomed Pharmacother. 2017;89:83-8.). The criteria for selecting the excipients was also based on its non-irritancy, pharmaceutical acceptance, non-sensitivity towards the skin and bear GRAS status (generally regarded as safe) (Gaba et al., 2015Gaba B, Fazil M, Khan S, Ali A, Baboota S, Ali J. Nanostructured lipid carrier system for topical delivery of terbinafine hydrochloride. Bull Fac Pharmacy, Cairo Univ. 2015;53(2):147-59.). The liquid lipids were physically observed for their homogeneity. FLZ showed a higher solubility in castor oil when compared to olive oil and oleic acid (shown in Figure 1B). On the basis of solubility studies of lipids, SA was selected as solid lipid and CO as the liquid lipid for the preparation of FLZ-NLCs. In this study, 20 µL of CO was taken as it has been reported in the literature if the amount of oil increases in the NLCs then the chances of nanostructuring of NLC reduces as particle size increases (Kovacevic et al., 2011Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.) and the possibility of oil separation also increases at the time of cooling process (Perez, 2005Perez M. Gibbs-Thomson effects in phase transformations. Scripta Mater. 2005;52(8):709-12.).

FIGURE 1
Solubility of FLZ in lipids: (A) solid lipids and (B) liquid lipids (data presented as mean ± SD, n=3).

Screening of surfactants and selection of method for the preparation of NLCs

Surfactants improve the stability of the nanoformulations. Hydrophilic-lipophilic balance (HLB) values are considered as of prime importance in surfactant selection. Surfactants with low HLB values (3 to 6) are oil soluble and those who have high HLB values (8 to 18) are water soluble (Montenegro et al., 2016Montenegro L, Lai F, Offerta A, Sarpietro MG, Micicchè L, Maccioni AM, Valenti D, Fadda AM. From nanoemulsions to nanostructured lipid carriers: A relevant development in dermal delivery of drugs and cosmetics. J Drug Deliver Sci Technol. 2016;32(Part B):100-112.). Several types of surfactant have been used for the preparation of NLCs such as ionic, amphoteric, non-ionic, etc. (Kovacevic et al., 2011Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.). Non-ionic surfactants have low skin toxicity (Kovacevic et al., 2011Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.), exhibit enhanced blood-compatibility (Balakrishnan, James, Jayakrishnan, 2005Balakrishnan B, James NR, Jayakrishnan A. Tween 20-modified poly(vinyl chloride) exhibits enhanced blood-compatability. Polym Int. 2005;54(9):1304-9.) and these can effectively inhibit the in vivo degradation of lipid matrix. Poly(ethylene oxide) chains on the non-ionic surfactants hamper the fastening of lipase/co-lipase complex which is accountable for lipid degradation (Olbrich, Müller, 1999Olbrich C, Müller R. Enzymatic degradation of SLN - effect of surfactant and surfactant mixtures. Int J Pharm 1999;180(1):31-9.; Olbrich, Kayser, Müller, 2002Olbrich C, Kayser O, Müller R. Lipase degradation of Dynasan 114 and 116 solid lipid nanoparticles (SLN) - effect of surfactants, storage time and crystallinity. Int J Pharm. 2002;237(1-2):119-28.; Shah et al., 2015Shah R, Eldridge D, Palombo E, Harding I (editors). Composition and structure. In: Lipid nanoparticles: Production, characterization and stability. Heidelberg: Springer International Publishing; 2015. p. 11-22.). Non-ionic surfactants are also preferred for topical preparations (Kovacevic et al., 2011Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.). In this preparation of FLZ-NLCs, three non-ionic surfactants were studied namely poloxamer 188, tween 80 and tween 20. The HLB value of poloxamer 188 is 29, which is very high in comparison of tween 20 and tween 80. HLB value of tween 80 is lesser than tween 20 that is 15. HLB value of tween 20 is 16.7. Surfactant screening study was carried out to study the effect of these three surfactants on particle size, PDI and zeta potential. The surfactant which reduces the particle size, reduces the PDI value and generates more surface charge is preferred (Kovacevic et al., 2011Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.).

All three surfactants were studied using microemulsion technique (first technique for screening of surfactants) by keeping all other factors constant such as amount of solid lipid, amount of liquid lipid and concentration of surfactant. On the basis of obtained results, poloxamer 188 was eradicated from further study (using second technique such as ultrasonication emulsion technique) as it showed very high particle size compared to tween 20 and tween 80. Tween 80 showed smaller particle size compared to tween 20 and poloxamer 188. But the NLCs prepared using tween 80 showed high PDI value and less zeta potential value.

For further screening study using second technique i.e. ultrasonication emulsion technique, tween 20 and tween 80 were selected. Tween 20 was selected as it showed high zeta potential, small particle size and low PDI with first technique (as presented in Table I) compared to poloxamer 188. Similarly, tween 80 was also preferred over poloxamer 188, as it also showed smaller particle size with first technique (as reported in Table I) compared to tween 20 and poloxamer 188. It has also been reported in the earlier studies that poloxamer 188 produces bigger particle size in comparison of tween 20 and tween 80 that might be due to the high HLB value of poloxamer 188 (Das, Ng, Tan, 2012Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.).

In ultrasonication emulsion technique, instrumental conditions were kept constant (such as sonication time, pulses and sonication amplitude) and the effect of tween 20 and tween 80 on particle size, PDI and zeta potential was studied. As reported in Table II, tween 20 was found to be a suitable surfactant in meeting the requirements of FLZ-NLCs as the particle size was small, PDI value was found to be less and the charge on the surface of particles was also considerable. As reported in the literature, usually the zeta potential value more than 20 or less than - 20 mV is preferable for a physically stable nanoformulation (Das et al., 2012Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.). Similarly, smaller PDI value is preferable (more towards 0 which indicates monodisperse nature of populations) (Das, Ng, Tan, 2012Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.). Most of the investigators prefer PDI values less than 0.3, but less than 0.5 is also acceptable (Kaur et al., 2008Kaur IP, Bhandari R, Bhandari S, Kakkar V. Potential of solid lipid nanoparticles in brain targeting. J Control Rel. 2008;127(2):97-109.; Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.).

Furthermore, the particle size can be reduced with the alteration in the sonication conditions and increase in the surfactant concentration (Silva, et al., 2010Silva R, Ferrira H, Little C, Cavaco-Paulo A. Effect of ultrasound parameters for unilamellar liposome preparation. Ultrasonic Sonochem. 2010;17(3):628-32.; Das, Ng, Tan, 2012Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.; Kumar et al., 2016Kumar L, Reddy MS, Verma R, Koteshwara KB. Selection of cryoprotective agent for freeze drying of valsartan solid lipid nanoparticles. Latin Am J Pharm. 2016;35(2):284-90.). Hence, tween 20 was chosen as the surfactant in formulating FLZ-NLCs and the ultrasonication emulsion method was used for the preparation of nanoparticles as it complied with our requirements.

Drug-excipient compatibility studies

Fourier transform infrared spectroscopy (FTIR)

FTIR spectrum of pure FLZ, SA and physical mixture were recorded in between 4000 to 400 cm-1 wavenumber. The spectra of essential functional groups of FLZ in physical mixture were analysed and compared with the spectra obtained in pure FLZ and SA to confirm the compatibility of FLZ with SA. FTIR spectra of FLZ, SA and physical mixture are reported in Table IV.

As reported in Table IV, the main absorption peaks of FLZ (in FLZ sample) were found at 3111.18 cm-1 (N-H stretching), 2958.80 cm-1 (C-H stretching), 1595.13 cm-1 (C=C), 1510.26 cm-1 (triazole ring stretching), 1247.94 cm-1 (triazole ring stretching), 1139.93 cm-1 (C-F stretching), 1016.86 cm-1 (C-OH stretching), 966.34 cm-1 (O-H stretching and 572.86 cm-1 (β-CF) (Gu and Jiang, 1995Gu and Jian. Characterization of polymeric forms of fluconazole using fourier transform raman spectroscopy. J Pharm Sci. 1995;84(2):1438-41.; Cyr et al., 1996Cyr TD, Dawson BA, Neville GA, Shurvell HF. Spectral characterization of fluconazole. J Pharm Biomed Anal. 1996;14(3):247-55.; Kumar et al., 2013Kumar L, Reddy MS, Shirodkar RK, Pai GK, Krishna VT, Verma R. Preparation and characterization of fluconazole films for the treatment of vaginal candidiasis. Indian J Pharm Sci. 2013;75(5):585-90.). The absorbance peaks of SA (in SA sample) were noticed at 2927.94 cm-1, 2852.72 cm-1 (C-H stretching), 2673.34 cm-1 (O-H stretching), 1707 cm-1 (C=O stretching), 1411.89 cm-1 (C-OH stretching), 1099.43 cm-1 (C-OH stretching) and 941.26 cm-1 (O-H stretching) (Kimura, Umemura, Takenaka, 1986Kimura F, Umemura J, Takenaka T. FTIR-ATR studies on Langmuir-Blodgett films of stearic acid with 1-9 monolayes. Langmuir 1986;2(1):96-101.; Kamata, Umemura, Takenata, 1987Kamata T, Umemura J, Takenaka T. Infrared ATR spectra of stearic acid LB films: Intensity enhancement by Au evaporation. Bull Inst Chem Res Kyoto Univ. 1987;65(4):170-8.; Nair, Pradeep, MacLaren, 2004Nair AS, Pradeep T, MacLaren I. An investigation of the structure of stearate monolayers on Au@ZrO2 and Ag@ZrO2 core-shell nanoparticles. J Mater Chem. 2004;14(5):857-62.). The physical mixture (PM) of FLZ and SA showed absorption peaks at 3111.18 cm-1 (for N-H stretching), 2956.87 cm-1 and 2852.72 cm-1 (for C-H stretching), 1708.93 cm-1 (C=O stretching), 1595.13 cm-1 (C=C), 1510.26 cm-1 (triazole ring stretching), 1423.47 cm-1 (C-OH stretching), 1247.94 cm-1 (triazole ring stretching), 1138 cm-1 (C-F stretching), 101186 cm-1 (for C-OH stretching), 966.34 cm-1 (O-H stretching) and 572.86 cm-1(β-CF). All the important characteristic spectra of FLZ and SA were found in the PM of FLZ and SA which confirms the compatibility of FLZ with SA.

Attenuated total reflection Fourier transform infrared spectroscopy (ATR-FTIR)

ATR-FTIR spectrum of pure FLZ, SA and physical mixture were recorded in between 4000 to 600 cm-1 wavenumber. The essential functional group peaks in physical mixtures [physical mixture of SA and FLZ (SFLZ), physical mixture of SA, CO and FLZ (SCFLZ) and physical mixture of SA, CO, TW and FLZ (SCTFLZ)] were analysed and compared with the spectra obtained in the pure FLZ, SA, tween 20 (TW), castor oil (CO) to confirm the compatibility of FLZ with excipients used to develop the formulation. FTIR spectra of FLZ, SA and physical mixtures are reported in Table V.

In FLZ, the triazole group was confirmed with the presence of C-H stretching mode at 3105.00 cm-1 which was also found in the SFLZ, SCFLZ and SCTFLZ at 3116.05 cm-1, 3118.05 cm-1 and 3117.78 cm-1, respectively. Furthermore, the presence of triazole ring in FLZ was confirmed with the presence of absorbance peaks at 1502.33 cm-1 and 1246.47 cm-1. The absorbance bands were further confirmed in SFLZ with the absorbance bands at 1514.48 cm-1 and 1250.27 cm-1. These absorbance bands were also present in SCFLZ at 1514.47 cm-1 and 1250.82 cm-1. The same absorbance bands were also found in SCTFLZ at 1513.84 cm-1 and 1250.07 cm-1. In fluconazole structure, 2,4 - Difluorobenzyl group is also present which showed its absorbance band for C-F stretching at 1274.31 cm-1 in pure FLZ sample; and at 1270.68 cm-1, 1269.84 cm-1 and 1270.98 cm-1 in SFLZ, SCFLZ and SCTFLZ, respectively. The absorbance bands of C=C stretching were present at 1616.77 cm-1, 1616.55 cm-1, 1616.59 cm-1 and 1616.93 cm-1 in pure FLZ, SFLZ, SCFLZ and SCTFLZ, respectively. These absorbance bands of C=C stretching confirmed the presence of aromatic ring of FLZ in all the samples. The presence of hydroxyl group of FLZ was also found in the pure FLZ, SFLZ, SCFLZ and SCTFLZ as C-OH stretching at absorbance bands 1016.86 cm-1, 1011.61 cm-1, 1010.57 cm-1 and 1011.19 cm-1, respectively. These results of IR confirms the compatibility of FLZ with the used excipients (Gu and Jiang, 1995Gu and Jian. Characterization of polymeric forms of fluconazole using fourier transform raman spectroscopy. J Pharm Sci. 1995;84(2):1438-41.; Cyr et al., 1996Cyr TD, Dawson BA, Neville GA, Shurvell HF. Spectral characterization of fluconazole. J Pharm Biomed Anal. 1996;14(3):247-55.; Kumar et al., 2013Kumar L, Reddy MS, Shirodkar RK, Pai GK, Krishna VT, Verma R. Preparation and characterization of fluconazole films for the treatment of vaginal candidiasis. Indian J Pharm Sci. 2013;75(5):585-90.).

The presence of SA in the samples was inveterate with the important absorption peaks of C-H stretching at two places. One of C-H asymmetric stretching at absorbance bands 2914.20 cm-1, 2914.81 cm-1, 2916.09 cm-1 and 2918.13 cm-1, in pure SA, SFLZ, SCFLZ and SCTFLZ, respectively. Second of C-H symmetric stretching at absorbance bands 2847.17 cm-1, 2847.54 cm-1, 2849.02 cm-1 and 2852.11 cm-1, in pure SA, SFLZ, SCFLZ and SCTFLZ, respectively. The C=O stretching absorbance band of hydrogen bonded dimer was appeared at 1696.36 cm-1, 1698.97 cm-1, 1701.78 cm-1 and 1703.78 cm-1 in pure SA, SFLZ, SCFLZ and SCTFLZ, respectively (Kimura et al., 1986Kimura F, Umemura J, Takenaka T. FTIR-ATR studies on Langmuir-Blodgett films of stearic acid with 1-9 monolayes. Langmuir 1986;2(1):96-101.; Kamata, Umemura, Takenata, 1987Kamata T, Umemura J, Takenaka T. Infrared ATR spectra of stearic acid LB films: Intensity enhancement by Au evaporation. Bull Inst Chem Res Kyoto Univ. 1987;65(4):170-8.; Nair, Pradeep, MacLaren, 2004Nair AS, Pradeep T, MacLaren I. An investigation of the structure of stearate monolayers on Au@ZrO2 and Ag@ZrO2 core-shell nanoparticles. J Mater Chem. 2004;14(5):857-62.).

The presence of CO in the samples was confirmed with the two absorbance bands. One of -C-H- stretching at absorbance bands 2924.61 cm-1, 2916.09 cm-1 and 2918.13 cm-1 in pure CO, SCFLZ and SCTFLZ, respectively. Second of -C=O stretching for the presence of methyl ricinoleate at absorbance bands 1742.80 cm-1, 1744.21 cm-1 and 1740.24 cm-1 in pure CO, SCFLZ and SCTFLZ, respectively (Zamiri et al., 2011Zamiri R, Zakaria A, Abbastabar H, Darroudi M, Husin MS, Mahdi MA. Laser-fabricated castor oil-capped solver nanoparticles. Int J Nanomed. 2011;6:565-8.; Narwal et al., 2015Narwal SK, Saun NK, Dogra P, Chauhan G, Gupta R. Production and characterization of biodiesel using nonedible castor oil immobilized lipase from Bacillus aerius. BioMed Res Int. 2015;2015:281934.).

The presence of TW in the samples was inveterate with the absorbance bands for -OH stretching at 3481.98 cm-1 and 3442.62 cm-1 in pure TW and SCTFLZ, respectively. Three more absorbance bands in pure TW was recoded at 2921.68 cm-1, 2861.48 cm-1 and 1734.66 cm-1 which confirms the presence of C-H asymmetric stretching, C-H symmetric stretching and -C=O stretching, respectively (Balakrishnan, James, Jayakrishnan, 2005Balakrishnan B, James NR, Jayakrishnan A. Tween 20-modified poly(vinyl chloride) exhibits enhanced blood-compatability. Polym Int. 2005;54(9):1304-9.). These three peaks were slightly shifted and overtone in physical mixtures with the same functional groups peak in lipids as the same functional groups are present in the used lipids (Balakrishnan, James, Jayakrishnan, 2005Balakrishnan B, James NR, Jayakrishnan A. Tween 20-modified poly(vinyl chloride) exhibits enhanced blood-compatability. Polym Int. 2005;54(9):1304-9.).

The ATR-FTIR study confirmed the compatibility of FLZ with excipients used for the formulation development.

Optimization and characterisation of NLCs

Full factorial design was used for the optimization of NLCs. Two level full factorial design (23) have suggested total of eight batches of formulation. The software suggested formulation batches were performed and collected responses (particle size, PDI and zeta potential) were put into the software. The obtained responses for the eight formulation batches are recorded in Table VI.

Particle size, PDI and zeta potential

The particle size, PDI and zeta potential of FLZ-NLCs were found to be in the range of 259.50 to 418.00 nm, 0.165 to 0.475 and - 21.00 to - 14.30 mV, respectively. The maximum particle size of FLZ-NLCs was found to be 418.00 nm which is parallel in the line of lipid nanoparticles prepared using stearic acid and tween 20 in the earlier research (Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.). The PDI values of all the formulations were found to be less than 0.5 which is considered to be appropriate and results indicates the homogeneous distribution of prepared FLZ-NLCs (Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.; Wolf et al., 2017Wolf M, Klang V, Halper M, Stix C, Heuser T, Kotisch H, Valenta C. Monoacyl-phosphotidylcholine nanostructured lipid carriers: Influence of lipid and surfactant content on in vitro skin permeation of flufenamic acid and fluconazole. J Drug Deliver Sci Technol. 2017;41:419-30.). The zeta potential values were also found to be in the similar range of the SLNs prepared earlier using stearic acid and tween 20 by the other investigates (Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.).

As depicted in Figure 2X, particle size was found to be decreased with increase of sonication amplitude. These results are also supported by the earlier findings (Silva et al., 2010Silva R, Ferrira H, Little C, Cavaco-Paulo A. Effect of ultrasound parameters for unilamellar liposome preparation. Ultrasonic Sonochem. 2010;17(3):628-32.; Das, Ng, Tan, 2012Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.). Surfactant concentration had shown positive effect on the particle size i.e., increase in the concentration of tween 20 there was increase in particle size. This may be due to the several reasons. First reason may be the viscosity of the dispersion medium. The increase in viscosity of the dispersion medium by increase in the concentration of tween 20 which may form rigid layer at the surface of particles and may increase the particle size (Elfiyani, Amalia, Pratana, 2017Elfiyani R, Amalia A, Pratama SY. Effect of using the combination of tween 80 and ethanol on the forming and physical stability of microemulsion of eucalyptus oil as antibacterial. J Young Pharm. 2017;9(1):S1-4.). Second reason may be tween 20 is acting as amphiphilic molecules which are deposited at the surface of particles resulting in increment of particle size (Asasutjarit et al., 2007Asasutjarit R, Lorenzen SI, Sirivichayakul S, Ruxrungtham K, Ruktanonchai U, Ritthidej GC. Effect of solid lipid nanoparticles formulation compositions on their size, zeta potential and potential for in vitro pHIS-HIV-Hugag transfection. Pharm Res. 2007;24(6):1098-107.; Asasutjarit et al., 2013Asasutjarit R, Sorrachaitawatwong C, Tipchuwong N, Pouthai S. Effect of formulation compositions on particle size and zeta potential of diclofenac sodium-loaded chitosan nanoparticles. Int Schol Scient Res Innov. 2013;7(9):568-570.). Amount of solid lipid did not show any effect on the particle size. Furthermore, the effect of variables on particle size was studied using the eq 1.

(1) Particle Size = 368 . 26 + 15 . 59 B 28 . 91 C + 13 . 41 AB 8 . 89 AC + 22 . 96 BC + 18 . 49 ABC

FIGURE 2
Perturbation plots represents the effect of variables on responses: (X) Effect of variables on particle size; (Y) Effect of variables on PDI; (C) Effect of variables on zeta potential.

where, A, B and C are the coded factors for the amount of solid lipid, concentration of tween 20 and sonication amplitude.

Although, the effect of amount of solid lipid was not found on the particle size, but with other variables such as concentration of tween 20 and sonication amplitude it also revealed some interactive effect on the particle size. As shown in eq. 1, amount of solid lipid and concentration of tween 20 collectively presented positive effect (means increase of particle size) on the particle size which may be due to the main effect of surfactant concentration on particle size. Similarly, amount of solid lipid and sonication amplitude collectively revealed negative effect (means reduced particle size) on particle size which again may be due to sonication amplitude only.

As reported in Table VII, the regression coefficient (r2) of equation (1) was found to be 0.999 which confirmed the strong relation between the variables and responses. The F value of linear model for the particle size was found to be 1400.340. All the variables and selected model were found to be significant (p < 0.05) for particle size as stated by ANOVA. The variables B, C, AB, AC, BC and ABC were found to be significant (p < 0.05) with the p-values 0.021, 0.011, 0.024, 0.037, 0.014 and 0.018, respectively. The signal to noise ratio was estimated with the adeq precision value and which was also found to be good with the value 116.89.

TABLE VII
Results of coefficient estimate and regression analysis of variance (ANOVA)

As illustrated in Figure 2Y, PDI value found to be increased with increase of amount of solid lipid, concentration of tween 20 and sonication amplitude. The amount of solid lipid exhibited very least effect on PDI and concentration of tween 20 indicated highest effect on PDI compared to the sonication amplitude. An increase in PDI value with increased concentration of tween 20 was found. This may be due to the non-uniform thickness of surfactant layers on the surface of particles which affects the shape of particles. Sonication amplitude also showed some positive effect on PDI (increase of PDI values) that may be due to the uneven shape of particles. Furthermore the effect of variables on PDI was studied using the eq 2.

(2) PDI = 0 . 27 + 0 . 014 A + 0 . 048 B + 0 . 027 C + 0 . 072 AC + 0 . 058 ABC

where, A, B and C are the coded factors for the amount of solid lipid, concentration of tween 20 and sonication amplitude.

As presented in Table VII, the regression coefficient (r2) of equation (2) was found to be 0.994 which also confirmed the strong relation between the variables and responses. The F value of linear model for PDI was found to be 64.100. Few variables such as B, C and ABC; and selected model were found to be significant (p < 0.05) for PDI as stated by ANOVA. The variables B, C and ABC were found to be significant (p < 0.05) with the p-values 0.016, 0.047 and 0.011, respectively. The variable A was found to be non-significant (p > 0.05) whereas interactive variable AB was found to be significant (p < 0.01) with p-value 0.007. The signal to noise ratio was estimated with the adeq precision value and which was also found to be good with the value 21.11.

As presented in Figure 2Z, amount of solid lipid, concentration of tween 20 and sonication amplitude does not have any direct effect on zeta potential which was further confirmed using the eq 3. These results were found in the parallel line of SLNs prepared using stearic acid and tween 20 by other researchers (Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.). Preferably the prepared FLZ-NLCs are covered by non-ionic surfactant (tween 20). It has been reported that if the lipid nanoparticles are covered by non-ionic surfactant may remain stable even having low zeta potential values (Martins et al., 2012Martins S, Tho I, Souto E, Ferreira D, Brandl M. Multivariate design for the evaluation of lipid and surfactant composition effect for optimisation of lipid nanoparticles. Eur J Pharm Sci. 2012;45(5):613-23.; Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.). The stability of such type of particles were due to stearic stabilization rather than due to the electrostatic stabilization. The covering of particles with non-ionic surfactants decreases the mobility of the lipid nanoparticles and leading to lower the zeta potential values (Santander-Ortega et al., 2006Satander-Ortega MJ, Jódar-Reyes AB, Csaba N, Bastos-González D, Ortega-Vinuesa JL. Colloidal stability of luronic F68-coated PLGA nanoparticles: A variety of stabilisation mechanisms. J Colloid Interfac Sci. 2006;302(2):522-9.; Martins et al., 2012Martins S, Tho I, Souto E, Ferreira D, Brandl M. Multivariate design for the evaluation of lipid and surfactant composition effect for optimisation of lipid nanoparticles. Eur J Pharm Sci. 2012;45(5):613-23.; Shah et al., 2014Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.).

(3) Zeta potential = 17 . 03 0 . 40 AB 0 . 65 AC 1 . 13 BC 1 . 50 ABC

where A, B and C are the coded factors for the amount of solid lipid, concentration of tween 20 and sonication amplitude.

As shown in Table VII, the regression coefficient (r2) of equation (3) was found to be 0.963 which also confirmed the strong correlation between the variables and responses. The F value of linear model for the zeta potential was found to be 12.73. The variables (A, B and C) does not showed any effect. Variables AC, BC and selected model were found to be significant (p < 0.05) for zeta potential as stated by ANOVA. The variable ABC was found to be significant (p < 0.01) with the p-values 0.007 whereas variable AB was found to be non-significant. The adeq precision value was also estimated to know signal to noise ratio and was also found to be good with the value 12.73.

Validation of optimized NLCs

With the help of ANOVA, regression analysis, perturbation and surface response plots, the effect of variables on the responses was studied. The optimization criteria for FLZ-NLCs was set in the DoE software. On the basis of high desirability value (0.970) a software suggested formulation composition was selected for further studies. The software suggested FLZ-NLCs formulation was performed and the responses were recorded. The practically obtained responses were compared with the software predicted responses. On the basis of practically obtained and software predicted responses, the residual values were calculated (as shown in Table VIII).

TABLE VIII
Software suggest‑ed and practically obtained results of FLZ-NLCs composition with desirability value

Minimal errors were found in the obtained results which may be due to the trivial changes in the composition used for the preparation of FLZ-NLCs.

Drug content (DC) and entrapment efficiency (EE) of NLCs

Drug content and entrapment efficiency of an optimized FLZ-NLCs nanoformulation were found to be 102.97 ± 7.45% and 87.00 ± 0.59%, respectively. There is a high entrapment efficiency owing to the solid lipid matrix enclosing the liquid lipid in which the drug solubility is higher which ultimately increases the entrapment efficiency. The chosen lipids are mainly responsible in enhancing the drug loading capacity as they create imperfections in a highly ordered crystal matrix so that there is enough space for a large amount of drug to fit in productively (Müller, Mäder, Gohla, 2000Müller RH, Mäder K, Gohla S. Solid lipid nanoparticles (SLN) for controlled drug delivery: a review of the state of the art. Eur J Pharm Biopharm. 2000;50(1):161-77.; Jose et al., 2014Jose S, Anju SS, Cinu TA, Aleykutty NA, Thomas S, Souto EB. In vivo pharmacokinetics and biodistribution of resveratrol-loaded solid lipid nanoparticles for brain delivery. Int J Pharm. 2014;474(1-2):6-13.).

In vitro drug release study of NLCs

Drug release study of optimized NLCs was performed in phosphate buffer pH 7.4. The optimized FLZ-NLCs formulation was subjected to the drug release media for 72 h. The study was performed in triplicates. The release profile of FLZ-NLCs is shown in Figure 3.

FIGURE 3
In vitro drug release profile of optimised FLZ-NLCs in phosphate buffer pH 7.4 (data presented as mean ± SD, n=3).

Abbreviation: SD, standard deviation.


Initially there was a rapid release of FLZ from NLCs (20.30 ± 2.08% in first 2 h) and then later the release got retarded. The initial rapid release may be due to the presence of some amount of drug on the surface of the prepared NLCs and then the drug release corresponded to the core of the solid lipid in NLCs. The optimized FLZ-NLCs showed release of 37.34 ± 2.08% over a period of 72 h.

CONCLUSION

In the present study, FLZ loaded NLCs were successfully prepared using ultrasonication emulsion technique by using stearic acid as the solid lipid, castor oil as the liquid lipid and tween 20 as an emulsifier. The NLCs formulation was optimized by applying DoE, and the data was analysed using Design Expert® v.9.0.5.1 software. The particle size, polydispersity index and zeta potential of an optimized FLZ-NLCs was found to be 359.15 ± 9.83 nm, 0.236 ± 0.01 and -19.25 ± 0.35 mV, respectively. The drug content of optimized NLCs was found to be 102.97 ± 7.45% and encapsulation efficiency was found to be 87 ± 0.59%. In vitro drug release studies of FLZ-NLCs showed 37.34 ± 2.08% drug release over a period of 72 h. The above obtained results projected that the prepared FLZ-NLCs may be useful for the treatment of fungal infections.

ACKNOWLEDGEMENTS

Authors are thankful to Ipca Laboratories, Mumbai, India for providing drug as a gift sample. Authors are grateful to Signet Chemical Corporation Pvt. Ltd., Mumbai for providing poloxamer 188 as a gift sample. Authors also acknowledge the support of Manipal Academy of Higher Education (MAHE), Manipal, Karnataka, India for providing infrastructural facilities.

REFERENCES

  • Ameen M. Epidemiology of superficial fungal infections. Clin Dermatol. 2010;28(2):197-201.
  • Asasutjarit R, Lorenzen SI, Sirivichayakul S, Ruxrungtham K, Ruktanonchai U, Ritthidej GC. Effect of solid lipid nanoparticles formulation compositions on their size, zeta potential and potential for in vitro pHIS-HIV-Hugag transfection. Pharm Res. 2007;24(6):1098-107.
  • Asasutjarit R, Sorrachaitawatwong C, Tipchuwong N, Pouthai S. Effect of formulation compositions on particle size and zeta potential of diclofenac sodium-loaded chitosan nanoparticles. Int Schol Scient Res Innov. 2013;7(9):568-570.
  • Balakrishnan B, James NR, Jayakrishnan A. Tween 20-modified poly(vinyl chloride) exhibits enhanced blood-compatability. Polym Int. 2005;54(9):1304-9.
  • Behtash A, Nafisi S, Maibach HI. New generation of fluconazole: A review on existing researchers and technologies. Curr Drug Deliv. 2017;14(1):2-15.
  • Cyr TD, Dawson BA, Neville GA, Shurvell HF. Spectral characterization of fluconazole. J Pharm Biomed Anal. 1996;14(3):247-55.
  • Das S, Ng WK, Tan RBH. Are nanostructured lipid carriers (NLCs) better than solid lipid nanoparticles (SLNs): Development, characterizations and comparative evaluations of clotrimazole-loaded SLNs and NLCs? Eur J Pharm Sci. 2012;47(1):139-51.
  • Dutta L, Mukherjee B, Chakraborty T, Das MK, Mondal L, Bhattacharya S, Gaonkar RH, Debnath MC. Lipid-based nanocarrier efficiently delivers highly water soluble drug across the blood-brain barrier into brain. Drug Deliver. 2018;25(1):504-16.
  • Elfiyani R, Amalia A, Pratama SY. Effect of using the combination of tween 80 and ethanol on the forming and physical stability of microemulsion of eucalyptus oil as antibacterial. J Young Pharm. 2017;9(1):S1-4.
  • Ewing AV, Wray PS, Clarke GS, Kazarian SG. Evaluating drug delivery with salt formation: Drug disproportionation studied in situ by ATR-FTIR imaging and Ramam mapping. J Pharm Biomed Anal. 2015;111:248-56.
  • Fluconazole. 2017. Drug Bank. [Accessed on April 04, 2017]. Available from: https://www.drugbank.ca/drugs/DB00196
    » https://www.drugbank.ca/drugs/DB00196
  • Gaba B, Fazil M, Khan S, Ali A, Baboota S, Ali J. Nanostructured lipid carrier system for topical delivery of terbinafine hydrochloride. Bull Fac Pharmacy, Cairo Univ. 2015;53(2):147-59.
  • Gaikwad VL, Yadav VD, Dhavale RP, Choudhari PB, Jadhav SD. Effect of carbopol 934 and 940 on fluconazole release from topical gel formulation: A factorial approach. Current Pharma Research. 2012;2(2):487-93.
  • Garud A, Singh D, Garud N. Solid lipid nanoparticles (SLN): Method, characterization and applications - Review. Int Curr Pharm J. 2012;1(11):384-93.
  • Gu and Jian. Characterization of polymeric forms of fluconazole using fourier transform raman spectroscopy. J Pharm Sci. 1995;84(2):1438-41.
  • Güngör S, Erdal MS, Aksu B. New formulation strategies in topical antifungal therapy. J Cosmet Dermatol Sci Appl. 2013;3(1A):56-65.
  • Gupta M, Vyas SP. Development, characterization and in vivo assessment of effective lipidic nanoparticles for dermal delivery of fluconazole against cutaneous candidiasis. Chem Phys Lipids. 2012;165(4):454-61.
  • Havlickova B, Czaika VA, Friedrich M. Epidemiological trends in skin mycoses worldwide. Mycoses. 2008;51(Suppl 4):2-15.
  • Helal DA, Abd El-Rhman D, Abdel-Halim SA, El-Nabarawi MA. Formulation and evaluation of fluconazole topical gel. Int J Pharm Pharm Sci. 2012;4(Suppl 5):176-83.
  • Jose S, Anju SS, Cinu TA, Aleykutty NA, Thomas S, Souto EB. In vivo pharmacokinetics and biodistribution of resveratrol-loaded solid lipid nanoparticles for brain delivery. Int J Pharm. 2014;474(1-2):6-13.
  • Kamata T, Umemura J, Takenaka T. Infrared ATR spectra of stearic acid LB films: Intensity enhancement by Au evaporation. Bull Inst Chem Res Kyoto Univ. 1987;65(4):170-8.
  • Kaur IP, Bhandari R, Bhandari S, Kakkar V. Potential of solid lipid nanoparticles in brain targeting. J Control Rel. 2008;127(2):97-109.
  • Kelidari HR, Moazeni M, Babaei R, Saeedi M, Akbari J, Parkoohi PI, Nabili M, Gohar AA, Morteza-Semnani K, Nokhodchi A. Improved yeast delivery of fluconazole with a nanostructured lipid carrier system. Biomed Pharmacother. 2017;89:83-8.
  • Kimura F, Umemura J, Takenaka T. FTIR-ATR studies on Langmuir-Blodgett films of stearic acid with 1-9 monolayes. Langmuir 1986;2(1):96-101.
  • Kovacevic A, Savic S, Vuleta G, Müller RH, Keck CM. Polyhydroxy surfactants for the formulation of lipid nanoparticles (SLN and NLC): Effect on size, physical stability and particle matrix structure. Int J Pharm. 2011;406(1-2):163-172.
  • Kumar L, Reddy MS, Shirodkar RK, Pai GK, Krishna VT, Verma R. Preparation and characterization of fluconazole films for the treatment of vaginal candidiasis Indian J Pharm Sci. 2013;75(5):585-90.
  • Kumar L, Reddy MS, Verma R, Koteshwara KB. Selection of cryoprotective agent for freeze drying of valsartan solid lipid nanoparticles. Latin Am J Pharm. 2016;35(2):284-90.
  • Ledeţi I, Vlase G, Vlase T, Şuta LM, Todea A, Fuliaş A. Selection of solid-state excipients for simvastatin dosage forms through thermal and nonthermal techniques. J Therm Anal Calorim. 2015;121(3):1093-1102.
  • Lee CM, Maibach HI. Deep percutaneous penetration into muscles and joints. J Pharm Sci. 2006;95(7):1405-13.
  • Li X, Nie SF, Kong J, Li N, Ju CY, Pan WS. A controlled-release ocular delivery system for ibuprofen based on nanostructured lipid carriers. Int J Pharm. 2008;363(1-2):177-82.
  • Martins S, Tho I, Souto E, Ferreira D, Brandl M. Multivariate design for the evaluation of lipid and surfactant composition effect for optimisation of lipid nanoparticles. Eur J Pharm Sci. 2012;45(5):613-23.
  • Merkus JM. Treatment of vaginal candidiasis: Orally of vaginally? J Am Acad Dermatol. 1990;23(3 Pt 2):568-72.
  • Moazeni M, Kelidari HR, Saeedi M, Morteza-Semnani K, Nabili M, Gohar AA, Akbari J, Lotfali E, Nokhodchi A. Time to overcome fluconazole resistant Candida isolates: Solid lipid nanoparticles as a novel antifungal drug delivery system. Colloid Surf B Biointerfaces. 2016;142:400-7.
  • Montenegro L, Lai F, Offerta A, Sarpietro MG, Micicchè L, Maccioni AM, Valenti D, Fadda AM. From nanoemulsions to nanostructured lipid carriers: A relevant development in dermal delivery of drugs and cosmetics. J Drug Deliver Sci Technol. 2016;32(Part B):100-112.
  • Müller RH, Mäder K, Gohla S. Solid lipid nanoparticles (SLN) for controlled drug delivery: a review of the state of the art. Eur J Pharm Biopharm. 2000;50(1):161-77.
  • Nair AS, Pradeep T, MacLaren I. An investigation of the structure of stearate monolayers on Au@ZrO2 and Ag@ZrO2 core-shell nanoparticles. J Mater Chem. 2004;14(5):857-62.
  • Narwal SK, Saun NK, Dogra P, Chauhan G, Gupta R. Production and characterization of biodiesel using nonedible castor oil immobilized lipase from Bacillus aerius BioMed Res Int. 2015;2015:281934.
  • Olbrich C, Kayser O, Müller R. Lipase degradation of Dynasan 114 and 116 solid lipid nanoparticles (SLN) - effect of surfactants, storage time and crystallinity. Int J Pharm. 2002;237(1-2):119-28.
  • Olbrich C, Müller R. Enzymatic degradation of SLN - effect of surfactant and surfactant mixtures. Int J Pharm 1999;180(1):31-9.
  • Pardeike J, Weber S, Haber T, Wagner J, Zarfl HP, Plank H, Zimmer A. Development of an itraconazole-loaded nanostructured lipid carrier (NLC) formulation for pulmonary application. Int J Pharm. 2011;419(1-2):329-38.
  • Perez M. Gibbs-Thomson effects in phase transformations. Scripta Mater. 2005;52(8):709-12.
  • Saez V, Souza IDL, Mansur CRE. Lipid nanoparticles (SLN & NLC) for delivery of vitamin E: A comprehensive review. Int J Cosmetic Sci. 2018:40(2):103-16.
  • Sanad RA, Abdelmalak NS, Elbayoomy TS, Badawi AA. Formulation of a novel oxybenzone-loaded nanostructured lipid carriers (NLCs). AAPS PharmSciTech. 2010;11(4):1684-94.
  • Satander-Ortega MJ, Jódar-Reyes AB, Csaba N, Bastos-González D, Ortega-Vinuesa JL. Colloidal stability of luronic F68-coated PLGA nanoparticles: A variety of stabilisation mechanisms. J Colloid Interfac Sci. 2006;302(2):522-9.
  • Sawant B, Khan T. Recent advances in delivery of antifungal agents for therapeutic management of candidiasis. Biomed Pharmacotherapy. 2017;96:1478-90.
  • Selvamuthukumar S, Velmurugan R. Nanostructured lipid carriers: a potential drug carrier for cancer chemotherapy. Lipids Health Dis. 2012;11:159.
  • Shah R, Eldridge D, Palombo E, Harding I (editors). Composition and structure. In: Lipid nanoparticles: Production, characterization and stability. Heidelberg: Springer International Publishing; 2015. p. 11-22.
  • Shah R, Eldridge D, Palombo E, Harding I. Optimisation and stability assessment of solid lipid nanoparticles using particle size and zeta potential. J Phys Sci. 2014;25(1):59-75.
  • Sharma P, Ganta S, Denny WA, Garg S. Formulation and pharmacokinetics of lipid nanoparticles of a chemically sensitive nitrogen mustard derivative: Chlorambucil. Int J Pharm. 2009;367(1-2):187-194.
  • Silva R, Ferrira H, Little C, Cavaco-Paulo A. Effect of ultrasound parameters for unilamellar liposome preparation. Ultrasonic Sonochem. 2010;17(3):628-32.
  • Soliman GM. Nanoparticles as safe and effective delivery systems of antifungal agents: Achievements and challenges. Int J Pharm. 2017;523(1):15-32.
  • Souto EB, Wissing SA, Barbosa CM, Müller RH. Development of a controlled release formulation based on SLN and NLC for topical clotrimazole delivery. Int J Pharm. 2004;278(1):71-7.
  • Srinivas NSK, Verma R, Kulyadi GP, Kumar L. A quality by design approach on polymeric nanocarrier delivery of gefitinib: formulation, in vitro and in vivo characterization. Int J Nanomed. 2017;12:15-28.
  • Trombino S, Mellace S, Cassano R. Solid lipid nanoparticles for antifungal drugs delivery for topical applications. Ther Deliv. 2016;7(9):639-47.
  • Wolf M, Klang V, Halper M, Stix C, Heuser T, Kotisch H, Valenta C. Monoacyl-phosphotidylcholine nanostructured lipid carriers: Influence of lipid and surfactant content on in vitro skin permeation of flufenamic acid and fluconazole. J Drug Deliver Sci Technol. 2017;41:419-30.
  • Zamiri R, Zakaria A, Abbastabar H, Darroudi M, Husin MS, Mahdi MA. Laser-fabricated castor oil-capped solver nanoparticles. Int J Nanomed. 2011;6:565-8.

Publication Dates

  • Publication in this collection
    16 Mar 2020
  • Date of issue
    2020

History

  • Received
    26 Jan 2018
  • Accepted
    30 Sept 2018
Universidade de São Paulo, Faculdade de Ciências Farmacêuticas Av. Prof. Lineu Prestes, n. 580, 05508-000 S. Paulo/SP Brasil, Tel.: (55 11) 3091-3824 - São Paulo - SP - Brazil
E-mail: bjps@usp.br