Acessibilidade / Reportar erro

Calcium particle size and feeding time influence egg shell quality in laying hens

ABSTRACT.

An experiment with Leghorn laying hens was undertaken to determine the effect of oyster shell particle size and feeding time on different production variables, calcium retention, plasma calcium content and egg internal and external quality. Two hundred Leghorn layers (40 weeks old old) were allocated in five dietary treatments with four replicates during ten weeks. Two particle size combinations (wherein 50% of calcium substituted by medium or coarse particles (1-2 mm and 2-4 mm respectively) and two feeding time (8-pm or 9-am) were compared against a control diet (100% ground, <1 mm which fed with meal). Egg number, egg production, egg mass and feed conversion ratio did not differ among treatments (p > 0.05). Hens fed diets containing coarse Ca had significantly greater feed intake and calcium content of excreta (p > 0.05), whereas medium particle size reduced feed intake compared to control. Coarse particle size and feeding time at 9-pm significantly increased the calcium content of egg shell, egg shell thickness, egg surface area (ESA) and shell weight per unit surface area (SWUSA) (p < 0.05). Plasma calcium concentration, gizzard digesta calcium content and egg specific gravity were not affected by treatments (p > 0.05). Providing of calcium at 9-pm resulted an increase of egg shell (%), shell weight and thickness (p < 0.05). The results have shown that substitution of fine oyster shell with 50% coarse particles (2-4 mm) and feeding time at 9-pm have better effects on egg shell quality.

Keywords:
calcium retention; feeding time; oyster shell; particle size

Introduction

Calcium (Ca) is a key mineral in laying hens, particularly during the laying period (Araujo et al., 2011Araujo, J. A., Silva, J. H. V., Costa, F. G. P., Sousa, J. M. B., Givisiez, P. E. N., & Sakomura, N. K. (2011). Effect of the levels of calcium and particle size of limestone on laying hens. Revista Brasileira de Zootecnia, 40(5), 997-1005. doi: /10.1590/S1516-35982011000500009.
https://doi.org//10.1590/S1516-359820110...
). Dietary Ca is one of the primary factors affecting egg shell quality and shell strength (William, Horacio, Paulo, Luis, & Marcelo, 2006William, N. S., Horacio, S. R., Paulo, R. S., Luis, F. U., & Marcelo, A. S. (2006). Nutritional requirement of calcium in White laying hens from 46 to 62 Wk of age. International Journal of Poultry Science , 5(2), 181-184. ). Calcium constitutes approximately 1.5% and 40.0% of BW and eggshell weight respectively (Bölükbasi, Çelebi, & Utlu, 2005Bölükbasi, S. C., Çelebi, S., & Utlu, N. (2005). The effects of calcium and vitamin D in diet on plasma calcium and phosphorus, egg shell calcium, and phosphorus levels of laying hens in late laying production period. International Journal of Poultry Science, 4(8), 600-603. ). It is usually supplied as calcium carbonate in the form of limestone or oyster shell, or from other sources, such as marine shells. The Ca availability of these dietary sources is a function of their chemical composition and their capacity to physical bind to other dietary components (McNaughton & Deaton, 1980McNaughton, J. L., & Deaton, J. W. (1980). Effect of calcium source and particle size on calcium utilization. Poultry Science , 59(7), 1568. ).

Sá, Gomes, Albino, Rostagno, and D'Agostini (2004Sá, L. M., Gomes, P. C., Albino, L. F. T., Rostagno, H. S., & D'Agostini, P. (2004). Calcium requirement and bioavailability of some feedstuffs for broiler chicks from 1 to 21 days old. Revista Brasileira de Zootecnia , 33(1), 157-168. ) have determined the relative Ca availability in dicalcium phosphate, calcitic limestone and dolomitic limestone to be 99%, 84%, and 75% respectively. Providing Ca in the form of oyster shell has shown higher digestibility and retention than the calcium carbonate fed as ground limestone (Roland, 1988Roland, S. R. (1988). Research note: egg shell problems: estimates of incidence and economic impact. Poultry Science , 67(12), 1801-1803. doi: 10.3382/ps.0671801.
https://doi.org/10.3382/ps.0671801....
). Particle size of calcium sources in layers’ diets is an important factor affected calcium bioavailability. Acknowledging this importance, the identification of the Ca bioavailability of different sources and also the ideal Ca particle size (generally limestone) in laying hens have been received great interest by researchers for a long time (Araujo et al., 2011Araujo, J. A., Silva, J. H. V., Costa, F. G. P., Sousa, J. M. B., Givisiez, P. E. N., & Sakomura, N. K. (2011). Effect of the levels of calcium and particle size of limestone on laying hens. Revista Brasileira de Zootecnia, 40(5), 997-1005. doi: /10.1590/S1516-35982011000500009.
https://doi.org//10.1590/S1516-359820110...
; De Witt, Kuleile, Van der Merwe, & Fair, 2008De Witt, F. H., Kuleile, N. P., Van der Merwe, H. J., & Fair, M. D. (2008). Influence of limestone particle size on egg production and eggshell quality of layers. World Poultry Science Journal, 64, 411. ; Ekmay & Coon, 2011Ekmay, R. D., & Coon, C. N. (2011). An examination of the P requirements of broiler breeders for performance, progeny quality and P balance 2. Ca particle size. International Journal of Poultry Science , 10(10), 760-765. ; Guinotte & Nys, 1991Guinotte, F., & Nys, Y. (1991). Effects of particle size and origin of calcium sources on eggshell quality and bone mineralization in egg laying hens. Poultry Science , 70(3), 583-592. doi: 10.3382/ps.0700583.
https://doi.org/10.3382/ps.0700583....
; Guo & Kim, 2012Guo, X. Y., & Kim, I. H. (2012). Impacts of limestone multi-particle size on production performance, egg shell quality, and egg quality in laying hens. Asian-Australasian Journal of Animal Sciences, 25(6), 839-844. doi: 10.5713/ajas.2011.11468.
https://doi.org/10.5713/ajas.2011.11468....
; Koreleski & Šwiątkiewicz, 2004Koreleski, J., & Šwiątkiewicz, S. (2004). Calcium from limestone meal and grit in laying hen diets-effect on performance, eggshell and bone. Journal of Animal and Feed Sciences, 13(4), 635-645. ; Lichovnikova, 2007Lichovnikova, M. (2007). The effect of dietary calcium source, concentration and particle size on calcium retention, eggshell quality and overall calcium requirement in laying hens. British Poultry Science , 48(1), 71-75. ; Pavlovski, Vitorović, Lukić, & Spasojević, 2003Pavlovski, Z., Vitorović, D., Lukić, M., & Spasojević, I. (2003). Improving eggshell quality by replacement of pulverised limestone by granular limestone in the hen diet. Acta veterinaria, 53(1), 35-40. ; Pelicia et al., 2011Pelicia, K., Mourao, J. L. M., Garcia, E. A., Pinheiro, V. M. C., Berto, D. A., Molino, A. B., ... Silva, A. P. (2011). Effects of dietary calcium levels and limestone particicle size on the performance, tibia and blood of laying hens. Revista Brasileira de Ciência Avícola, 13(1), 29-34. doi: 10.1590/S1516-635X2011000100005.
https://doi.org/10.1590/S1516-635X201100...
; Saunders-Blades, MacIsaac, Korver, & Anderson, 2009Saunders-Blades, J. L., MacIsaac, J. L., Korver, D. R., & Anderson, D. M. (2009). The effect of calcium source and particle size on the production performance and bone quality of laying hens. Poultry Science , 88(2), 338-353. doi: 10.3382/ps.2008-00278.
https://doi.org/10.3382/ps.2008-00278....
; Skřivan, Marounek, Bubancova, & Podsedníček, 2010Skřivan, M., Marounek, M., Bubancova, I., & Podsedníček, M. (2010). Influence of limestone particle size on performance and egg quality in laying hens aged 24-36 weeks and 56-68 weeks. Animal Feed Science and Technology , 158(1-2), 110-114. doi: 10.1016/j.anifeedsci.2010.03.018.
https://doi.org/10.1016/j.anifeedsci.201...
).

Some researchers have shown that coarse particle size had, generally, a beneficial effect on egg shell quality (Koreleski & Šwiątkiewicz, 2004Koreleski, J., & Šwiątkiewicz, S. (2004). Calcium from limestone meal and grit in laying hen diets-effect on performance, eggshell and bone. Journal of Animal and Feed Sciences, 13(4), 635-645. ; Lichovnikova, 2007Lichovnikova, M. (2007). The effect of dietary calcium source, concentration and particle size on calcium retention, eggshell quality and overall calcium requirement in laying hens. British Poultry Science , 48(1), 71-75. ; Skřivan et al., 2010Skřivan, M., Marounek, M., Bubancova, I., & Podsedníček, M. (2010). Influence of limestone particle size on performance and egg quality in laying hens aged 24-36 weeks and 56-68 weeks. Animal Feed Science and Technology , 158(1-2), 110-114. doi: 10.1016/j.anifeedsci.2010.03.018.
https://doi.org/10.1016/j.anifeedsci.201...
), egg specific gravity (Ekmay & Coon, 2011Ekmay, R. D., & Coon, C. N. (2011). An examination of the P requirements of broiler breeders for performance, progeny quality and P balance 2. Ca particle size. International Journal of Poultry Science , 10(10), 760-765. ), and also bone strength (Guinotte & Nys, 1991Guinotte, F., & Nys, Y. (1991). Effects of particle size and origin of calcium sources on eggshell quality and bone mineralization in egg laying hens. Poultry Science , 70(3), 583-592. doi: 10.3382/ps.0700583.
https://doi.org/10.3382/ps.0700583....
). However, others have reported no effects of large particles of limestone on performance or egg quality, egg shell thickness, egg breaking strength and specific gravity (Keshavarz, 1998Keshavarz, K. (1998). Investigation on the possibility of reducing protein, phosphorus, and calcium requirements of laying hens by manipulation of time of access to these nutrients. Poultry Science , 77(9), 1320-1332. ; Skřivan et al., 2010). Overall, there are inconsistent results of particle size of Ca in laying hens diets. Differences in Ca sources solubility might be responsible for the contradictory findings.

Another strategy to improve eggshell quality is limited feeding or changing the time of feeding during the day (particularly from morning to afternoon) which is used to improve eggshell quality of broiler breeder hens (Bootwalla, Wilson, & Harms, 1983Bootwalla, S. M., Wilson, H. R., & Harms, R. H. (1983). Performance of broiler breeders on different feeding systems. Poultry Science, 62(12), 2321-2325. doi: 10.3382/ps.0622321.
https://doi.org/10.3382/ps.0622321....
; Wilson & Keeling, 1991Wilson, H. R., & Keeling, L. J. (1991). Effect of time of feeding on oviposition time and production parameters in broiler breeders. Poultry Science , 70(2), 254-259. doi: 10.3382/ps.0700254.
https://doi.org/10.3382/ps.0700254....
). Feeding in the late day work through supplying dietary Ca at times that correspond more closely to period of shell deposition, resulted in improved calcium utilization, which is usually manifested as an increased in egg specific gravity, shell quality, shell weight and thickness. However, effects of feeding time on performance are various. Some investigations have shown that afternoon feeding resulted in a higher rate of egg production (Bootwalla et al., 1983Bootwalla, S. M., Wilson, H. R., & Harms, R. H. (1983). Performance of broiler breeders on different feeding systems. Poultry Science, 62(12), 2321-2325. doi: 10.3382/ps.0622321.
https://doi.org/10.3382/ps.0622321....
), whereas others reported no effect (Wilson & Keeling, 1991Wilson, H. R., & Keeling, L. J. (1991). Effect of time of feeding on oviposition time and production parameters in broiler breeders. Poultry Science , 70(2), 254-259. doi: 10.3382/ps.0700254.
https://doi.org/10.3382/ps.0700254....
).

Implementing a good Ca feeding program is a method which permits the hen to adjust calcium intake to its needs. Although numerous studies have been carried out in this area, there are no reports on interaction between oyster shell particle size and time of feeding in laying hens in middle of production period. Considering the importance of obtaining more information on this subject, the objective of this study was to evaluate the effects of feeding time and oyster shell particle size on shell quality and calcium retention in Leghorn laying hens.

Material and methods

Calcium particles and dietary treatments

Dietary treatments consisted of three oyster shell particles sizes namely ground (<1 mm) as control diet which fed with meal; medium (1-2 mm) and coarse (2-4 mm) which fed at morning (8-am) and night (9-pm) for treatments 1,3 and 2,4 respectively. Calcium (7.8 %) was supplied in the form of powder with particle size less than 1 mm in control diet. In other treatments, 50 % of calcium was supplied by oyster shell particle sizes less than 1 mm and the residual (50 %) by particle sizes larger than 1 mm, include 1-2 mm (for first and second treatments) and 2-4 mm (for third and fourth treatments). The particle size of oyster shell was obtained by analysis in sieves shaker. The calculated and chemical composition of diets and in vitro solubility of oyster shell particles are presented in Table 1 and Table 2 respectively.

Experimental design

Trial was set up in a completely randomized factorial design, with five treatments, four replications and ten birds in each. A total of 200 Leghorn layers (40 weeks old) were randomly assigned to five dietary treatments (40 birds/ treatment) with four replicates (10 birds/ replicate) in a 10-wk trial. The hens were housed in a battery cage system (42×40×50 cm). Laying hens were individually reared in one floor adjacent cages which equipped with nipple drinker, and trough. Lights were controlled by time switches according to the recommended hours of lighting as per schedule supplied by the Leghorn breeding company.

Measurements

Feed intake (g/day/laying hen), egg number, egg weight (g), egg production (%) and egg mass were recorded weekly. The FCR was calculated as the amount of feed consumed per unit of BWG.

At the end of weeks 3, 6 and 9 of experiment, four eggs from each replicates were randomly selected for egg shell quality measurement. The shells were washed under slightly flowing water to remove adhering albumen according to Kul and Seker (2004Kul, S., & Seker, I. (2004). Phenotypic correlations between some external and internal egg quality traits in the Japanese quail (Coturnix coturnix japonica). International Journal of Poultry Science , 3(6), 400-405. ) and wiped with a paper towel to remove excessive moisture. A micrometer sensitive in 0.001 mm was used for measuring the eggshell thickness. Variables i.e. egg index (EI), egg specific gravity (ESG), egg surface area (ESA), egg shell weight per unit surface area (SWUSA), and shell ratio (SR) were investigated by following equations:

E I = W L * 100

E S A c m 2 = 3.9782 W 0.7056

S R = S W E W * 100

S W U S A g r c m - 2 = S W E S A

where: EI is egg index; W is egg width; L is egg length; EW is egg weight; EWW is weight of egg weighted in water; ESA is egg surface area; SR is shell ratio; ESG is egg specific gravity; SWUSA is shell weight per unit surface area; and SW is shell weight.

The In vitro solubility of the oyster shell was determined by the method described by Zhang and Coon (1997Zhang, B., & Coon, C. N. (1997). Improved in vitro methods for determining limestone and oyster shell solubility. Journal of Applied Poultry Research, 6(1), 94-99. ). Briefly, a 2.0 (g) oyster shell sample was poured into HCl solution (0.2 N) that was warmed at 42 Cº. After allowing 10 min for reaction, the undissolved limestone was filtered and weighed after drying finally was expressed as the percentage weight loss.

At the end of experiment three birds of each replication selected and a sample of trunk blood were collected quickly (30s) into vials containing 10 mg sodium heparin and placed immediately into an ice bath. The blood samples were centrifuged (in 5000 rpm under refrigeration at 4 ºC) for 15 min; then, the plasma was decanted and assayed in a way where in cresolphthalein complexone was employed as the color reagent and illustrates the Ca content of samples. In order to determining Ca content of gizzard, 2 birds from each replicate have been slaughtered 3 hours after feeding. Calcium content of gizzard content was measured by chromatography method. Excreta samples were taken daily, by plastic plates which have been placed under the cages. Then samples were weighed and a 10% aliquot was stored in a freezer at -10°C until laboratory analysis. The contents of total calcium in excreta were analyzed by spectrophotometer.

Table 1
Diet composition and chemical analysis.
Table 2
In vitro solubility of oyster shell particle size distribution.

Statistical analysis

Two analyses include completely randomized design and repeated measurement were used. Data were analyzed in a 2×2+1 factorial designed by Statistical Analysis System (SAS, 2004Statistical Analysis System [SAS]. (2004). SAS/STAT User guide, Version 9.1.2. Cary, NC: SAS Institute Inc.) and means were tested by Duncan multiple range test. Statements of statistical significance are based on (p < 0.05).

Results

The effects of different particle sizes and feeding time on laying hens performance have shown in Table 3. As shown in the Table 3, feed intake was significantly (p < 0.05) increased by treatment 3 compared to the control. Egg number, egg production, egg mass and feed conversion ratio were not significantly (p > 0.05) influenced by treatments. But egg weight significantly decreased by treatments 1, 2 and 4 in comparison with control (p < 0.05).

Results of egg index, egg specific gravity, egg surface area (ESA) and Shell Weight per Unit Surface Area (SWUSA) have presented in Table 3. No statistical significant differences in egg index and egg specific gravity characteristics were detected. In contrast SWUSA was significantly increased (p < 0.05) by control and treatment 4 (coarse particle size at 9-pm) rather than other treatments.

There was no significant interaction (p > 0.05) between feeding time and oyster shell particle size on the shell weight, shell thickness, calcium concentration of plasma, excreta and gizzard digesta as shown in table 4. Whereas egg shell (%), shell weight and calcium content of excreta were significantly increased by main effects of large particle size (coarse vs medium) (p < 0.05). Also providing of Ca at 9-pm resulted in an increase of egg shell (%), shell weight and thickness (p < 0.05). Unlike egg shell percentage, egg shell weight, Ca concentration of plasma, gizzard digesta and excreta, in the case of egg shell thickness there is a significant increase (p < 0.05) in treatment 4 compared to the control.

Table 3
Effects of treatments on laying hens performance and egg external quality.
Table 4
Effects of feeding program and particle size on calcium concentration in egg shell, plasma, excreta, gizzard digesta at the end of experiment.

Discussion

The results of this study showed that feed intake of hens could significantly (p < 0.05) altered by different feeding treatments. In comparison with control, different feeding time couldn’t affect feed intake. It has been shown that the longer retention time of large particle sizes of calcium in digestive tract, has improved of energy digestibility (Nam, Lee, Joo, Kim, & Kang, 1998Nam, K.-T., Lee, H.-A., Joo, Y.-J., Kim, K.-H., & Kang, C.-W. (1998). Influence of builder's sand on the TME of linseed for poultry. Animal Feed Science and Technology, 72(1-2), 199-201. doi: 10.1016/S0377-8401(97)00176-4.
https://doi.org/10.1016/S0377-8401(97)00...
), and reduce feed intake (Richards, 2003Richards, M. P. (2003). Genetic regulation of feed intake and energy balance in poultry. Poultry Science , 82(6), 907-916. doi: 10.1093/ps/82.6.907.
https://doi.org/10.1093/ps/82.6.907....
). This has justified the lower feed intake in treatments 1 and 2 rather than control. The more fine particles, the more excreting rate, which in turn has affected the feed intake. Lower feed intake in treatment 1 and 2 than control are in agreement with Guo and Kim (2012Guo, X. Y., & Kim, I. H. (2012). Impacts of limestone multi-particle size on production performance, egg shell quality, and egg quality in laying hens. Asian-Australasian Journal of Animal Sciences, 25(6), 839-844. doi: 10.5713/ajas.2011.11468.
https://doi.org/10.5713/ajas.2011.11468....
) who have reported the large particle size and mixture of two particle sizes of limestone have beneficial effects on feed intake, rather than small particles. Also Guinotte and Nys (1991Guinotte, F., & Nys, Y. (1991). Effects of particle size and origin of calcium sources on eggshell quality and bone mineralization in egg laying hens. Poultry Science , 70(3), 583-592. doi: 10.3382/ps.0700583.
https://doi.org/10.3382/ps.0700583....
) have found that calcium carbonate particles in range of 0.15 to 3.35 mm increased the feed intake, which is in agreement with results of treatment 3 and 4 (2-4 mm) in current study. Furthermore, Siegel Yo, Siegel, Guerin, and Picard (1997Yo, T., Siegel, P. B., Guerin, H., & Picard, M. (1997). Self-selection of dietary protein and energy by broilers grown under a tropical climate: effect of feed particle size on the feed choice. Poultry Science , 76(11), 1467-1473. ) have suggested that large particle size in hen rations, resulted in more selectivity and consequently feed intake may be increased.

Neither feeding time (treatments 1 and 3 or 2 and 4 vs control) nor Ca particle size (treatments 1 and 2 or 3 and 4 vs control) could affect egg number, egg production, egg mass and FCR. Results of FCR in this study are in accordance with Ito, Faria, Kuwano, Junqueira, and Araujo (2006Ito, D. T., Faria, D. E., Kuwano, E. A., Junqueira, O. M., & Araujo, L. F. (2006). Effects of dietary calcium fractionation and limestone particle size on the performance and egg quality of commercial laying hens. Acta Scientiarum-Animal Sciences, 28(2), 187-195. ) who also did not observe any difference in feed conversion ratio with different limestone particle sizes.

In current study larger particle size of oyster shell (coarse vs medium) in diet and feeding time (9-pm vs 8-am) improved the calcium content of egg shell which is in agreement with the results reported by Rao and Roland (1989Rao, K. S., & Roland, S.R. (1989). Influence of dietary calcium level and particle size of calcium source on in vivo calcium solubilization by commercial Leghorns. Poultry Science , 68(11), 1499-1505. ). However, Skřivan et al. (2010Skřivan, M., Marounek, M., Bubancova, I., & Podsedníček, M. (2010). Influence of limestone particle size on performance and egg quality in laying hens aged 24-36 weeks and 56-68 weeks. Animal Feed Science and Technology , 158(1-2), 110-114. doi: 10.1016/j.anifeedsci.2010.03.018.
https://doi.org/10.1016/j.anifeedsci.201...
) didn’t observe any effect of particle size.

A slower solubility of sources of Ca would make it available during the time of the eggshell calcification and diminish bone Ca and P mobilization (Skřivan et al., 2010Skřivan, M., Marounek, M., Bubancova, I., & Podsedníček, M. (2010). Influence of limestone particle size on performance and egg quality in laying hens aged 24-36 weeks and 56-68 weeks. Animal Feed Science and Technology , 158(1-2), 110-114. doi: 10.1016/j.anifeedsci.2010.03.018.
https://doi.org/10.1016/j.anifeedsci.201...
), which it could justify improvement in egg shell Ca content by feeding large particle size and nightly in present study. However, Saunders-Blades et al. (2009Saunders-Blades, J. L., MacIsaac, J. L., Korver, D. R., & Anderson, D. M. (2009). The effect of calcium source and particle size on the production performance and bone quality of laying hens. Poultry Science , 88(2), 338-353. doi: 10.3382/ps.2008-00278.
https://doi.org/10.3382/ps.2008-00278....
) concluded that calcium particle size and different sources have no effect on eggshell quality.

Such traits as breaking strength, thickness, pore density, and elasticity accounts for shell quality determinant, which simultaneously are correlated with the egg specific gravity (ESG) (Sooncharenying & Edwards, 1989Sooncharenying, S., & Edwards, H. M. (1989). Modelling the relationships of egg weight, specific gravity, shell calcium and shell thickness. British Poultry Science , 30(3), 623-631. ). Egg surface area (ESA) is one of the shell quality characteristics (Narushin, 2001Narushin, V. G. (2001). What egg parameters predict best its shell strength?. In Proceedings of the IX European Symposium on the Quality of Eggs and Egg Products, Kusadasi, Turkey (p. 349-355).) and egg interior parameters (Narushin & Romanov, 2002Narushin, V. G., & Romanov, M. N. (2002). Egg physical characteristics and hatchability. World's Poultry Science Journal, 58(3), 297-303. ). Egg specific gravity together with ESA and SWUSA may serve as indicators of egg shell and egg internal quality. Neither feeding time nor the Ca particle size could not affect the egg specific gravity in this experiment. The results of the effect of limestone particle size on egg shell quality have similarity with those reported by other researchers (Jardim Filho et al., 2005Jardim Filho, R. M., Stringhini, J. H., Café, M. B., Leandro, N. S. M., Cunha, W. C. P., & Nascimento, J. (2005). The influence of limestone source and particles sizes on performance and eggshell quality of commercial laying hens. Acta Scientiarum-Animal Sciences , 27(1), 35-41. ; Keshavarz, 1998Keshavarz, K. (1998). Investigation on the possibility of reducing protein, phosphorus, and calcium requirements of laying hens by manipulation of time of access to these nutrients. Poultry Science , 77(9), 1320-1332. ; Murata, Santana, Jardim Filho, & Ariki, 2009Murata, L. S., Santana, A. P., Jardim Filho, R. M., & Ariki, J. (2009). Effects of calcium levels and limestone on laying hen performance and egg shell quality. Biotemas, 22(1), 103-110. ; Saunders-Blades et al., 2009Saunders-Blades, J. L., MacIsaac, J. L., Korver, D. R., & Anderson, D. M. (2009). The effect of calcium source and particle size on the production performance and bone quality of laying hens. Poultry Science , 88(2), 338-353. doi: 10.3382/ps.2008-00278.
https://doi.org/10.3382/ps.2008-00278....
; Yo et al., 1997Yo, T., Siegel, P. B., Guerin, H., & Picard, M. (1997). Self-selection of dietary protein and energy by broilers grown under a tropical climate: effect of feed particle size on the feed choice. Poultry Science , 76(11), 1467-1473. ). But, Roland (1988Roland, S. R. (1988). Research note: egg shell problems: estimates of incidence and economic impact. Poultry Science , 67(12), 1801-1803. doi: 10.3382/ps.0671801.
https://doi.org/10.3382/ps.0671801....
) and Guinotte and Nys (1991Guinotte, F., & Nys, Y. (1991). Effects of particle size and origin of calcium sources on eggshell quality and bone mineralization in egg laying hens. Poultry Science , 70(3), 583-592. doi: 10.3382/ps.0700583.
https://doi.org/10.3382/ps.0700583....
) have stated that larger particles are superior to small or medium particles in improving the eggshell strength and weight. Different calcium sources solubility and/or the period in lay could be responsible for the contrary results.

With respect to feeding time, results are in accordance with other researchers21who have reported egg weight and egg specific gravity were not affected by feeding time.

In current study feeding time at (9-pm vs 8-am) improved shell weight, shell thickness and egg shell (%). But there is no difference in egg weight simultaneity with shell weight, egg shell (%) and shell thickness in birds fed at 9-pm. This suggests that feeding later in the day didn’t affect oviducal transit times or egg formation time, as stated earlier (Backhouse & Gous, 2005Backhouse, D., & Gous, R. M. (2005). The effect of feeding time on shell quality and oviposition time in broiler breeders. British Poultry Science, 46(2), 255-259. ). Therefore, feeding later in day influences the shell weight by providing a greater proportion of retained calcium in the gastrointestinal tract at the commencement of shell formation than morning-fed birds.35 These results are in agreement with Backhouse and Gous (2005Backhouse, D., & Gous, R. M. (2005). The effect of feeding time on shell quality and oviposition time in broiler breeders. British Poultry Science, 46(2), 255-259. ).

SWUSA showed a significant improvement by feeding oyster shell particle size 2-4 mm and nightly feeding. Egg Surface Area (ESA) followed by a reduction in treatments with Ca particle size 1-2 mm in comparison with control, suggesting the more potent effect of Ca particle size on these two characteristics rather than time of feeding. Increasing calcium concentration in egg shell refers to improve numerical calcium concentration in plasma (Table 4). Oyster shell with coarse particles (2-4 mm) vs medium (1-2 mm) increased calcium concentration in excreta (Table 4) which may be attributed to lower solubility. Accordingly, Zhang and Coon (1997Zhang, B., & Coon, C. N. (1997). Improved in vitro methods for determining limestone and oyster shell solubility. Journal of Applied Poultry Research, 6(1), 94-99. ) have reported that larger particle size significantly increased calcium concentration in excreta. Large particle size of oyster shell in diet could be lead to improve calcium release and absorption in body, therefore increase Ca turn over and consequently calcium concentration in excreta. From these results, it has been arisen that Ca retention as a percentage of Ca ingestion decreased with increasing Ca particle size. Diets containing coarse particles (2-4 mm) numerically increased Ca concentration in gizzard digesta (Table 4). Egg shell quality improvement in these treatments may be attributed to lower solubility and gradually release of Ca in gastrointestinal tract by large particles. As it has been shown that larger particles of oyster shell and limestone have lower solubility than small particle size In-vitro (Saunders-Blades et al., 2009Saunders-Blades, J. L., MacIsaac, J. L., Korver, D. R., & Anderson, D. M. (2009). The effect of calcium source and particle size on the production performance and bone quality of laying hens. Poultry Science , 88(2), 338-353. doi: 10.3382/ps.2008-00278.
https://doi.org/10.3382/ps.2008-00278....
).

Overall, when finely particles of oyster shell are substituted partially with larger particle size releasing of Ca become slowly and steadily, which in combination with delay feeding could supply Ca more closely to shell formation time.

Conclusion

Egg shell quality and calcium retention in body increased by a dietary treatment containing 50% of total Ca as coarse particle size (2-4 mm) rather than medium and ground (1-2 mm and <1 mm respectively) of oyster shell. Feeding time at 9-pm increased the shell weight and shell thickness. Calcium content in egg shell increased by substituting coarse oyster shell at level of 50% of total Ca and feeding time at 9-pm.

Acknowledgements

The authors gratefully acknowledge Department of Animal Science of Bu-Ali Sina University for financial support

References

  • Araujo, J. A., Silva, J. H. V., Costa, F. G. P., Sousa, J. M. B., Givisiez, P. E. N., & Sakomura, N. K. (2011). Effect of the levels of calcium and particle size of limestone on laying hens. Revista Brasileira de Zootecnia, 40(5), 997-1005. doi: /10.1590/S1516-35982011000500009.
    » https://doi.org//10.1590/S1516-35982011000500009.
  • Backhouse, D., & Gous, R. M. (2005). The effect of feeding time on shell quality and oviposition time in broiler breeders. British Poultry Science, 46(2), 255-259.
  • Bölükbasi, S. C., Çelebi, S., & Utlu, N. (2005). The effects of calcium and vitamin D in diet on plasma calcium and phosphorus, egg shell calcium, and phosphorus levels of laying hens in late laying production period. International Journal of Poultry Science, 4(8), 600-603.
  • Bootwalla, S. M., Wilson, H. R., & Harms, R. H. (1983). Performance of broiler breeders on different feeding systems. Poultry Science, 62(12), 2321-2325. doi: 10.3382/ps.0622321.
    » https://doi.org/10.3382/ps.0622321.
  • De Witt, F. H., Kuleile, N. P., Van der Merwe, H. J., & Fair, M. D. (2008). Influence of limestone particle size on egg production and eggshell quality of layers. World Poultry Science Journal, 64, 411.
  • Ekmay, R. D., & Coon, C. N. (2011). An examination of the P requirements of broiler breeders for performance, progeny quality and P balance 2. Ca particle size. International Journal of Poultry Science , 10(10), 760-765.
  • Guinotte, F., & Nys, Y. (1991). Effects of particle size and origin of calcium sources on eggshell quality and bone mineralization in egg laying hens. Poultry Science , 70(3), 583-592. doi: 10.3382/ps.0700583.
    » https://doi.org/10.3382/ps.0700583.
  • Guo, X. Y., & Kim, I. H. (2012). Impacts of limestone multi-particle size on production performance, egg shell quality, and egg quality in laying hens. Asian-Australasian Journal of Animal Sciences, 25(6), 839-844. doi: 10.5713/ajas.2011.11468.
    » https://doi.org/10.5713/ajas.2011.11468.
  • Ito, D. T., Faria, D. E., Kuwano, E. A., Junqueira, O. M., & Araujo, L. F. (2006). Effects of dietary calcium fractionation and limestone particle size on the performance and egg quality of commercial laying hens. Acta Scientiarum-Animal Sciences, 28(2), 187-195.
  • Jardim Filho, R. M., Stringhini, J. H., Café, M. B., Leandro, N. S. M., Cunha, W. C. P., & Nascimento, J. (2005). The influence of limestone source and particles sizes on performance and eggshell quality of commercial laying hens. Acta Scientiarum-Animal Sciences , 27(1), 35-41.
  • Keshavarz, K. (1998). Investigation on the possibility of reducing protein, phosphorus, and calcium requirements of laying hens by manipulation of time of access to these nutrients. Poultry Science , 77(9), 1320-1332.
  • Koreleski, J., & Šwiątkiewicz, S. (2004). Calcium from limestone meal and grit in laying hen diets-effect on performance, eggshell and bone. Journal of Animal and Feed Sciences, 13(4), 635-645.
  • Kul, S., & Seker, I. (2004). Phenotypic correlations between some external and internal egg quality traits in the Japanese quail (Coturnix coturnix japonica). International Journal of Poultry Science , 3(6), 400-405.
  • Lichovnikova, M. (2007). The effect of dietary calcium source, concentration and particle size on calcium retention, eggshell quality and overall calcium requirement in laying hens. British Poultry Science , 48(1), 71-75.
  • McNaughton, J. L., & Deaton, J. W. (1980). Effect of calcium source and particle size on calcium utilization. Poultry Science , 59(7), 1568.
  • Murata, L. S., Santana, A. P., Jardim Filho, R. M., & Ariki, J. (2009). Effects of calcium levels and limestone on laying hen performance and egg shell quality. Biotemas, 22(1), 103-110.
  • Nam, K.-T., Lee, H.-A., Joo, Y.-J., Kim, K.-H., & Kang, C.-W. (1998). Influence of builder's sand on the TME of linseed for poultry. Animal Feed Science and Technology, 72(1-2), 199-201. doi: 10.1016/S0377-8401(97)00176-4.
    » https://doi.org/10.1016/S0377-8401(97)00176-4.
  • Narushin, V. G. (2001). What egg parameters predict best its shell strength?. In Proceedings of the IX European Symposium on the Quality of Eggs and Egg Products, Kusadasi, Turkey (p. 349-355).
  • Narushin, V. G., & Romanov, M. N. (2002). Egg physical characteristics and hatchability. World's Poultry Science Journal, 58(3), 297-303.
  • Pavlovski, Z., Vitorović, D., Lukić, M., & Spasojević, I. (2003). Improving eggshell quality by replacement of pulverised limestone by granular limestone in the hen diet. Acta veterinaria, 53(1), 35-40.
  • Pelicia, K., Mourao, J. L. M., Garcia, E. A., Pinheiro, V. M. C., Berto, D. A., Molino, A. B., ... Silva, A. P. (2011). Effects of dietary calcium levels and limestone particicle size on the performance, tibia and blood of laying hens. Revista Brasileira de Ciência Avícola, 13(1), 29-34. doi: 10.1590/S1516-635X2011000100005.
    » https://doi.org/10.1590/S1516-635X2011000100005.
  • Rao, K. S., & Roland, S.R. (1989). Influence of dietary calcium level and particle size of calcium source on in vivo calcium solubilization by commercial Leghorns. Poultry Science , 68(11), 1499-1505.
  • Richards, M. P. (2003). Genetic regulation of feed intake and energy balance in poultry. Poultry Science , 82(6), 907-916. doi: 10.1093/ps/82.6.907.
    » https://doi.org/10.1093/ps/82.6.907.
  • Roland, S. R. (1988). Research note: egg shell problems: estimates of incidence and economic impact. Poultry Science , 67(12), 1801-1803. doi: 10.3382/ps.0671801.
    » https://doi.org/10.3382/ps.0671801.
  • Sá, L. M., Gomes, P. C., Albino, L. F. T., Rostagno, H. S., & D'Agostini, P. (2004). Calcium requirement and bioavailability of some feedstuffs for broiler chicks from 1 to 21 days old. Revista Brasileira de Zootecnia , 33(1), 157-168.
  • Statistical Analysis System [SAS]. (2004). SAS/STAT User guide, Version 9.1.2 Cary, NC: SAS Institute Inc.
  • Saunders-Blades, J. L., MacIsaac, J. L., Korver, D. R., & Anderson, D. M. (2009). The effect of calcium source and particle size on the production performance and bone quality of laying hens. Poultry Science , 88(2), 338-353. doi: 10.3382/ps.2008-00278.
    » https://doi.org/10.3382/ps.2008-00278.
  • Skřivan, M., Marounek, M., Bubancova, I., & Podsedníček, M. (2010). Influence of limestone particle size on performance and egg quality in laying hens aged 24-36 weeks and 56-68 weeks. Animal Feed Science and Technology , 158(1-2), 110-114. doi: 10.1016/j.anifeedsci.2010.03.018.
    » https://doi.org/10.1016/j.anifeedsci.2010.03.018.
  • Sooncharenying, S., & Edwards, H. M. (1989). Modelling the relationships of egg weight, specific gravity, shell calcium and shell thickness. British Poultry Science , 30(3), 623-631.
  • William, N. S., Horacio, S. R., Paulo, R. S., Luis, F. U., & Marcelo, A. S. (2006). Nutritional requirement of calcium in White laying hens from 46 to 62 Wk of age. International Journal of Poultry Science , 5(2), 181-184.
  • Wilson, H. R., & Keeling, L. J. (1991). Effect of time of feeding on oviposition time and production parameters in broiler breeders. Poultry Science , 70(2), 254-259. doi: 10.3382/ps.0700254.
    » https://doi.org/10.3382/ps.0700254.
  • Yo, T., Siegel, P. B., Guerin, H., & Picard, M. (1997). Self-selection of dietary protein and energy by broilers grown under a tropical climate: effect of feed particle size on the feed choice. Poultry Science , 76(11), 1467-1473.
  • Zhang, B., & Coon, C. N. (1997). Improved in vitro methods for determining limestone and oyster shell solubility. Journal of Applied Poultry Research, 6(1), 94-99.

Publication Dates

  • Publication in this collection
    25 Feb 2019
  • Date of issue
    2019

History

  • Received
    21 May 2018
  • Accepted
    05 Sept 2018
Editora da Universidade Estadual de Maringá - EDUEM Av. Colombo, 5790, bloco 40, CEP 87020-900 , Tel. (55 44) 3011-4253, Fax (55 44) 3011-1392 - Maringá - PR - Brazil
E-mail: actaanim@uem.br